NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
79 reportsClear category filter134,197 miles · Mar 4, 2010
Engine And Engine Cooling
KEYWAY ON CRANKSHAFT WHERE TIMING GEAR ATTACHES WEARS OUT PREMATURELY AND CAN RESULT IN HAVING TO REPLACE ENGINE! I HAVE REPLACE THROTTLE POSITION SENSOR, FUEL FILTER, AND KNOCK SENSOR ALSO THE MASS AIRFLOW SENSOR AND TIMING BELT WERE REPLACED AS THERE APPEARED TO BE A TIMING ISSUE COULD NOT FIND PROBLEM SO TOOK TO KIA DEALER TO…
Read full complaint
KEYWAY ON CRANKSHAFT WHERE TIMING GEAR ATTACHES WEARS OUT PREMATURELY AND CAN RESULT IN HAVING TO REPLACE ENGINE! I HAVE REPLACE THROTTLE POSITION SENSOR, FUEL FILTER, AND KNOCK SENSOR ALSO THE MASS AIRFLOW SENSOR AND TIMING BELT WERE REPLACED AS THERE APPEARED TO BE A TIMING ISSUE COULD NOT FIND PROBLEM SO TOOK TO KIA DEALER TO FIND THE KEYWAY ON CRANKSHAFT TO BE SO WORN YOU COULD ALMOST TURN GEAR ALL THE WAY AROUND! IN ALL THE YEARS I HAVE BEEN WORKING ON VEHICLES THIS IS THE FIRST TIME I HAVE EVER SEEN THIS AND IS VERY OBVIOUSLY A MANUFACTURER DEFECT! *TR
NHTSA ODI #10316796
Mileage unknown · Sep 8, 2008
Engine And Engine CoolingService Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE IS GRADUALLY LEAKING BRAKE FLUID AND HE IS CONSTANTLY HAVING TO ADD MORE FLUID. ALSO, THE VEHICLE STALLS INTERMITTENTLY WHILE DRIVING BETWEEN 30-50 MPH AND MERGING INTO TRAFFIC. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 98V222000 (SERVICE…
Read full complaint
TL*THE CONTACT OWNS A 1999 KIA SPORTAGE. THE CONTACT STATED THAT THE VEHICLE IS GRADUALLY LEAKING BRAKE FLUID AND HE IS CONSTANTLY HAVING TO ADD MORE FLUID. ALSO, THE VEHICLE STALLS INTERMITTENTLY WHILE DRIVING BETWEEN 30-50 MPH AND MERGING INTO TRAFFIC. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBERS 98V222000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING AND FITTINGS) AND 99V325000 (ELECTRICAL SYSTEM:WIRING); HOWEVER, THE DEALER WILL REPAIR THE VEHICLE ACCORDING TO NHTSA CAMPAIGN ID NUMBER 04V305000 (SEAT BELTS:FRONT:BUCKLE ASSEMBLY). THE CURRENT MILEAGE WAS 107,812 AND THE FAILURE MILEAGE WAS UNAVAILABLE.
NHTSA ODI #10241352
76,000 miles · May 23, 2007
Engine And Engine CoolingSeat Belts
TL*THE CONTACT OWNS A 1999 KIA SPORTAGE. THE SEAT BELT RETRACTOR ON THE DRIVERS SIDE HAS FAILED. THE AIR CONDITIONER IS ALSO LEAKING INTO THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 80,000 AND FAILURE MILEAGE WAS 76,000.
NHTSA ODI #10191567
Mileage unknown · Aug 27, 2006
Electrical SystemEngine And Engine CoolingEquipmentCrash
THIS KIA WAS PURCHASED NEW AND IS A ONE OWNER CAR. IT HAS HAD 2 MASTER CYLINDERS, AND 4 SETS OF BRAKE PADS. THE CAR CURRENTLY HAS 50,000 MILES ON IT. THE CAR SLIDES TO THE RIGHT ON WET ROADS AND DOES NOT STOP UNTIL IT HITS SOMETHING OR SLOWS TO A STOP. I HAVE SLID 2 TIMES, REAR ENDED SOMEONE THE 3RD, AND MY SON HIT A LIGHT P…
Read full complaint
THIS KIA WAS PURCHASED NEW AND IS A ONE OWNER CAR. IT HAS HAD 2 MASTER CYLINDERS, AND 4 SETS OF BRAKE PADS. THE CAR CURRENTLY HAS 50,000 MILES ON IT. THE CAR SLIDES TO THE RIGHT ON WET ROADS AND DOES NOT STOP UNTIL IT HITS SOMETHING OR SLOWS TO A STOP. I HAVE SLID 2 TIMES, REAR ENDED SOMEONE THE 3RD, AND MY SON HIT A LIGHT POLE. THE OTHER TIMES THE BRAKES MAY OR MAY NOT WORK. THE PROBLEM IS WORSE DURING RAINY WEATHER. THE BRAKES GO TO THE FLOOR AND THE CAR DOES NOT STOP. AT TIMES THE BRAKES VIBRATE. THIS CAR HAS HAD A NEW CLOTH TOP, NEW AIR CONDITIONING 2X, 5 CATALYTIC CONVERTERS, NEW CARPET FROM THE AIR LEAKING AND MOLDING, NEW SEAT COVERS AS THEY RIPPED, NEW BRAKES, ROTORS, PADS SEVERAL ITEMS I HAVE LOST COUNT, THE CHECK ENGINE LIGHT COMES ON, THE CAR HAS BEEN RE-WIRED, AT TIMES THE CAR WON'T ACCELERATE IF THE AIR CONDITIONER IS ON. LAST NIGHT THE HIGHWAY PATROL OFFICE WANTED TO KNOW WHY I WOULD ENDANGER MY SON'S LIFE IN A CAR THAT WON'T STOP OR SLIDES. THAT IS A GOOD QUESTION. WHY ARE ANY OF THESE MODELS STILL ON THE HIGHWAY WHEN THERE ARE SO MANY THINGS WRONG WITH THEM. IN LOOKING AT THE COMPLAINTS THERE WERE MANY THAT DEALT WITH THE BRAKES. AT THIS POINT IS THERE ANY RECOURSE WITH THE CAR? I DON'T FEEL THAT I CAN SELL IT OUTRIGHT HONESTLY AND PUT SOMEONES LIFE IN DANGER. THE HIGHWAY PATROL OFFICER MADE ME FEEL LIKE A NEGLECTFUL PARENT BY EVEN LETTING MY SON DRIVE THE CAR. WE EVEN PARKED IT FOR 6 MONTHS TRYING TO DECIDE WHAT TO DO WITH THE CAR. MY SON'S CAR WAS IN THE REPAIR SHOP, SO HE TOOK THE KIA. I FEEL THAT THE CAR IS A DEATH TRAP. *JB
NHTSA ODI #10166674
65,000 miles · Aug 21, 2006
Electrical SystemEngine And Engine CoolingSteering
DT*: THE CONTACT STATED THE VEHICLE STALLS AT VARIOUS SPEEDS AND INTERMITTENTLY WILL NOT START. AFTER SITTING FOR A WHILE THE VEHICLE WILL RESTART. THE DEALERSHIP HAS BEEN INFORMED. THERE ARE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE VEHICLE STALLING. THE TEMPERATURE GAUGE WAS ACTING ERRATIC. THE POWER STEERING BELT WAS…
Read full complaint
DT*: THE CONTACT STATED THE VEHICLE STALLS AT VARIOUS SPEEDS AND INTERMITTENTLY WILL NOT START. AFTER SITTING FOR A WHILE THE VEHICLE WILL RESTART. THE DEALERSHIP HAS BEEN INFORMED. THERE ARE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE VEHICLE STALLING. THE TEMPERATURE GAUGE WAS ACTING ERRATIC. THE POWER STEERING BELT WAS REPLACED. UPDATED 09/13/06. *JB
NHTSA ODI #10166087
28,000 miles · Jul 5, 2006
Engine And Engine CoolingFuel System, GasolinePower Train
I HAVE A 1999 KIA SPORTAGE WITH LESS THAN 35,000 MILES ON IT AS OF JULY 5, 2006. IN NOVEMBER OF 2005 I STARTED NOTICING A REALLY STRONG FUEL SMELL. SHORTLY THEREAFTER I NOTICED FLUID LEAKING FROM THE REAR OF MY VEHICLE. I TOOK IT IN AROUND THANKSGIVING TO FIND OUT THAT THE GAS TANK HAD TO BE REPLACED. I HAD TO PAY ALMOST $1,…
Read full complaint
I HAVE A 1999 KIA SPORTAGE WITH LESS THAN 35,000 MILES ON IT AS OF JULY 5, 2006. IN NOVEMBER OF 2005 I STARTED NOTICING A REALLY STRONG FUEL SMELL. SHORTLY THEREAFTER I NOTICED FLUID LEAKING FROM THE REAR OF MY VEHICLE. I TOOK IT IN AROUND THANKSGIVING TO FIND OUT THAT THE GAS TANK HAD TO BE REPLACED. I HAD TO PAY ALMOST $1,000 FOR THIS REPAIR. ALSO, IN MAY OF 2006 POWER STEERING FLUID LEAKED ALL OVER MY GARAGE WHILE THE CAR WAS IN SUMMER STORAGE. UPON FURTHER INVESTIGATION IT IS DUE TO THE POWER STEERING PRESSURE HOSE DAMPING PIPE RUSTING OUT. THIS CAR HAS ALSO ALREADY HAVE TO GET NEW FRONT BRAKE ROTORS (RUSTED/WARPED) AS WELL AS A NEW EXHAUST PIPE SINCE THE PREVIOUSLY ONE RUSTED OFF THE MUFFLER. WITHIN THE FIRST COUPLE YEARS ONE OF THE BEARINGS WENT BAD AND THEY ENDED UP REPLACING THE WHOLE FRONT AXLE UNIT. THIS CAR HAS HAD MANY PROBLEMS AND WITH LESS THAN 35,000 MILES ON IT BASICALLY MAKES ME SICK TO MY STOMACH. I AM REPORTING THIS TO YOU AFTER READING ON WWW.KIA.COM TECHNICAL/OWNERS SECTION ABOUT A "SERVICE CAMPAIGN" FOR THE LEAKING FUEL TANKS IN MAY 2006. NOBODY HAS NOTIFIED ME AND I JUST HAPPENED TO RUN INTO MYSELF AS I WAS RESEARCHING INFORMATION RELATED TO THE POWER STEERING SYSTEM SINCE THAT STARTED LEAKING IN MAY 2006. *JB
NHTSA ODI #10161481
62,500 miles · Aug 30, 2005
Engine And Engine Cooling
1999 KIA SPORTAGE HAS HAD TIMING BELT REPLACED THREE TIMES SINCE I BOUGHT CAR NEW IN 1999. WHILE TRAVELING ON NJ TURNPIKE, WHAT WE BELIEVED WAS THE TIMING BELT YET AGAIN WAS THE CRANK SHAFT AT THE HARMONIC BALANCE (WHICH HOLDS THE TIMING BELT IN PLACE) COMPLETELY SNAPPED INTO TWO PIECES INSIDE THE ENGINE. I SPOKE TO SEVERAL DIF…
Read full complaint
1999 KIA SPORTAGE HAS HAD TIMING BELT REPLACED THREE TIMES SINCE I BOUGHT CAR NEW IN 1999. WHILE TRAVELING ON NJ TURNPIKE, WHAT WE BELIEVED WAS THE TIMING BELT YET AGAIN WAS THE CRANK SHAFT AT THE HARMONIC BALANCE (WHICH HOLDS THE TIMING BELT IN PLACE) COMPLETELY SNAPPED INTO TWO PIECES INSIDE THE ENGINE. I SPOKE TO SEVERAL DIFFERENT KIA SERVICE DEPARTMENTS WHO ADVISED ME THAT THIS WAS NOT A NORMAL THING AND WAS IN NO WAY DUE TO SOMETHING WE COULD HAVE DONE. I WAS TOLD BY MY KIA DEALER THAT THE MANUFACTURERS WARRANTY HAD EXPIRED LAST YEAR AND THAT I WAS RESPONSIBLE FOR THE DEFECT IN THE KIA. THE FIRST THREE TIMES THAT THE TIMING BELT WAS REPLACED THE WARRANTY COVERED. NOW I AM TOLD I MUST PAY FOR A NEW ENGINE. BE ADVISED THAT EVERY TIME THIS HAPPENED THE CAR WAS GOING 55 M.P.H. OR OVER. IT IS MY BELIEF THAT WAS CAUSED BY A MANUFACTURING DEFECT AND THAT KIA SHOULD BE HELD ACCOUNTABLE. THERE HAS NEVER BEEN ANY COLLISION OR ANY OTHER EVENT THAT HAS TAKEN PLACE FOR THIS TO OCCUR. WE ARE JUST LUCKY THAT WE HAVE NEVER BEEN HURT OR KILLED IN THIS CAR!*JB
NHTSA ODI #10134824
60,043 miles · Feb 21, 2005
Engine And Engine Cooling
I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 60043 MILES. I BOUGHT THE VEHICLE BRAND NEW. THE VEHICLE STALLED AT 40 MPH, LUCKILY, IT DID NOT STALLED AT 75 MPH WHILE I WAS TAKING ONE OF MY DAILY TRIPS TO OK CITY BECAUSE IT WOULD HAVE BEEN DISASTROUS. THE CRANKSHAFT SHEARED OFF FLUSH WITH THE ENGINE HOUSING LEAVING THE MAIN AND…
Read full complaint
I AM THE OWNER OF A 99 KIA SPORTAGE WITH ONLY 60043 MILES. I BOUGHT THE VEHICLE BRAND NEW. THE VEHICLE STALLED AT 40 MPH, LUCKILY, IT DID NOT STALLED AT 75 MPH WHILE I WAS TAKING ONE OF MY DAILY TRIPS TO OK CITY BECAUSE IT WOULD HAVE BEEN DISASTROUS. THE CRANKSHAFT SHEARED OFF FLUSH WITH THE ENGINE HOUSING LEAVING THE MAIN AND TIMING BELT PULLEYS DISCONNECTED FROM THE ENGINE. AS CONSEQUENT, THE ENGINE STALLED LEAVING THE VEHICLE WITHOUT POWER IN THE MIDDLE OF TRAFFIC. NO ONE WAS HURT OR KILLED BECAUSE OF THIS. CONTACTED THE KIA DEALER AND THEY WILL NOT TAKE ANY RESPOSIBILITY FOR THIS DEFECTIVE PART. THIS IS THE KIND OF SAFE PRODUCT THAT MAKES KIA CUSTOMERS NOT TO BE REPEAT CUSTOMERS.
NHTSA ODI #10111887
Mileage unknown · Aug 9, 2004
Engine And Engine Cooling
CONSUMER HAD THE SAME PROBLEMS AS MENTIONED IN NHTSA RECALL 99V325000. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, AND LOOSENING THEM . THIS RESULTS IN A LOSS OF CIRCUIT CONTINUITY. DEALERSHIP INDICATED TO THE CONSUMER THIS VEHIC…
Read full complaint
CONSUMER HAD THE SAME PROBLEMS AS MENTIONED IN NHTSA RECALL 99V325000. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, AND LOOSENING THEM . THIS RESULTS IN A LOSS OF CIRCUIT CONTINUITY. DEALERSHIP INDICATED TO THE CONSUMER THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO VIN. *AK
NHTSA ODI #10087403
Mileage unknown · Mar 8, 2004
Electrical SystemEngine And Engine Cooling
WHILE DRIVING AT 30 MPH VEHICLE STALLED WITHOUT WARNING. VEHICLE WAS TOWED TO THE DEALERSHIP, AND TECHNICIAN DETERMINED THAT WIRING AND CONNECTORS FAILED. *AK
NHTSA ODI #10061584
NHTSA investigations
8EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06002 · Fuel Tank Leakage
Opened Jan 4, 2006 · Closed May 9, 2006
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
ON JANUARY 4, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FUEL LEAKAGE FROM THE STEEL FUEL STORAGE TANK IN CERTAIN MODEL YEAR 1999-2000 KIA SPORTAGE VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON JANUARY 25, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER KIA SPORTAGE VEHICLES.ODI IS AWARE OF 40 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE FUEL STORAGE TANK LEAKAGE IN THE SUBJECT VEHICLES.ANALYSIS OF MANUFACTURER DATA INDICATES THAT ALLEGED FUEL LEAKAGE AT OR NEAR THE STORAGE TANK MAY BE ATTRIBUTED TO SEVERAL DIFFERENT FAILURE MODES INVOLVING THE FUEL CONTAINMENT AND DISTRIBUTION SYSTEM.KIA HAS IDENTIFIED CORROSION AS A PRIMARY CAUSAL FACTOR RELATED TO FUEL STORAGE TANK COMPLAINTS AND CONTINUED FUEL SYSTEM PART SALES.ACCORDING TO KIA, FUEL TANK CORROSION CLAIMS RELATED TO LEAKAGE CAN BE DIVIDED INTO TWO CATEGORIES: LOWER TANK CLAIMS ASSOCIATED WITH EXTERIOR CORROSION DUE TO DISRUPTION OF THE POLYVINYL CHLORIDE (PVC) PROTECTIVE COATING AND UPPER TANK CLAIMS ASSOCIATED WITH CORROSION AT THE FUEL SENDING UNIT MOUNTING PLATE AREA.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FUEL TANK CORROSION RESULTING IN LEAKAGE IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-007) TO FURTHER STUDY THE FREQUENCY, SCOPE, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02002 · Windshield Wiper
Opened Jan 9, 2002 · Closed Aug 7, 2002
Status: closed (inferred from source dates) · Visibility
No summary supplied.
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.
Illustration