NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
79 reportsClear category filter50,280 miles · Jan 15, 2004
Engine And Engine CoolingUnknown Or Other
\T\T\T\T 11/16/02\TGENERAL DIAGNOSTICS AFTER PURCHASE\T NO STORED CODES \T $75.50 \T\TTIMING CHECK - DISCONNECT BATTERY\T\T 11/29/02\TENGINE BUCKS ON ACCELERATION\T NO STORED CODES\T $87.26 \T BROKEN CENTER CONSOLE REPLACED\T\T 01/02/03\TENGINE STALLED - DIED…
Read full complaint
\T\T\T\T 11/16/02\TGENERAL DIAGNOSTICS AFTER PURCHASE\T NO STORED CODES \T $75.50 \T\TTIMING CHECK - DISCONNECT BATTERY\T\T 11/29/02\TENGINE BUCKS ON ACCELERATION\T NO STORED CODES\T $87.26 \T BROKEN CENTER CONSOLE REPLACED\T\T 01/02/03\TENGINE STALLED - DIED AFTER ONE WEEK'S TIME, NO DIAGNOSIS\T $70.88 * TOWED *\T\T 01/05/03\TEMAIL SENT TO: KIA CONSUMER AFFAIRS ADVISED OF POOR RUNNING CONDITION AND \T INFERIOR KIA SERVICE RECEIVED RESPONSE AS TO FOUR \T \T\T MANUFACTURER RECALLS NOT PERFORMED TO\T \T\T DATE ON VEHICLE\T 01/13/03\T*SC014 RECALL - ENGINE WIRING HARNESS\T RECALL PERFORMED\T $102.44 *SC022 RECALL - MANIFOLD CATALYTIC CONVERTER\T RECALL PERFORMED\T \T\T*FRONT WHEEL BEARING SEALS LEAKING/LOOSE REPLACED FRONT HUB ASSEMBLIES\T \T\T*COOLANT LEAKING AT BYPASS HOSE\T R&R HOSE AND REPLACED SEALS\T \T\T*DETERMINED FRONT BUMPER REPLACED \T 01/17/03\T*EXHAUST MANIFOLD STUD BROKEN\T REMOVED MANIFOLD/DRILLED OUT BROKEN STUD\T AND REPLACED $77.77 \T\T*STUCK THERMOSTAT\T REPLACED THERMOSTAT\T 05/22/03\T52,500 MILE SERVICE\T\T$123.27 \T\T*WIPER BLADE CHECK - NOT OPERATING PROPERLY\T ADJUSTED WIPER ARMS/REPLACED BLADES\T \T\T\T OPERATING WORSE!\T \T\T*FRONT END SHAKING @ HIGH SPEEDS\T ROTATED TIRES - NO CHANGE!\T \T\T*REPLACE FRONT TURN SIGNAL ASSEMBLY\T COMPLETED SATISFACTORILY\T 05/23/03\TCAR DIED WHILE DRIVING - STALLED OUT AT IDLE\T WIRING HARNESS TO TCM SHORTING OUT\T $260.13 \T *TOWED* REMOVED TCM/CLEANED/REPAIRED\T TOTAL OUT OF POCKET REPAIRS (NOT INCLUDING WARRANTY ITEMS) $797.25
NHTSA ODI #10069808
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingSteeringSuspensionCrash
I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 19000 MILES ON IT BOUGHT NEW WITH ONLY 10 MILES ON IT BACK IN 99. THIS SUV HAS BEEN NOTHING BUT PROBLEMS FROM DAY ONE, WITH EVERYTHING FROM THE AC TO THE 4 WHEEL DRIVE NEEDING REPAIRED TWICE IN ONE DAY, TO THE MOST SERIOUS PROBLEM HAPPENING ON 8-19-02 WHEN MY RIGHT REAR ANTI SWAY B…
Read full complaint
I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 19000 MILES ON IT BOUGHT NEW WITH ONLY 10 MILES ON IT BACK IN 99. THIS SUV HAS BEEN NOTHING BUT PROBLEMS FROM DAY ONE, WITH EVERYTHING FROM THE AC TO THE 4 WHEEL DRIVE NEEDING REPAIRED TWICE IN ONE DAY, TO THE MOST SERIOUS PROBLEM HAPPENING ON 8-19-02 WHEN MY RIGHT REAR ANTI SWAY BAR BRACKET BREAKS AWAY FROM WHERE IT WAS WELDED ON THE FRAME IN THE FACTORY ( THE ORG. WELDS JUST BROKE ) AS MY DAUGHTER AND I ARE DRIVING THIS SUV HOME ONE EVENING CAUSING THIS SUV TO BE ALL OVER THE ROAD AND UNCONTROLLABLE. LUCKILY NO ONE WAS HURT OR KILLED BECAUSE OF THIS. KIA ACCEPTS NO RESPONSIBILTY FOR THIS. BUT IT WAS THERE WELDS DONE IN THERE FACTORY WHEN THEY MADE THIS SUV. THIS IS THE KIND OF SAFE PRODUCTS THAT KIA MAKES AND THE PUBLIC NEEDS TO BE AWARE OF THIS FACT AND HOW MUCH THIS CO. VALUES A HUMAN LIFE.
NHTSA ODI #10069532
40,000 miles · Oct 23, 2003
Engine And Engine Cooling
CATALYTIC CONVERTER WAS RECALLED AND REPLACED BY THE DEALER IN 2001, RATTLING AND NOT WORKING CORRECTLY SINCE (ENGINE LIGHT ON - DIAGNOSTIC SAYS CONVERTER), RETURN TO DEALER APPROXIMATELY. 2 MONTHS LATER, THEY VERIFIED EVERYTHING WAS OK, WOULD NOT PASS SMOG THE NEXT YEAR, RETURNED TO DEALER THEY SAY IT IS THE CONVERTER AGAIN, WI…
Read full complaint
CATALYTIC CONVERTER WAS RECALLED AND REPLACED BY THE DEALER IN 2001, RATTLING AND NOT WORKING CORRECTLY SINCE (ENGINE LIGHT ON - DIAGNOSTIC SAYS CONVERTER), RETURN TO DEALER APPROXIMATELY. 2 MONTHS LATER, THEY VERIFIED EVERYTHING WAS OK, WOULD NOT PASS SMOG THE NEXT YEAR, RETURNED TO DEALER THEY SAY IT IS THE CONVERTER AGAIN, WILL NOT PAY TO REPLACE AGAIN. CAR RUNS WITH NO POWER AND IS A DANGER ON THE ROAD. *LA
NHTSA ODI #10043435
56,000 miles · Oct 10, 2003
Engine And Engine Cooling
WHILE DRIVING AT ANY SPEED VEHICLE WILL INTERMITTENTLY STALL. AFTER A FEW MINUTES SITTING VEHICLE CAN BE RESTARTED. MANUFACTURER AND DEALER HAVE BEEN NOTIFIED OF THE PROBLEM.*AK
NHTSA ODI #10042731
Mileage unknown · Sep 1, 2003
Engine And Engine Cooling
SMELL OF EXHAUST COMING FROM UNDER HOOD AGAIN. HAS BEEN IN SHOP NUMBER OF TIMES, CHECK ENGINE CAME ON 50 MILES AFTER LEAVING DEALERSHIP FOR REPAIRS.RUNS VERY BAD, SAME AS BEFORE REPAIRS. HAS BEEN OUT OF WARRNETY FOR WHILE, PAY FOR REPAIRS OUT OF POCKET. *AK
NHTSA ODI #10036991
Mileage unknown · Jun 26, 2003
Engine And Engine Cooling
1999 KIA SPORTAGE 4DR ECM TROUBLE CODE 171 - LEFT BANK LEAN. DEALERSHIP HAS HAD VEHICLE FOR OVER A WEEK AND IS NOT ABLE TO FIX. *AK
NHTSA ODI #10023829
43,000 miles · Jun 24, 2003
Engine And Engine Cooling
DURING VEHICLE OPERATION EXHAUST FUMES ARE ENTERING THE PASSENGER CABIN.*AK
NHTSA ODI #10024812
36,000 miles · Jun 22, 2003
Engine And Engine Cooling
99 KIA SPORTAGE SURGES WHEN STARTING AND IDLES SO ROUGH WHEN STOPPED THAT YOU THINK THE CAR WILL DIE, HAS DIED A FEW TIMES. DEALER HAS NOT BEEN ABLE TO DETERMINE THE CAUSE TO REPAIR. ALL RECALL WORK WAS DONE, INCLUDING THE WIRING HARNESS FIX SC014, BUT THERE WAS NO SYMPTOM OF PROBLEM THEN. EXTENDED WARRANTY HAS EXPIRED, AND C…
Read full complaint
99 KIA SPORTAGE SURGES WHEN STARTING AND IDLES SO ROUGH WHEN STOPPED THAT YOU THINK THE CAR WILL DIE, HAS DIED A FEW TIMES. DEALER HAS NOT BEEN ABLE TO DETERMINE THE CAUSE TO REPAIR. ALL RECALL WORK WAS DONE, INCLUDING THE WIRING HARNESS FIX SC014, BUT THERE WAS NO SYMPTOM OF PROBLEM THEN. EXTENDED WARRANTY HAS EXPIRED, AND CONTINUALLY FINDING PROBLEM WITH CAR. ALSO TAIL PIPE RECENTLY BROKE OFF HAD TO BE REPLACED. I NOW HAVE A SPREADSHEET OF THE PROBLEMS AND REPAIRS. WOULD LIKE TO FIX THIS PROBLEM IF I KNEW WHAT IT WAS. HAD MASS AIR FLOW SENSOR, THROTTLE POSITION SENSOR, NUMEROUS OTHER PARTS REPLACED AS WELL AS A TUNE UP. ALSO THE EXHAUST SMELLS BAD. ENGINE DOESN'T HAVE MUCH PICK UP ON SMALL HILLS EITHER. *NLM
NHTSA ODI #10023549
32,609 miles · Jun 9, 2003
Engine And Engine Cooling
ENGINE BELT AND PULLEYS FAIL EVERY 3 MONTHS AND HAVE TO BE REPLACED. CAUSE UNKNOWN.*AK
NHTSA ODI #10022684
10,000 miles · Mar 27, 2003
Engine And Engine Cooling
EXHAUST IS SUCKED INTO THE PASSENGER COMPARTMENT WHEN THE REAR VINYL WINDOW RELEASES FROM THE TRACK THAT IS SUPPOSE TO KEEP IT SECURED AND CLOSED. THE EXHAUST CAUSES ILLNESS AND HEADACHES. THE DESIGN OF THE WINDOW AND EXHAUST PIPE DO NOT ALLOW FOR AN EXHAUST FREE PASSENGER COMPARTMENT. *JB
NHTSA ODI #10013571
NHTSA investigations
8EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06002 · Fuel Tank Leakage
Opened Jan 4, 2006 · Closed May 9, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON JANUARY 4, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FUEL LEAKAGE FROM THE STEEL FUEL STORAGE TANK IN CERTAIN MODEL YEAR 1999-2000 KIA SPORTAGE VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON JANUARY 25, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER KIA SPORTAGE VEHICLES.ODI IS AWARE OF 40 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE FUEL STORAGE TANK LEAKAGE IN THE SUBJECT VEHICLES.ANALYSIS OF MANUFACTURER DATA INDICATES THAT ALLEGED FUEL LEAKAGE AT OR NEAR THE STORAGE TANK MAY BE ATTRIBUTED TO SEVERAL DIFFERENT FAILURE MODES INVOLVING THE FUEL CONTAINMENT AND DISTRIBUTION SYSTEM.KIA HAS IDENTIFIED CORROSION AS A PRIMARY CAUSAL FACTOR RELATED TO FUEL STORAGE TANK COMPLAINTS AND CONTINUED FUEL SYSTEM PART SALES.ACCORDING TO KIA, FUEL TANK CORROSION CLAIMS RELATED TO LEAKAGE CAN BE DIVIDED INTO TWO CATEGORIES: LOWER TANK CLAIMS ASSOCIATED WITH EXTERIOR CORROSION DUE TO DISRUPTION OF THE POLYVINYL CHLORIDE (PVC) PROTECTIVE COATING AND UPPER TANK CLAIMS ASSOCIATED WITH CORROSION AT THE FUEL SENDING UNIT MOUNTING PLATE AREA.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FUEL TANK CORROSION RESULTING IN LEAKAGE IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-007) TO FURTHER STUDY THE FREQUENCY, SCOPE, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02002 · Windshield Wiper
Opened Jan 9, 2002 · Closed Aug 7, 2002
Status: closed (inferred from source dates) · Visibility
No summary supplied.
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.
Illustration