VEHICLE NEVER HAD 4-WHEEL DRIVE EVEN THOUGH 4- WHEEL GREEN LIGHT INDICATOR CAME ON . FAILURE WAS DUE TO FRONT SEAL THAT SHRANK. CONSUMER HAS TAKEN VEHICLE BACK TO DEALER SEVERAL TIMES TO FIX DEFECT, BUT DEFECT STILL OCCURS, PLACING CONSUMER IN DANGEROUS SITUATION. CONSUMER IS NOW ON WAITING LIST FOR A NEW PART THAT MANUFACTU…
Read full complaint
VEHICLE NEVER HAD 4-WHEEL DRIVE EVEN THOUGH 4- WHEEL GREEN LIGHT INDICATOR CAME ON . FAILURE WAS DUE TO FRONT SEAL THAT SHRANK. CONSUMER HAS TAKEN VEHICLE BACK TO DEALER SEVERAL TIMES TO FIX DEFECT, BUT DEFECT STILL OCCURS, PLACING CONSUMER IN DANGEROUS SITUATION. CONSUMER IS NOW ON WAITING LIST FOR A NEW PART THAT MANUFACTURER CLAIMS WILL FIX DEFECT. *AK
NHTSA ODI #877750
Mileage unknown · Jan 7, 2001
Power Train
4-WHEEL DRIVE NOT ENGAGING. DEALER HAS MADE THREE ATTEMPTS TO REPAIR. RECALLED SEPTEMBER 1999. REPLACED VACCUM SEAL DECEMBER 27, 2000 STILL NOT WORKING.*AK
NHTSA ODI #738941
Mileage unknown · Dec 7, 2000
Power Train
WE WERE LUCKY IN A 25 MILE SPEED ZONE-HIGHWAY SPEED WOULD HAVE KILLED US. NO SAFETY DEFECT MENTIONED IN SUMMARY
NHTSA ODI #737451
Mileage unknown · Oct 22, 2000
Air BagsElectrical SystemEngine And Engine Cooling
BRAKE FAILURE. *SLC
NHTSA ODI #556790
Mileage unknown · Sep 15, 2000
Exterior LightingPower TrainStructure
MAIN CONCERN IS 4 WHEEL DRIVE, COULD CAUSE AN ACCIDENT IF INDICATOR LAMP IS ON AND 4 WHEEL DRIVE IS NOT ENGAGING. CAUSING A FALSE SENSE OF SECURITY ON HAZARDOUS ROADWAYS, CAUSING LOSS OF VEHICLE CONTROL.*AK
NHTSA ODI #731606
Mileage unknown · Jul 11, 2000
Power Train
WHEN PUTTING VEHICLE IN ANY GEAR CAN HEAR A LOUD SQUEALING NOISE. WHEN PUSHING DOWN ON CLUTCH, IT REDUCES THE SQUEALING NOISE, CONSUMER STATED IT WAS A VERY ANNOYING SOUND. *AK
NHTSA ODI #865225
Mileage unknown · Apr 5, 2000
Electrical SystemEngine And Engine CoolingPower Train
CONNECTOR CORROSION CAUSED VEHICLE NOT TO START. ALSO, THERE WAS A CAMSHAFT OIL LEAK. WHILE DRIVING VEHICLE AT 65MPH, ENGINE STARTED TO RACE. WAS AS IF SOMEONE PUT VEHICLE IN NEUTRAL AND STEPPED ON GAS.
NHTSA ODI #721067
Mileage unknown · Apr 5, 2000
Power TrainCrash
FRONT HUBS WERE SEIZED. PURCHASED VEHICLE 1 WEEK BEFORE INCIDENT. *AK
NHTSA ODI #721064
Mileage unknown · Mar 23, 2000
Power TrainService Brakes, HydraulicTires
FRONT BEARINGS REPLACED, CAUSING EXCESSIVE TIRE WEAR, AFTER REPLACEMENT BEARINGS HAD TO BE REPLACED SHORTLY AFTER DUE TO FAULTY PARTS THAT FELL APART, HUB AND BEARING ASSEMBLY/FOUR WHEEL DRIVE DEFECTIVE AND NOT LOCKING IN PROPERLY AND CAUSING LOSS OF CONTROL ON MINIMAL SNOW COVERAGE PRIOR TO RECALL REPAIR, AFTER REPAIR VEHICLE S…
Read full complaint
FRONT BEARINGS REPLACED, CAUSING EXCESSIVE TIRE WEAR, AFTER REPLACEMENT BEARINGS HAD TO BE REPLACED SHORTLY AFTER DUE TO FAULTY PARTS THAT FELL APART, HUB AND BEARING ASSEMBLY/FOUR WHEEL DRIVE DEFECTIVE AND NOT LOCKING IN PROPERLY AND CAUSING LOSS OF CONTROL ON MINIMAL SNOW COVERAGE PRIOR TO RECALL REPAIR, AFTER REPAIR VEHICLE STILL EXPERIENCED FAILURES. *MJS
NHTSA ODI #551511
Mileage unknown · Jan 20, 2000
Power TrainVisibility
THE TRNAMISSION FAIL TWICE ONCE AFTER THE CAR WAS CHECKED BEFORE WE LEFT ON VACATION, THE DEELER WILL NOT HELP MY AND WE HAVE ENDED UP HAVING A RESTRAINING ORDER DRAW UP BECAUSE OF THE THREATS FROM HIS STAFF. KIA IT'S SELF HAS BEEN NOTIFIED AND HAV OFFERED A REDICULUS TRAID IN OF $7000. THE CAR WAS OVER $18000. THE HUBS HAVE NE…
Read full complaint
THE TRNAMISSION FAIL TWICE ONCE AFTER THE CAR WAS CHECKED BEFORE WE LEFT ON VACATION, THE DEELER WILL NOT HELP MY AND WE HAVE ENDED UP HAVING A RESTRAINING ORDER DRAW UP BECAUSE OF THE THREATS FROM HIS STAFF. KIA IT'S SELF HAS BEEN NOTIFIED AND HAV OFFERED A REDICULUS TRAID IN OF $7000. THE CAR WAS OVER $18000. THE HUBS HAVE NEARLY COST ME MY LIFE I WENT OFF THE INTERSTATE HITTING ICE I WAS NOT IN 4 WHEEL DRIVE AT THE TIME BUT I WENT IN TO A DITCH,WHEN I TRIED TO PUT IT IN TO 4 WHEEL I WOULD NOT GO I HAD TO TRAVEL IN A DITCH ON A BUSY INTERSTATE FOR 5 MILE TILL I COULD REACH THE EXIT. THE WASHER MOTOR FAILED ON THE INTERSTATE IN SMOWING CONDITIONS, I HAD TO EMPTY WATER ON THE WINDOW AS I WAS DRIVING TO SEE. THIS THE WORST CAR EVER AND THE DEALER AND KIA WILL NOT HELP WITH ANY OF THESE MATTERS. THE DATES OF THESE INCIDENTS MIGHT NOT BE THE CORRECT DATE MY ATTORNEY HAS ALL THE PAPER WORK FROM THE DEALER. *AK
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE WIRES CONNECTED TO THE C123 AND C124 CONNECTORS CAN BE PUT UNDER TENSION BY MOVEMENT OF THE ENGINE, THUS PULLING THE WIRES AND CONNECTORS, LOOSENING THEM AND RESULTING IN A LOSS OF CIRCUIT CONTINUITY.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE ENGINE STALLING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SPRING CLIPS TO LOCK THE CONNECTORS TOGETHER. IN ADDITION, THE DEALERS WILL BE INSTRUCTED TO SOLDER A SPLICE IN THE WIRE HARNESS.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES WITHOUT AN ANTI-LOCK BRAKING SYSTEM (ABS). THE STEERING INTERMEDIATE SHAFT COUPLING CAN CONTACT A HYDRAULIC BRAKE PIPE CAUSING FLUID LEAKAGE.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF REAR BRAKE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, INCREASE THE CLEARANCE BETWEEN THE BRAKE PIPE AND STEERING INTERMEDIATE SHAFT COUPLING.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ02013 · Engine Stalling POST-RECALL
Opened Oct 18, 2002 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Electrical System:wiring
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Engine And Engine Cooling
RQ02-013 WAS OPENED TO ASSESS THE SCOPE AND ADEQUACY OF RECALL 99V-325, WHICH INVOLVED MODIFICATIONS TO THE ENGINE FUEL INJECTION WIRE HARNESS (HARNESS).VEHICLES PRODUCED AFTER THE RECALL POPULATION HAVE SHOWN NO SIGNS OF A DEFECT TREND.THE MAJORITY OF RECALL REMEDY FAILURES IDENTIFIED WERE REPAIRED WITHIN ONE DAY OF THE INITIAL WORK.SUBSEQUENT FAILURE EXPERIENCE IS MINIMAL (249/55,548 VEHICLES REMEDIED).FIELD DATA SHOW NO INDICATION OF AN ONGOING CONCERN: OF 627 POST-RECALL STALLING-RELATED WIRE HARNESS WARRANTY REPAIRS, ONLY SEVEN OCCURRED IN 2003.CONSUMER COMPLAINTS AND FUEL INJECTION WIRE HARNESS SALESHAVE DECLINED SINCE 2001.ODI HAS RECEIVED A TOTAL OF TWELVE POTENTIALLY RELEVANT CONSUMER COMPLAINTS SINCE 2001.UNDER THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED.THE RECALL QUERY IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.
PE99033 · Windshield Wiper
Opened May 6, 1999 · Closed Oct 21, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED WINDSHIELD WIPER BECOMES INOPERATIVE WHEN THE WIPER ARM AND PIVOT SEPARATE
Illustration