Engine. Review the 551 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports69 fire reports24 injury reports

What owners actually said

897 reports

93,000 miles · Jun 16, 2021

Engine

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated that the vehicle was serviced for NHTSA Campaign Number: 20V750000 (Engine) and a manufacturer's product improvement campaign software update however, the failure occurred. The contact stated that on three separate occasions while driving at 60 mph, there was a rattling sound heard then the vehicle loss motive power without warning. The instrument panel light and front driver’s and passenger’s side headlights flickered on and off. The vehicle was taken to the dealer and diagnosed that there was a rod bearing knocking code that appeared on the code reader however, there were no oil leaks found. An oil consumption test was performed which found that the vehicle consumed a quart of oil for every thousand miles. An engine test was also performed, which the vehicle passed. The vehicle was not repaired. The manufacturer was made aware of the failure but informed the contact that there was no warranty coverage and advised the contact to drive the vehicle until the engine seized. The failure mileage was 93,000.

NHTSA ODI #11421165

Mileage unknown · Jun 15, 2021

Engine

Read full complaint

I was traveling back home from Dandridge, TN in July 2019. As I was going down the interstate at 70MPH, the engine made a very loud noise and the vehicle began to shake. I promptly pulled over to the shoulder and shut off the vehicle. The vehicle was then towed to Rusty Wallace Kia of Knoxville. They had the car for three months before I received a phone call in September 2019. I was on my way to Florida with a friend, and Rusty Wallace Kia informed me that the engine had “threw a rod” and cut the oil lines. The recall is related to this exact issue. Rusty Wallace Kia then replaced the engine without my written permission. They called to inform me of this about a month later. I did receive mail from Kia Consumer Affairs alerting me of the recall a few months later. I have since contacted Consumer Affairs and they let me know they would be contacting Rusty Wallace Kia of Knoxville to discuss getting the repair payed for so I can get my car back. I received an email just today (several months later) from the service manager, Allison Richard’s, saying that I am responsible for the cost of the repairs. The recall paperwork in the mail states the engine will be replaced and the KDS software updated. As of today, Rusty Wallace Kia of Knoxville is refusing to release my car back to me (which is paid in full and I have the title in hand), and Allison also stated that consumer affairs said they wouldn’t help. I am needing my car back as soon as possible, and any help is appreciated. Thank you.

NHTSA ODI #11421069

Mileage unknown · Jun 15, 2021

Exterior Lighting

IN THE PAST YEAR FROM FEB LAST YEAR TILL TODAY I HAVE BOUGHT 2 SET OF LIGHTBULBS. THE 1ST SET LASTED A YEAR THE 2ND SET I BOUGHT 2/1/21 AND IT JUST BURNT OUT AGAIN. I AM NOT BUYING CHEAP BULBS EITHER.

NHTSA ODI #11420997

Mileage unknown · Jun 14, 2021

EngineFire

Read full complaint

My car caught fire upon a drive home. Had to call fire department and extinguished it myself before fire department arrival. Took vehicle to local Kia dealership to have them check car. Documentation of charting from fire. They told me it’s because I needed new snow tires. I purchased new tires. Months later my engine started knocking and vehicle is not drivable. I have filed a national claim with Kia due to safety recall on 4/21/21. I have sent pictures and report. I leave multiple voicemails. No one is calling me back. Case number 14128806. Case manager is Jesse. Twice I’ve been told his supervisor will call me back and no one has. Fire occurred in 2018- engine blew in 2021

NHTSA ODI #11420851

Mileage unknown · Jun 13, 2021

Engine

Read full complaint

We have concerns how Gerald KIA of Naperville handled the recall: NHTSA Recall Number: 20V750 (1/25/21)/Product Improvement Campaign (10/20/20) and at this point are very concerned about the safety of driving our car at all. We brought our car in on 2/24/21 for this important safety recall/product improvement campaign. They performed the PI2002B ECU Update (sc200b logic update), inspected the engine for sc200ps bct and fuel line and oil pan inspection which all passed. We expressed the check engine light was coming on when on the highway, the proposed fix was replacing Purge valve, spark plugs and air filter. I replaced the air filter and purge valve myself and had my local mechanic replaced the spark plugs and one coil on 4/10/21. Also note that the car has been consuming too much oil for the past year and started to get worse during this time - sometimes losing more than a quart a week and we just monitor the oil level and add when it is getting low and were hopeful that these repairs would help the oil consumption problem as well as the check engine light coming on. After these fixes the car started having severe acceleration/loss of power issues while driving on the highway when reaching 65 mph and the check engine light would flash. And then one time the check engine light started flashing and stayed on and I brought it to my local mechanic to diagnose. He cleaned our fuel system to see if it improves our performance and while doing so confirmed that our car has a clogged catalytic converter and recommended that we bring the car back to the dealership for an oil consumption test to inquire further into our car issues and that the high oil consumption may have led to the clogged cat. Before I brought the car back to the dealership I re-read the recall/safety campaign letters and realized that it appears what was happening was after the software update which updated the knock sensor detection system - the blinking check engine light was blinking and the

NHTSA ODI #11420761

130,000 miles · Jun 11, 2021

Engine

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated while driving at various speeds, the vehicle failed to accelerate as needed. The contact stated that there was an abnormal knocking coming from the engine. There was no warning light illuminated. The vehicle was taken to the local dealer where the vehicle had been repaired under NHTSA campaign number: 20V750000 (Engine) however, the failure recurred. The manufacturer was notified of the failure. The approximate failure mileage was 130,000.

NHTSA ODI #11420542

107,269 miles · Jun 9, 2021

Engine And Engine Cooling

Read full complaint

The contact owns a 2014 Kia SOUL. The contact received notification of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speeds, the vehicle failed to accelerate and loss motive power. The vehicle was towed to an Independent mechanic to be diagnosed. The contact was informed that the engine was ½ quart low on oil, with no leaks present. The catalytic converter was inspected and flushed however, and additional diagnostic test was needed. The vehicle was then towed to the dealer where it was diagnosed that the catalytic converter fractured and the engine needed to be replaced. The vehicle was not repaired. The contact felt unsafe driving at low speeds due to the vehicle not accelerating above 15 mph. The manufacturer was not contacted. The failure mileage was approximately 107,269.

NHTSA ODI #11420306

Mileage unknown · Jun 9, 2021

Engine And Engine Cooling

Read full complaint

My issue has to deal with the catalytic converter. I received a safety recall letter dated 4/12/2019 which stated I had a defect related directly to the converter. I brought the car in within days of this letter to get the upgrade to the Catalytic overheating protection unit. starting in Feb of 2021 my engine light goes on, and stays on for a few days, then goes off again for a week . this has repeated itself since then. Ive since brought the car in twice explaining this issue, only to be told on my 2nd trip that my catalytic converter is clogged. I explained I have the safety recall later which states "Kia will upgrade the catalytic overheating protection logic in the engine control unit (ECU), and if necessary replace the catalytic converter and/or engine at no cost to you". The response from both the dealer and KIA has been, "that campaign has ended, and the repairs are your responsibility". My argument is, how can a safety recall that is directly related to my defect ever be expired?. The car has been diagnosed as having a clogged converter. I've been advised by a lawyer to reach out here to see if i can get any answers regarding the recall letter and if its valid for the life of the vehicle.

NHTSA ODI #11420292

125,000 miles · Jun 9, 2021

Engine And Engine Cooling

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated while driving an abnormal sound was heard as the vehicle loss power with several unknown warning lights illuminated. The contact opened the hood and checked the oil dipstick and discovered there was no oil in the engine. The contact stated that the oil was change three weeks prior to the failure. The vehicle was towed to her residence and then towed to the NTB in Belair, MD to be diagnosed. The contact was informed that the rod had punctured the oil tank. The manufacturer was notified of the failure and the contact was notified of NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The Vin was included in the recall. The vehicle was taken to the dealer however, the mechanic was unable to retrieve a diagnostic trouble code. The contact was informed that the engine needed to be replaced. The failure mileage was approximately 125,000.

NHTSA ODI #11420253

Mileage unknown · Jun 4, 2021

Engine

Read full complaint

Engine has a severe knock and is consuming large quantities of oil, oil light would flash even with oil at the max mark. It is available for inspection. When dealer looked at the car they flashed the knock sensor, and returned vehicle, drove 2 miles went into limp mode in traffic, would not go above 5mph. Engine light flashed. Dealer replaced knock sensor and returned vehicle. Again, approximately 2 miles the vehicle went into limp mode again in traffic. Upon 3rd time going to the dealer they determined Engine needed replaced and refused to warrentie under recall. Vehicle has 156k miles recall expires at 150k.

NHTSA ODI #11419722

Official recalls

22V096000 · Air Bags: Air Bag/restraint Control Module:software; Air Bags:frontal

Feb 18, 2022

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence & remedy

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

Remedy: Dealers will update the ACU software, free of charge. Owner notification letters were mailed April 4, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC229.

Additional source detail variants (2)

Air Bags: Air Bag/restraint Control Module:software

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

Remedy: Dealers will update the ACU software, free of charge. Owner notification letters were mailed April 4, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC229.

Air Bags:frontal

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

20V750000 · Engine

Dec 2, 2020

Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

Consequence & remedy

Consequence: An engine compartment fire increases the risk of injury.

Remedy: Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC200.

19V120000 · Engine; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Feb 22, 2019

Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.

Consequence & remedy

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Additional source detail variants (2)

Engine

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

17V608000 · Steering

Sep 29, 2017

Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.

Consequence & remedy

Consequence: If the pinion gear separates, steering will be lost, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.

15V123000 · Vehicle Speed Control:accelerator Pedal

Mar 2, 2015

Kia Motors America (Kia) is recalling certain model year 2014-2015 Soul and Soul electric vehicles manufactured July 21, 2013, to January 8, 2015. A section of the accelerator pedal may bend and fracture.

Consequence & remedy

Consequence: If the vehicle has a bent or broken accelerator pedal, the driver may have difficulty accelerating the vehicle, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will add a supporting rubber underneath the pedal stopper, free of charge. The recall began on March 24, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC116.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE19004 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines (approximately 1.7 million vehicles). ODI also reviewed field and other data on other Kia vehicles (approximately 3.6 million additional vehicles) equipped with the same engines used in the above-mentioned vehicles.As a result of this PE, Kia has issued NHTSA Recalls 20V-750 and 21V-844 to address potential engine failures and fires in certain Kia vehicles equipped with various engine types.Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov.In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure-related recalls mentioned above and conducted previously.See the EA21-003 Opening Resume available at NHTSA.gov for more information.Also available in the downloadable version of this resume is a list of the reference numbers for the 444 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021.Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (392)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal:switch

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other