NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
15 reportsClear category filterMileage unknown · Jul 12, 2016
Electrical SystemVisibility
HAVING TROUBLE WITH DRIVERS SIDE WINDOW. IT WILL WORK THEN THE MOTOR/REGULATOR GETS STUCK AND WON'T FUNCTION. THEN ALL OF A SUDDEN IT WILL WORK THEN NOT WORK. I JUST WANT TO FIND OUT WHAT'S CAUSING PROBLEM. ALL WIRES TO SWITCH TESTED POSITIVE POWER IS GOING TO AND FROM MOTOR/REGULATOR TO ALL SWITCHES. MY CELL IS [XXX] I JUST WAN…
Read full complaint
HAVING TROUBLE WITH DRIVERS SIDE WINDOW. IT WILL WORK THEN THE MOTOR/REGULATOR GETS STUCK AND WON'T FUNCTION. THEN ALL OF A SUDDEN IT WILL WORK THEN NOT WORK. I JUST WANT TO FIND OUT WHAT'S CAUSING PROBLEM. ALL WIRES TO SWITCH TESTED POSITIVE POWER IS GOING TO AND FROM MOTOR/REGULATOR TO ALL SWITCHES. MY CELL IS [XXX] I JUST WANT A NAME AND PHONE NUMBER OF SOMEONE WHO CAN FIX THIS IN 07646 AREA CODE. I,E AN EXPERT ON POWER WINDOW PROBLEMS THANK YOU. MY NAME IS [XXX] THIS IS SORT OF A COMPLAINT BECAUSE IT'S BECOME A DIFFICULT DIAGNOSIS I NEED A KIA SPECIALISTS HELP. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10884375
52,984 miles · Dec 8, 2008
Electrical System
TL*THE CONTACT OWNS A 2001 KIA SEPHIA. THE VEHICLE FAILED TO START AFTER SEVERAL ATTEMPTS. THE STARTER AND TWO RELAYS WERE REPLACED; HOWEVER, THE FAILURE IMMEDIATELY RECURRED. THE CONTACT HAS NOT HAD THE VEHICLE DIAGNOSED BY AN AUTHORIZED DEALER TO DETERMINE THE CAUSE OF THE FAILURE. SHE IS IN THE PROCESS OF NOTIFYING THE MA…
Read full complaint
TL*THE CONTACT OWNS A 2001 KIA SEPHIA. THE VEHICLE FAILED TO START AFTER SEVERAL ATTEMPTS. THE STARTER AND TWO RELAYS WERE REPLACED; HOWEVER, THE FAILURE IMMEDIATELY RECURRED. THE CONTACT HAS NOT HAD THE VEHICLE DIAGNOSED BY AN AUTHORIZED DEALER TO DETERMINE THE CAUSE OF THE FAILURE. SHE IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 52,984. UPDATED 01/07/09. *LJ UPDATED 01/08/09. *JB
NHTSA ODI #10251098
Mileage unknown · Nov 7, 2005
Electrical SystemEngine And Engine Cooling
MY CAR IS IN THE SHOP FOR THE THIRD MAJOR REPAIR IN LESS THAN 2 YEARS. FIRST, IN JAN. OF '04 THERE WAS A LEAK IN THE BLOCK. THAT REQUIRED THE ENTIRE ENGINE TO BE REPLACED ($3,800). THEN, 2 MONTHS AGO, THE ENTIRE ELECTRICAL SYSTEM HAD TO BE REPLACED ($1,567) AND NOW IT IS IN THE SHOP TO HAVE THE COMPRESSOR AND BELTS REPLACED($975…
Read full complaint
MY CAR IS IN THE SHOP FOR THE THIRD MAJOR REPAIR IN LESS THAN 2 YEARS. FIRST, IN JAN. OF '04 THERE WAS A LEAK IN THE BLOCK. THAT REQUIRED THE ENTIRE ENGINE TO BE REPLACED ($3,800). THEN, 2 MONTHS AGO, THE ENTIRE ELECTRICAL SYSTEM HAD TO BE REPLACED ($1,567) AND NOW IT IS IN THE SHOP TO HAVE THE COMPRESSOR AND BELTS REPLACED($975). THE DEALERSHIP ALSO DOES NOT OFFER A LOANER CAR AND I CANNOT AFFORD TO RENT. *NM
NHTSA ODI #10142014
3,000 miles · Aug 17, 2004
Electrical SystemPower TrainStructure
BEFORE 40,000 MILES, HAD FUEL PUMP CHANGED 2 TIMES, STARTER CHANGED 2 TIMES, NEW TRANSMISSION, IGNITION CONTROL MODULE ONCE, DOORS REPLACED DUE TO DEFECT, NEW PAINT JOB DUE TO TRASH UNDER ORIGINAL PAINT JOB, ALL HUB CAPS AND TRIM WERE REPLACED DUE TO FADING AT 10,000 MILES (WHICH FADED AGAIN A FEW THOUSAND MILES LATER), AC BLOWE…
Read full complaint
BEFORE 40,000 MILES, HAD FUEL PUMP CHANGED 2 TIMES, STARTER CHANGED 2 TIMES, NEW TRANSMISSION, IGNITION CONTROL MODULE ONCE, DOORS REPLACED DUE TO DEFECT, NEW PAINT JOB DUE TO TRASH UNDER ORIGINAL PAINT JOB, ALL HUB CAPS AND TRIM WERE REPLACED DUE TO FADING AT 10,000 MILES (WHICH FADED AGAIN A FEW THOUSAND MILES LATER), AC BLOWER RESISTOR MOTOR REPLACED, ALL MIRRORS WERE REPLACED, ELECTRICAL SHORT IN DOME LIGHT, & IGNITION SWITCH REPLACED. I BOUGHT MY CAR IN OCT 2001, AND WAS PUT IN SHOP FOR THE FIRST TIME IN JAN. 2002 AND HAS BEEN THERE 55 DAYS SINCE. I HAVE KEPT UP WITH ALL REQUIRED MAINTENANCE. SORRY, BUT THIS CAR IS JUNK. AND I HATE TO HAVE HAD A BAD EXPERIENCE BUYING MY FIRST NEW VEHICLE. *JB
NHTSA ODI #10088107
Mileage unknown · Jan 13, 2004
Electrical SystemExterior Lighting
CONSUMER STATED THAT HEADLIGHTS CHANGED FROM BRIGHT TO DIM CONSTANTLY. FIRST THEY WERE BRIGHT, THEN THEY GRADUALLY BECAME DIM. THE CONSUMER TOOK THE VEHICLE TO SEVERAL MECHANICS AND WAS TOLD BY THAT THERE WAS NOTHING THEY COULD DO BECAUSE THIS WAS A MANUFACTURER'S DEFECT. THE HEADLIGHTS NEVER STOPPED WORKING, THEY JUST DIMME…
Read full complaint
CONSUMER STATED THAT HEADLIGHTS CHANGED FROM BRIGHT TO DIM CONSTANTLY. FIRST THEY WERE BRIGHT, THEN THEY GRADUALLY BECAME DIM. THE CONSUMER TOOK THE VEHICLE TO SEVERAL MECHANICS AND WAS TOLD BY THAT THERE WAS NOTHING THEY COULD DO BECAUSE THIS WAS A MANUFACTURER'S DEFECT. THE HEADLIGHTS NEVER STOPPED WORKING, THEY JUST DIMMED ENOUGH THAT IT WAS HARD TO VIEW IN FRONT WHILE DRIVING. *AK THERE WAS TROUBLE WITH THE KEYLESS ENTRY. THE VEHICLE LOCKED UP WOULD NOT UNLOCK. WHILE DRIVING, THE PROBLEM SEEMED WORSE AT A MODERATE STEADY SPEED. *SC *JB
NHTSA ODI #10050495
Mileage unknown · Dec 29, 2003
Air BagsElectrical SystemCrashFireInjury
THE SEPHIA WAS HIT AT AN ANGLE ON THE RIGHT FRONT CORNER AT ABOUT 30 MILES PER HOUR. THE AIRBAGS DELOYED AND THE PASSENGER SIDE AIRBAG AND WIRING IMMEDEATLY CAUGHT ON FIRE. THE CABIN FILLED WITH DUST FROM THE BAGS AND SMOKE. THE POWER WINDOWS DID NOT WORK AT THAT POINT. THE DRIVER COULD NOT SEE THE DOOR HANDLE. SOMEONE OPENED…
Read full complaint
THE SEPHIA WAS HIT AT AN ANGLE ON THE RIGHT FRONT CORNER AT ABOUT 30 MILES PER HOUR. THE AIRBAGS DELOYED AND THE PASSENGER SIDE AIRBAG AND WIRING IMMEDEATLY CAUGHT ON FIRE. THE CABIN FILLED WITH DUST FROM THE BAGS AND SMOKE. THE POWER WINDOWS DID NOT WORK AT THAT POINT. THE DRIVER COULD NOT SEE THE DOOR HANDLE. SOMEONE OPENED THE DOOR TO LET HER OUT. A PASSENGER HAD RECENTLY EXITED THE CAR OR THE ACCIDENT COULD HAVE BEEN MUCH WORSE. THE DRIVER SIDE AIRBAG DELPOYED AND WENT DOWN SO FAST THAT THE DRIVERS HEAD WAS JERKED BACK AND LET DROP SO THAT IT DID NOT REDUCE THE WHIPLASH SIGNIFACANTLY.*AK
NHTSA ODI #10051259
Mileage unknown · Oct 6, 2003
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
DEALER REPLACED IN THE LAST PAST THREE MONTHS THE FOLLOWING ITEMS: IGNITION COIL/FUEL INJECTION SYSTEM TWICE/WIRING HARNESS, AND CATALYTIC CONVERTER. HOWEVER, PROBLEMS STILL RECURRED. *AK
NHTSA ODI #10042366
Mileage unknown · Jul 15, 2002
Electrical SystemPower Train
VEHICLE DOES NOT HAVE ANY POWER. VEHICLE HAS BEEN CHECKED BY DEALER, WHO HAS REPLACED WIRE HARNESS/ 2 COMPUTER CHIPS, AND TRANSMISSION TWICE. VEHICLE WAS PICKED UP 7/3/02, AND BROKE DOWN AGAIN. CONSUMER HAS TO HAVE PEDAL FLOORED FOR VEHICLE TO MOVE.*AK
NHTSA ODI #8013960
Mileage unknown · Jul 13, 2002
Electrical SystemEquipmentPower Train
BOUGHT NEW CAR. SEVERAL ELECTRICAL MALFUNCTIONS. INSIDE DOOR LOCKS (REPAIRED 2 TIMES). HORN MALFUNCTION (REPAIRED 2 TIMES). SPARK PLUGS, WIRES, AND COIL (REPLACED 1 TIME). REAR DEFROST MALFUNCTION (REPAIRED 1 TIME.) AIR FILTER COVER SCREWS AND HOLES STRIPPED OUT (REPLACED 1 TIME). AIR CONDITIONER FAN-SCRAPING NOISE (NEVER …
Read full complaint
BOUGHT NEW CAR. SEVERAL ELECTRICAL MALFUNCTIONS. INSIDE DOOR LOCKS (REPAIRED 2 TIMES). HORN MALFUNCTION (REPAIRED 2 TIMES). SPARK PLUGS, WIRES, AND COIL (REPLACED 1 TIME). REAR DEFROST MALFUNCTION (REPAIRED 1 TIME.) AIR FILTER COVER SCREWS AND HOLES STRIPPED OUT (REPLACED 1 TIME). AIR CONDITIONER FAN-SCRAPING NOISE (NEVER REPAIRED). OUTSIDE DOOR LOCKS MALFUNCTION (CURRENTLY BEING LOOKED AT). STICK SHIFT WAS "JUMPING AROUND"-REAR MOTOR MOUNT WAS BAD (REPLACED 1 TIME). KNOCK SENSOR MALFUNCTION (REPLACED 1 TIME). DASH DIALS NOT WORKING (REPLACED FUSE 1 TIME). PROBLEMS STARTED DAY AFTER I PURCHASED CAR-SHOULD HAVE HEEDED THE OBVIOUS WARNING! DO NOT BUY KIA!
NHTSA ODI #764172
Mileage unknown · Jun 10, 2002
Electrical System
VEHICLE HAS A PROBLEM WITH STARTING, HAS TO CRANK IT FOUR OR MORE TIMES BEFORE VEHICLE WOULD START. VEHICLE BEEN TO DEALER ON TWO OCCASIONS, AND HE WAS UNABLE TO CORRECT THE PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER INFROMATION.*AK
NHTSA ODI #8011410
NHTSA investigations
3EA04004 · Refueling Spit Back
Opened Feb 3, 2004 · Closed Jul 29, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (7)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ03006 · Refueling Spit Back
Opened Aug 15, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (6)
Fuel System, Gasoline
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration