Engine. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 151 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

22 crash reports45 fire reports18 injury reports

What owners actually said

662 reports

78,000 miles · Feb 15, 2022

EngineFire

Read full complaint

The contact owns a 2013 Kia Soul. The contact stated while driving approximately 60mph when the engine light illuminated and the vehicle lost power. The contact merged to the shoulder of the road. The contact was informed by a passerby that the engine was on fire. The contact then called the fire marshals and the fire was extinguished. A fire report was taken and no injuries were sustained. A police report was not filed. The vehicle was towed to a local dealer and was awaiting a response. Upon investigation, the contact associated the failure with, NHTSA Campaign Number: 19V120000 (ENGINE, ENGINE AND ENGINE COOLING) however the VIN was not included. The manufacturer was informed of failure and told the contact that they were unable to assist. The failure mileage was approximate. 78,000.

NHTSA ODI #11452135

120,000 miles · Feb 14, 2022

Steering

The contact owns a 2013 Kia Soul. The contact stated while driving at various speeds, the steering column would make a popping sound. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer to be diagnosed. The manufacturer was informed of the failure and informed the contact that t…

Read full complaint

NHTSA ODI #11451883

Mileage unknown · Feb 7, 2022

Electrical SystemEngine

While driving down the highway, or turning around a curve the engine stops. The car can be restarted after it is put un park. Not always possible on a busy road.

NHTSA ODI #11450798

Mileage unknown · Feb 2, 2022

Electrical SystemSeatsStructure

Read full complaint

I purchased the 2013 Kia Soul used on 5/22/2021 and shortly afterward discovered water leaking into the front passenger side compartment and evidence that the leak was old. I brought the car to Fred Anderson Kia of Raleigh (kiaofraleigh.com) on 6/7/21, 6/25/21, and 7/20/21, and they incorrectly diagnosed the leak as an air conditioner hose. And then, after they replaced the hose, they thought it might be a windshield leak. After the unneeded air conditioner repair, they referred me out for windshield/water leak testing. McConnell Auto Glass (mcconnellautoglass.com) determined that the windshield was not leaking. The leak was coming in from substandard factory welding in the car frame. The car has never had frame repair on that side. My attempts to patch the bad weld joints with JD Weld caused the leak to continue to move across multiple failing car frame welds. The leak has damaged the interior of the car, grown mold, and exposed the electrical components to failure, rust, and fire. I contacted Kia Corporation (800 333 4542) on 1/12/22, 1/20/22, and 1/21/22. They have told me that Fred Anderson Kia will not return their outreach calls, and they would refer my case # 14586235 to the district manager for a callback -- which has not happened. They tell me the DM’s name and contact information are secret, so I can not call them. Q1: The frame welds. I have covered some of the leaking areas with JD Weld, but the welds are unaltered and could be inspected by removing the JD Weld. I also took several pictures. The leak is still present. Q2: The leak caused interior damage, including mold, and could damage electrical components due to moisture, rust, or fire. Q3: Fred Anderson Kia of Raleigh verified the leak but could not correctly diagnose it. McConnell Auto Glass verified the leak. Q4: Yes, Fred Anderson Kia of Raleigh on 6/7/21, 6/25/21, and 7/20/21 Q5: I noticed the wet carpet shortly after I purchased the car, but there is evidence of long-term damage.

NHTSA ODI #11450006

Mileage unknown · Jan 31, 2022

Engine

Read full complaint

Received Engine Code P0420 - Catalyst System Efficiency Below Threshold - Bank 1. There is an existing recall NHTSA # 19V120000 ( Kia Recall SC176), with similar issues and I received a letter from Kia to get the recall repaired, but when entering my VIN, my vehicle is not on the recall list, and now I believe I am experiencing this recall on my vehicle. If the cat. the converter is clogged it can cause engine failure and possibly a fire in the near future. Unfortunately, Kia will not repair my vehicle as the VIN is not listed. The possible repairs are in the thousands for a new catalytic converter, which I have seen may other customers not get reimbursed if they fix it on their own. I am hoping this can get on their radar to add my car to the recall. My vehicle is a 2013 Kia Soul (Base Model 1.6 liter). Thank you.

NHTSA ODI #11449624

Mileage unknown · Jan 28, 2022

Electrical SystemSeatsStructure

Read full complaint

I purchased the 2013 Kia Soul used on 5/22/2021 and shortly afterward discovered water leaking into the front passenger side compartment and evidence that the leak was old. I brought the car to Fred Anderson Kia of Raleigh (kiaofraleigh.com) on 6/7/21, 6/25/21, and 7/20/21, and they incorrectly diagnosed the leak as an air conditioner hose. And then, after they replaced the hose, they thought it might be a windshield leak. After the unneeded air conditioner repair, they referred me out for windshield/water leak testing. McConnell Auto Glass (mcconnellautoglass.com) determined that the windshield was not leaking. The leak was coming in from substandard factory welding in the car frame. The car has never had frame repair on that side. My attempts to patch the bad weld joints with JD Weld caused the leak to continue to move across multiple failing car frame welds. The leak has damaged the interior of the car, grown mold, and exposed the electrical components to failure, rust, and fire. I contacted Kia Corporation (800 333 4542) on 1/12/22, 1/20/22, and 1/21/22. They have told me that Fred Anderson Kia will not return their outreach calls, and they would refer my case # 14586235 to the district manager for a callback -- which has not happened. They tell me the DM’s name and contact information are secret, so I can not call them. Q1: The frame welds. I have covered some of the leaking areas with JD Weld, but the welds are unaltered and could be inspected by removing the JD Weld. I also took several pictures. The leak is still present. Q2: The leak caused interior damage, including mold, and could damage electrical components due to moisture, rust, or fire. Q3: Fred Anderson Kia of Raleigh verified the leak but could not correctly diagnose it. McConnell Auto Glass verified the leak. Q4: Yes, Fred Anderson Kia of Raleigh on 6/7/21, 6/25/21 and 7/20/21 Q5: I noticed the wet carpet shortly after I purchased the car, but there is evidence of long-term damage.

NHTSA ODI #11449319

170,000 miles · Jan 26, 2022

EngineEngine And Engine Cooling

Read full complaint

The contact owns a 2013 Kia Soul. The contact stated the engine was making an abnormal knocking sound. The check engine warning light was illuminated. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic who informed the contact that the failure might be due to a piston slap. The manufacturer was notified of the failure and a case was filed. The contact was informed that the vehicle was not covered under NHTSA Campaign Number: 19V120000 (Engine and Engine Cooling). The failure mileage was approximately 170,000.

NHTSA ODI #11449024

Mileage unknown · Jan 10, 2022

Engine

Read full complaint

May, 2021 the check engine light came on. The engine appeared to be sluggish upon acceleration. Took vehicle to be serviced at Meineke in Berlin. NJ. They suggested filling tank with high octane gas. They also changed all fluids and filters as well as installed all new spark plugs. Engine continued to be sluggish and once again check engine light came on. On 8/24/21 an email was sent by the Federal Court attaching an information pamphlet regarding a recall in response to a "knock sensor detection system". I immediately attempted to make an appointment with the Turnersville, NJ Kia Dealer. I was told they were booked up for 6 to 8 weeks. I made an appointment, but subsequently cancelled when I was able to be seen by Keller Auto repair on 8/26/21. They diagnosed a "bad ground circuit ". They advised we should take the vehicle to a Kia dealer. I was able to get an appointment with Cherry Hill, NJ Kia dealer for 8/26/21. I was given a $426.45 invoice to perform recall along with a transmission service purge & fill and drive belt replacement. Unfortunately, engine problems were worsening. The vehicle was stalling at every stop sign, traffic light and acceleration. I inquired about the "knock sensor" recall and was told they would submit a claim to Kia for engine replacement. Claim was denied! Vehicle has been rendered as inoperable and unsafe. The vehicle is available for inspection upon request.

NHTSA ODI #11446921

Mileage unknown · Jan 3, 2022

Electrical SystemEngineFuel/propulsion System

Read full complaint

It all started when I thought I received bad gas a couple of months ago after filling my tank up with regular gas from a Speedway , It didn't start right away, and that never happened and then it continued to Be hard to accelerate, as I drove it. That has happened on 2 other occasions since that incident a couple of months ago I would push the pedal to the floor and the RPM would not move it stayed on zero. The accelerator was resistant to move, but I made it home. Spoke a mechanic friend, who's done body work on my car, and thought, as I did, I had bad gas.. suggested, I get the fuel tank flushed and filled, which I did at Jiffy Lube. I've since put HEET in on every fill up, and used premium gas. Happened again yesterday am on my way home from work about about 830am. I was stopped at a light, it cut off, I put it in park, and cut it back on, but it was hard to accelerate. I made it home, but now extremely worried, given all the spontaneous fires, and engine problems. It's my only source of transportation, so I'm in desperate need of help.

NHTSA ODI #11446016

Mileage unknown · Dec 28, 2021

Steering

Has a thud while turning the steering wheel left and right at a stop. Steering wheel shakes and vibrates when droving over bumpy road or train tracks. Steering for now unaffected.

NHTSA ODI #11445194

Official recalls

23V652000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 25, 2023

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

19V120000 · Engine; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Feb 22, 2019

Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.

Consequence & remedy

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Additional source detail variants (2)

Engine

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

14V822000 · Structure:body:roof And Pillars

Dec 29, 2014

Kia Motors America (Kia) is recalling certain model year 2010-2013 Kia Soul vehicles manufactured January 8, 2009, to October 2, 2013, equipped with a sun roof. A headliner plate may detach during deployment of the curtain air bag.

Consequence & remedy

Consequence: A detached headliner plate may increase the risk of injury to the occupant during a vehicle crash.

Remedy: Kia will notify owners, and dealers will install industrial adhesive strips to secure the headliner plates, free of charge. The recall is expected to begin February 2, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC112.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE19004 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines (approximately 1.7 million vehicles). ODI also reviewed field and other data on other Kia vehicles (approximately 3.6 million additional vehicles) equipped with the same engines used in the above-mentioned vehicles.As a result of this PE, Kia has issued NHTSA Recalls 20V-750 and 21V-844 to address potential engine failures and fires in certain Kia vehicles equipped with various engine types.Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov.In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure-related recalls mentioned above and conducted previously.See the EA21-003 Opening Resume available at NHTSA.gov for more information.Also available in the downloadable version of this resume is a list of the reference numbers for the 444 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021.Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (392)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal:switch

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other