IllustrationDT*: THE CONTACT STATED THERE WAS A SMELL OF GAS AND A FUEL LEAK OBSERVED UNDER THE VEHICLE. IT WAS DRIVEN TO AN INDEPENDENT REPAIR SHOP WHO REPLACED THE FUEL TANK AND THE FUEL LINES. THE DEALER HAS BEEN ALERTED. THE FUEL TANK AND FUEL LINES HAD RUSTED AND WERE LEAKING GASOLINE. UPDATED 08/25/06. *JB
1999 Kia Sportage
Owner reports · Recalls · Investigations
More warning signs than most Sportage years
Owner complaints for the 1999 Kia Sportage are substantially higher than the model-year median of 122.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sportage years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1025–50K
2150–75K
1375–100K
17100–150K
7150K+
71 reports with mileage · 213 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
27 crash reports3 fire reports12 injury reports
What owners actually said
284 reportsDRIVING 75 MPH ON I-74 IN ILLINOIS, TURN SIGNAL UNIT ON PASSENGER FRONT SIDE FELL OUT OF PLACE AND INTO FRONT TIRE. IT THEN SHREDDED CAUSING MY VEHICLE TO BECOME UNCONTROLLABLE AS WELL AS MAKING IT HARD O STEER PROPERLY. I WAS ABLE TO GET TO THE SIDE OF THE INTERSTATE AND LUCKILY NO ONE WAS INJURED. *NM
NOTICED SMELL OF GAS. REPLACED GAS TANK AND FUEL PUMP/SENDER UNIT. *JB
I HAVE A 1999 KIA SPORTAGE WITH LESS THAN 35,000 MILES ON IT AS OF JULY 5, 2006. IN NOVEMBER OF 2005 I STARTED NOTICING A REALLY STRONG FUEL SMELL. SHORTLY THEREAFTER I NOTICED FLUID LEAKING FROM THE REAR OF MY VEHICLE. I TOOK IT IN AROUND THANKSGIVING TO FIND OUT THAT THE GAS TANK HAD TO BE REPLACED. I HAD TO PAY ALMOST $1,…
Read full complaint
I HAVE A 1999 KIA SPORTAGE WITH LESS THAN 35,000 MILES ON IT AS OF JULY 5, 2006. IN NOVEMBER OF 2005 I STARTED NOTICING A REALLY STRONG FUEL SMELL. SHORTLY THEREAFTER I NOTICED FLUID LEAKING FROM THE REAR OF MY VEHICLE. I TOOK IT IN AROUND THANKSGIVING TO FIND OUT THAT THE GAS TANK HAD TO BE REPLACED. I HAD TO PAY ALMOST $1,000 FOR THIS REPAIR. ALSO, IN MAY OF 2006 POWER STEERING FLUID LEAKED ALL OVER MY GARAGE WHILE THE CAR WAS IN SUMMER STORAGE. UPON FURTHER INVESTIGATION IT IS DUE TO THE POWER STEERING PRESSURE HOSE DAMPING PIPE RUSTING OUT. THIS CAR HAS ALSO ALREADY HAVE TO GET NEW FRONT BRAKE ROTORS (RUSTED/WARPED) AS WELL AS A NEW EXHAUST PIPE SINCE THE PREVIOUSLY ONE RUSTED OFF THE MUFFLER. WITHIN THE FIRST COUPLE YEARS ONE OF THE BEARINGS WENT BAD AND THEY ENDED UP REPLACING THE WHOLE FRONT AXLE UNIT. THIS CAR HAS HAD MANY PROBLEMS AND WITH LESS THAN 35,000 MILES ON IT BASICALLY MAKES ME SICK TO MY STOMACH. I AM REPORTING THIS TO YOU AFTER READING ON WWW.KIA.COM TECHNICAL/OWNERS SECTION ABOUT A "SERVICE CAMPAIGN" FOR THE LEAKING FUEL TANKS IN MAY 2006. NOBODY HAS NOTIFIED ME AND I JUST HAPPENED TO RUN INTO MYSELF AS I WAS RESEARCHING INFORMATION RELATED TO THE POWER STEERING SYSTEM SINCE THAT STARTED LEAKING IN MAY 2006. *JB
DT*: THE CONTACT STATED THE VEHICLES GAS TANK WAS LEAKING. A CERTIFIED INDEPENDENT MECHANIC DETERMINED THE CAUSE TO BE A DEFECT. THE VEHICLE WAS NOT TA KEN INTO DEALERS FOR CONFIRMATION.
DT*: THE CONTACT STATED THAT THE VEHICLE STALLED DUE TO A LOSS OF CIRCUIT CONTINUITY. THERE IS A RECALL, #99V325000, PERTAINING TO THE ELECTRICAL SYSTEM: WIRING. THE VEHICLE HAS THE SAME CHARACTERISTICS AS LISTED IN THE RECALL HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
1999 KIA SPORTAGE SEAT BELT LOST ALL TENSION AND BECAME LOOSE. INERTIA REEL BROKE AND DISCONNECTED WHERE IT WAS ATTACHED TO THE BODY OR A HARD POINT. *TS *JB
THE CONTACT HAS A KIA SPORTAGE 1999 AND IT HAS A SEAT BELT PROBLEM. WHEN THE REAR DRIVER SEAT BUCKLE IS LATCHED IT DOES NOT LOCK OR MAKE A CLICKING SOUND DURING THE BUCKLING PROCESS. THIS PROBLEM OCCURRED 2 MONTHS AGO. THE CONTACT INFORMED THE LOCAL KIA SERVICE DEALER AND WAS TOLD THE REAR SEAT BELTS WERE NOT PART OF A RECALL …
Read full complaint
THE CONTACT HAS A KIA SPORTAGE 1999 AND IT HAS A SEAT BELT PROBLEM. WHEN THE REAR DRIVER SEAT BUCKLE IS LATCHED IT DOES NOT LOCK OR MAKE A CLICKING SOUND DURING THE BUCKLING PROCESS. THIS PROBLEM OCCURRED 2 MONTHS AGO. THE CONTACT INFORMED THE LOCAL KIA SERVICE DEALER AND WAS TOLD THE REAR SEAT BELTS WERE NOT PART OF A RECALL AND IF THEY NEEDED REPAIR THEY WOULD BE HAPPY TO INSTALL NEW ONES AT HIS COST. WHEN THE DEALER WAS INFORMED THE CONTACT HAD THE SAME PROBLEM WITH THE FRONT SEAT BELT THE DEALER TOLD THE CONTACT THE FRONT SEAT BELTS WILL BE REPAIRED AT NO COST. THE CONTACT WOULD LIKE THE AGENCY TO CONDUCT AN INVESTIGATION ON THE REAR SEAT BELTS *JB
DT: THE CONTACT STATED THE SEAT BELT ON THE DRIVER'S SIDE FRAYED. THE FRAYING WAS SO BAD THAT THE BUCKLE ASSEMBLY WOULD NOT SLIDE DOWN CORRECTLY. HE HAS BEEN IN CONTACT WITH KIA, AND THEY OFFERED NO FREE REMEDY. *AK
DT: THE CONTACT SMELLED GAS FUMES APPROXIMATELY ONE WEEK AGO. HE TOOK THE VEHICLE TO A LOCAL MECHANIC, AND HE FOUND THE SKID PLATE ON THE BOTTOM OF THE TANK HELD MOISTURE AGAINST THE TANK, AND CAUSED IT TO RUST. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. *AK
Official recalls
304V305000 · Seat Belts:front:buckle Assembly
Jun 24, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FRONT SAFETY BELT BUCKLES MAY EMIT A "CLICK" SOUND DURING THE BUCKLING PROCESS THAT IS SIMILAR TO THE SOUND EMITTED WHEN A BUCKLE IS BEING LATCHED, WHEN IT IS NOT.
Consequence & remedy
Consequence: THE LATCH CAN THEN PULL OUT OF THE BUCKLE WHEN TENSION IS APPLIED.
Remedy: DEALERS WILL REPLACE BOTH FRONT SEAT BELT BUCKLES. THE RECALL BEGAN AUGUST 16, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
99V325000 · Electrical System:wiring
Nov 19, 1999
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, LOOSENING THEM AND RESULTING IN A LOSS OF CIRCUIT CONTINUITY.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE ENGINE STALLING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SPRING CLIPS TO LOCK THE CONNECTORS TOGETHER. IN ADDITION, THE DEALERS WILL BE INSTRUCTED TO SOLDER A SPLICE IN THE WIRE HARNESS.
98V222000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Sep 15, 1998
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES WITHOUT AN ANTI-LOCK BRAKING SYSTEM (ABS). THE STEERING INTERMEDIATE SHAFT COUPLING CAN CONTACT A HYDRAULIC BRAKE PIPE CAUSING FLUID LEAKAGE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF REAR BRAKE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, INCREASE THE CLEARANCE BETWEEN THE BRAKE PIPE AND STEERING INTERMEDIATE SHAFT COUPLING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
8EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06002 · Fuel Tank Leakage
Opened Jan 4, 2006 · Closed May 9, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON JANUARY 4, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FUEL LEAKAGE FROM THE STEEL FUEL STORAGE TANK IN CERTAIN MODEL YEAR 1999-2000 KIA SPORTAGE VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON JANUARY 25, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER KIA SPORTAGE VEHICLES.ODI IS AWARE OF 40 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE FUEL STORAGE TANK LEAKAGE IN THE SUBJECT VEHICLES.ANALYSIS OF MANUFACTURER DATA INDICATES THAT ALLEGED FUEL LEAKAGE AT OR NEAR THE STORAGE TANK MAY BE ATTRIBUTED TO SEVERAL DIFFERENT FAILURE MODES INVOLVING THE FUEL CONTAINMENT AND DISTRIBUTION SYSTEM.KIA HAS IDENTIFIED CORROSION AS A PRIMARY CAUSAL FACTOR RELATED TO FUEL STORAGE TANK COMPLAINTS AND CONTINUED FUEL SYSTEM PART SALES.ACCORDING TO KIA, FUEL TANK CORROSION CLAIMS RELATED TO LEAKAGE CAN BE DIVIDED INTO TWO CATEGORIES: LOWER TANK CLAIMS ASSOCIATED WITH EXTERIOR CORROSION DUE TO DISRUPTION OF THE POLYVINYL CHLORIDE (PVC) PROTECTIVE COATING AND UPPER TANK CLAIMS ASSOCIATED WITH CORROSION AT THE FUEL SENDING UNIT MOUNTING PLATE AREA.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FUEL TANK CORROSION RESULTING IN LEAKAGE IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-007) TO FURTHER STUDY THE FREQUENCY, SCOPE, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02002 · Windshield Wiper
Opened Jan 9, 2002 · Closed Aug 7, 2002
Status: closed (inferred from source dates) · Visibility
No summary supplied.
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.