NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
266 reports50,000 miles · May 17, 2007
Latches/locks/linkages
I OWN KIA-SEPHIA-2000. WHEN THE TEMPERATURE IS UNDER 0 DEGREES THE DOORS FREEZE SO BADLY THAT I CANNOT SHUT THE DRIVER'S SIDE DOOR OR ANY OTHER DOOR THAT I MIGHT OPEN AND THEN TRY TO CLOSE. MOST OFTEN,. AFTER I STARTED AND RAN THE HEAT AT THAT TIME THE DOOR MIGHT CLOSE SHUT. ONE EVENING IN JANUARY, I HAD TO DRIVE THE ENTIR…
Read full complaint
I OWN KIA-SEPHIA-2000. WHEN THE TEMPERATURE IS UNDER 0 DEGREES THE DOORS FREEZE SO BADLY THAT I CANNOT SHUT THE DRIVER'S SIDE DOOR OR ANY OTHER DOOR THAT I MIGHT OPEN AND THEN TRY TO CLOSE. MOST OFTEN,. AFTER I STARTED AND RAN THE HEAT AT THAT TIME THE DOOR MIGHT CLOSE SHUT. ONE EVENING IN JANUARY, I HAD TO DRIVE THE ENTIRE TIME , 27 MILES OR 45 MINUTES WITH THE DRIVER'S SIDE DOOR UNABLE TO CLOSE. I WAS HOLDING IT CLOSED AS TIGHTLY AS I COULD. NO AMOUNT OF WD40 WOULD HELP THIS SITUATION. I LIVE IN AN AREA THAT GOES DOWN TO 40 BELOW, AND THAT IS NOT THE WIND CHILL FACTOR. WHEN I PURCHASED THIS VEHICLE A BLOCK HEATER WAS IMMEDIATELY ADDED TO IT FOR ANTICIPATION OF THE COLD WEATHER.*AK
NHTSA ODI #10191005
Mileage unknown · Jan 31, 2007
Structure
TL*- THE CONTACT CALLED REGARDING A 2000 KIA SPECTRUM. THE CONTACT OWNED THE VEHICLE SINCE 2002 AND ALL FOUR DOORS WILL NOT SHUT WHEN IT WAS COLD OUTSIDE. THE CONTACT DID NOT KNOW IF THIS FAILURE OCCURRED DURING A SPECIFIC TEMPERATURE. THE CONTACTDID NOT REMEMBER WHAT THE DEALER SAID OR DONE TO THE VEHICLE. THE CONTAC…
Read full complaint
TL*- THE CONTACT CALLED REGARDING A 2000 KIA SPECTRUM. THE CONTACT OWNED THE VEHICLE SINCE 2002 AND ALL FOUR DOORS WILL NOT SHUT WHEN IT WAS COLD OUTSIDE. THE CONTACT DID NOT KNOW IF THIS FAILURE OCCURRED DURING A SPECIFIC TEMPERATURE. THE CONTACTDID NOT REMEMBER WHAT THE DEALER SAID OR DONE TO THE VEHICLE. THE CONTACT STATED THAT THE DOORS EVENTUALLY SHUT. SHE HAD TIED THE DOORS SHUT TO KEEP THEM FROM OPENING.*AK
NHTSA ODI #10181191
Mileage unknown · Oct 24, 2006
Tires
PURCHASED A SET OF 4 MICHELIN X RADIAL TIRES 10/2005. IN MAY 2006 NOTICED A CRACK/CUT IN SIDEWALL OF TIRE. TIRE REPLACED AT COSTCO UNDER ROAD HAZARD WARRANTY. IN AUGUST 2006, ANOTHER TIRE SUFFERED A RUPTURE IN THE SIDEWALL CAUSING CAR TO HIT CURB. AGAIN REPLACED UNDER COSTCO ROAD HAZARD WARRANTY, DUE TO NOT BEING ABLE TO PROVE …
Read full complaint
PURCHASED A SET OF 4 MICHELIN X RADIAL TIRES 10/2005. IN MAY 2006 NOTICED A CRACK/CUT IN SIDEWALL OF TIRE. TIRE REPLACED AT COSTCO UNDER ROAD HAZARD WARRANTY. IN AUGUST 2006, ANOTHER TIRE SUFFERED A RUPTURE IN THE SIDEWALL CAUSING CAR TO HIT CURB. AGAIN REPLACED UNDER COSTCO ROAD HAZARD WARRANTY, DUE TO NOT BEING ABLE TO PROVE WE DIDN'T HIT SOMETHING THAT CAUSED SIDEWALL RUPTURE. OCTOBER 2006 STILL ANOTHER TIRE WAS NOTICED WITH A LARGE BUBBLE IN THE SIDEWALL. REPLACED AGAIN UNDER ROAD HAZARD WARRANTY AT COSTCO. ALL TIRES THAT WERE REPLACED WERE DOT HCP8HYUX2505. *NM
NHTSA ODI #10171704
5,000 miles · Sep 27, 2006
StructureUnknown Or Other
MY KIA SEPHIA WAS PURCHASED IN 2000 AND AT APPROXIMATED 32,000 MILES THE PAINT ON THE CAR IS PEELING AND FADED AS WELL AS THE ENTIRE DASHBOARD HAS LIFTED AND IS RAISED. I SEE THE SAME PROBLEMS WITH OTHER SEPHIA'S WHEN I AM IN PARKING LOTS OR ON THE ROAD. I CALLED CORAL SPRINGS KIA SEVERAL TIMES AND I AM BEING TOLD THAT BECAUSE…
Read full complaint
MY KIA SEPHIA WAS PURCHASED IN 2000 AND AT APPROXIMATED 32,000 MILES THE PAINT ON THE CAR IS PEELING AND FADED AS WELL AS THE ENTIRE DASHBOARD HAS LIFTED AND IS RAISED. I SEE THE SAME PROBLEMS WITH OTHER SEPHIA'S WHEN I AM IN PARKING LOTS OR ON THE ROAD. I CALLED CORAL SPRINGS KIA SEVERAL TIMES AND I AM BEING TOLD THAT BECAUSE I LIVE IN FLORIDA THE PROBLEM IS TO BE EXPECTED. THIS IS A BLATANT LIE. ON MONDAY 9/25 I CALLED KIA CUSTOMER SERVICE AND SPOKE TO JOHN AT EXTENSION 4635. HE TOLD ME HE WOULD CONTACT THE DEALERSHIP AND SOMEONE WOULD CALL ME. I RECEIVED A CALL FROM THE SERVICE DEPARTMENT AND THEY OFFERED TO SUPPLY THE PARTS BUT NOT THE LABOR TO FIX THE PROBLEMS. THIS IS NOT ACCEPTABLE. IF THEY AGREE TO SUPPLY THE PARTS THEN THEY KNEW OR KNOW THIS MAKE A MODEL IS HAVING PROBLEMS. I WOULD LIKE TO KNOW IF YOU CAN ADVISE MY NEXT COURSE OF ACTION. *JB
NHTSA ODI #10169419
78,000 miles · Aug 3, 2006
Structure
SEPHIA KIA DASH BOARD ....WARRANTY,IS ONLY 36,000 MILES THE SEAMS ARE TORN OUT ON THE DASH BOARD IN FRONT OF THE MILEAGE ODOMETER AND MAKING ME SICK,THE DASHBOARD ON THE PASSENGER SIDE IS BUFFED UP WITH THE AIR VENT BUFFERED UP TOWARD THE WINDOW, KEEPING ME FROM GETTING ANY AIR. I HAVE TAKEN THE CAR TOO DR.VINLYN.. THE ONLY PE…
Read full complaint
SEPHIA KIA DASH BOARD ....WARRANTY,IS ONLY 36,000 MILES THE SEAMS ARE TORN OUT ON THE DASH BOARD IN FRONT OF THE MILEAGE ODOMETER AND MAKING ME SICK,THE DASHBOARD ON THE PASSENGER SIDE IS BUFFED UP WITH THE AIR VENT BUFFERED UP TOWARD THE WINDOW, KEEPING ME FROM GETTING ANY AIR. I HAVE TAKEN THE CAR TOO DR.VINLYN.. THE ONLY PERSON THAT FIXES DASH BOARDS IN MY STATE, AND TO AN UPHOLSTERY SHOP, NEITHER ONE WOULD FIX IT..THEY STATE, KIA MANUFACTURER IS NOT MAKING THE DASHBOARDS THE SAME AND THERE ONLY MADE OUT OF PLASTIC NOW, NO USE IN FIXING IT, MIGHT AS WELL BUY A NEW DASHBOARD, CAUSE KIA DOESN'T MAKE GREAT DASHBOARDS FOR CARS ANY LONGER, AND THE DASHBOARDS ARE ONLY PLASTIC.. I WAS ALSO TOLD, A LOT OF KIA'S CARS HAVE BEEN BUFFERED UP, AND NOTHING BUT PLASTIC. I WAS TOLD I WOULD BE BETTER OFF, IF I COULD FIND A BETTER DASHBOARD THAN WHAT I HAVE NOW,CAUSE IT WOULD JUST COME A LOOSE AGAIN BY THE HEAT,IF IT IS STILL PLASTIC.. KIA CARS OF AMERICA...CLAIMS MY WARRANTY IS ONLY 36,000 MILES WARRANTY,BUT I NEED MY CAR FIXED BY KIA CARS OF AMERICA,MY DASH BOARD IS MADE OUT OF PLASTIC,AND I FAULT KIA MOTORS FOR BUILDING THIS CAR LIKE THIS, I HAVE BREATHING PROBLEMS, AND UNLESS KIA WANTS TO GIVE ME ANOTHER CAR, I WANT THEM TO FIX THIS CAR,THIS IS NOT THE WAY I BROUGHT THIS CAR AND IT IS TORN UP INSIDE, BUSTED UP BY HEAT. THANK YOU FOR E-MAILING ME BACK, AT MY EMAIL ABOVE. I AM VERY DISAPPOINTED IN KIA CARS, I WANTED TO STICK WITH KIA CARS, BUT AFTER THIS ,I DON'T KNOW, I JUST KNOW, I NEED KIA CARS OF AMERICA TO FIX THIS CAR. THE SMELL IN THIS CAR WITH THE SEAMS BUSTED IS MAKING ME SICK. *JB
NHTSA ODI #10164428
65,000 miles · Jul 26, 2006
Electrical SystemSuspension
BOTH LOWER CONTROL ARMS HAVE GONE AT THE SAME TIME...AT 65,000 MILES...WHICH WHEN I CHECKED WITH REPAIR SHOP IS HIGHLY UNUSUAL THAT AT THIS LOW MILES ONE WOULD GO LET ALONE BOTH...HE SAID IT IS A QUALITY ISSUE. KIA SAYS ITS NOT COVERED...WHEN WENT TO GET OUT OF DRIVERS SIDE THE DOOR HANDLE SNAPPED OFF. AN ELECTRICAL PROBLEM WI…
Read full complaint
BOTH LOWER CONTROL ARMS HAVE GONE AT THE SAME TIME...AT 65,000 MILES...WHICH WHEN I CHECKED WITH REPAIR SHOP IS HIGHLY UNUSUAL THAT AT THIS LOW MILES ONE WOULD GO LET ALONE BOTH...HE SAID IT IS A QUALITY ISSUE. KIA SAYS ITS NOT COVERED...WHEN WENT TO GET OUT OF DRIVERS SIDE THE DOOR HANDLE SNAPPED OFF. AN ELECTRICAL PROBLEM WITH HEATER/AIR CONDITIONER...TOOK TO KIA EAST SYRACUSE, NY THEY SAID THEY DON'T MAKE THEM ANY MORE BECAUSE SO MANY PROBLEMS. *NM
NHTSA ODI #10163581
Mileage unknown · Jul 8, 2006
Unknown Or Other
DASHBOARD WARPED AND BROKE THE DEFROSTER VENT. SAFETY HAS BEEN GREATLY COMPROMISED BECAUSE AIR IS NO LONGER ABLE TO BE DIRECTED TOWARDS THE WINDSHIELD DURING DEFOGGING/DEFROSTING. *JB
NHTSA ODI #10161867
Mileage unknown · Jun 9, 2006
Service Brakes, Hydraulic
REGULAR DRIVING CAUSING BRAKES ON 2000 KIA SEPHIA TO REQUIRE CONSTANT MAINTENANCE ON THE FRONT ROTORS AND PADS. AT VARIED INTERVALS, THE BRAKES WOULD BEGIN TO START VIBRATING WHEN APPLIED, ESPECIALLY ON THE HIGHWAY AT HIGH SPEEDS (60 MPH) AND GOING DOWN HILLS. THERE HAS BEEN NO ACCIDENTS BUT MANY CLOSE CALLS. THIS IS A VERY DANG…
Read full complaint
REGULAR DRIVING CAUSING BRAKES ON 2000 KIA SEPHIA TO REQUIRE CONSTANT MAINTENANCE ON THE FRONT ROTORS AND PADS. AT VARIED INTERVALS, THE BRAKES WOULD BEGIN TO START VIBRATING WHEN APPLIED, ESPECIALLY ON THE HIGHWAY AT HIGH SPEEDS (60 MPH) AND GOING DOWN HILLS. THERE HAS BEEN NO ACCIDENTS BUT MANY CLOSE CALLS. THIS IS A VERY DANGEROUS SAFETY HAZARD. THERE IS CLEARLY A FLAW IN THE BRAKING SYSTEM, THAT KIA OBVIOUSLY WILL NOT ACKNOWLEDGE. AS A MATTER OF FACT, I HAVE TO REPLACE THE ROTORS THIS WEEK BECAUSE THEY HAVE BEEN SHAVED DOWN SO MUCH. FIVE TIMES IN 2 YEARS, AND I WON'T EVEN DRIVE THE CAR FOR MONTHS AT A TIME. MOSTLY BECAUSE OF THIS REASON. *JB
NHTSA ODI #10159417
Mileage unknown · Mar 24, 2006
Equipment
THE DEFROSTER VENTS ON TOP OF THE DASHBOARD HAVE POPPED OFF. *JB
NHTSA ODI #10153592
40,000 miles · Mar 20, 2006
Visibility
1. REAR WINDOW TINT DAMAGED BY DEFOSTER WIRES CAUSING THE TINT TO BUBBLE AND OBSTRUCT REAR VIEW. 2. HEAT DAMAGE TO FRONT DASH RESULTS IN AN ADJUSTMENT OR MOVEMENT TO THE FROMT WINDSHEILD CREATING CRACKS IN WINDSHILED TO LARGE TO REPAIR. OCCURS WITH BOTH FACTORY AND COMMERCIALLY INSTALLED GLASS. 3. A SUB RESULT OCCURS WHE…
Read full complaint
1. REAR WINDOW TINT DAMAGED BY DEFOSTER WIRES CAUSING THE TINT TO BUBBLE AND OBSTRUCT REAR VIEW. 2. HEAT DAMAGE TO FRONT DASH RESULTS IN AN ADJUSTMENT OR MOVEMENT TO THE FROMT WINDSHEILD CREATING CRACKS IN WINDSHILED TO LARGE TO REPAIR. OCCURS WITH BOTH FACTORY AND COMMERCIALLY INSTALLED GLASS. 3. A SUB RESULT OCCURS WHERE THE DEFROSTER VENTS ON THE DASH BREAK AND NO LONGER PROVIDE DIRECTED AIR TO THE WINDSHILED, CAUSING OBSTRUCTED VIEWS. *JB
NHTSA ODI #10153186
NHTSA investigations
7EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
EA04004 · Refueling Spit Back
Opened Feb 3, 2004 · Closed Jul 29, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (7)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ03006 · Refueling Spit Back
Opened Aug 15, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (6)
Fuel System, Gasoline
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA02016 · NON-CRASH Engine Compartment Fires
Opened Aug 6, 2002 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Electrical System
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
PE02028 · Battery Cable Chafing
Opened Mar 6, 2002 · Closed Aug 6, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE00026 · Incorrect Battery JUMP-START
Opened Jul 10, 2000 · Closed Jul 31, 2000
Status: closed (inferred from source dates) · Electrical System
ALLEGE BATTETY MAY EXPLODE IF OWNER'S ATTEMPT TO JUMP-STATE THE VEHICLE BY FOLLOWING THE OWNER'S MANUAL DIAGRAM
Illustration