NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
7 reportsClear category filterMileage unknown · May 5, 2005
Exterior Lighting
HEADLIGHT HOUSING HAS SEVERE DISCOLORATION AFTER ONLY A LITTLE OVER 4.5 YEARS OF USE. PURCHASED THE VEHICLE NEW AND HAVE HAD NO ACCIDENTS. BOTH SIDE MARKERS RIGHT NEXT OF THE HEADLIGHT HOUSINGS ARE AS CLEAR AS GLASS, HOWEVER, THE HEADLIGHT HAS TURNED VERY DINGY, DULL YELLOW TO THE POINT WHERE IT IS VERY HARD TO SEE AT NIGHT. …
Read full complaint
HEADLIGHT HOUSING HAS SEVERE DISCOLORATION AFTER ONLY A LITTLE OVER 4.5 YEARS OF USE. PURCHASED THE VEHICLE NEW AND HAVE HAD NO ACCIDENTS. BOTH SIDE MARKERS RIGHT NEXT OF THE HEADLIGHT HOUSINGS ARE AS CLEAR AS GLASS, HOWEVER, THE HEADLIGHT HAS TURNED VERY DINGY, DULL YELLOW TO THE POINT WHERE IT IS VERY HARD TO SEE AT NIGHT. UPON DISCUSSING IT WITH KIA, THEY STATED THAT THE VEHICLE IS OUT OF WARRANTY AND THAT THERE WAS NO OTHER REPORTED CASES OF THIS HAPPENING. I HAVE SPOKEN TO THE SERVICE MANAGER WHERE I GET MY VEHICLE SERVICED AND HAD THE HEADLIGHTS LOOKED AT STATED LIKEWISE THAT KIA KNOWS THAT THERE IS A PROBLEM, BUT WILL NOT DO ANYTHING ABOUT IT IF THE VEHICLE IS OUT OF WARRANTY WHICH IT IS BECAUSE AT THE TIME OF PURCHASE THERE WAS ONLY A 5/50 WARRANTY. THE PRICE OF THE PARTS NEARLY $400.00 WHICH I BELIEVE SHOULD NOT BE CHARGED TO ME SINCE THERE IS A CLEAR DEFECT IN THE HEADLIGHT HOUSING THAT IS CAUSING THE DISCOLORATION TO OCCUR IN SUCH SHORT TIME OF OWNERSHIP. THIS IS A MAJOR SAFETY ISSUE THAT REQUIRES TO BE ADDRESSED BY KIA.
NHTSA ODI #10120008
Mileage unknown · Jun 26, 2002
Exterior LightingPower Train
30 NOV 99-BLINKERS INTERMITTENTLY INOPERABLE (MO=2,415);28 DEC 99-BLINKERS INTERMITTENTLY INOPERABLE (MO=3,044);13 JAN 00-BLINKERS INTERMITTENTLY INOPERABLE (MO=3,423);16 MAR 00-BLINKERS INTERMITTENTLY INOPERABLE (MO=5,268);8 MAR 01-GEAR SHIFT LEVER INTERMITTENTLY WON'T SHIFT(MO=26,471);20 NOV 01-GEAR SHIFT LEVER INTERMITTENLY W…
Read full complaint
30 NOV 99-BLINKERS INTERMITTENTLY INOPERABLE (MO=2,415);28 DEC 99-BLINKERS INTERMITTENTLY INOPERABLE (MO=3,044);13 JAN 00-BLINKERS INTERMITTENTLY INOPERABLE (MO=3,423);16 MAR 00-BLINKERS INTERMITTENTLY INOPERABLE (MO=5,268);8 MAR 01-GEAR SHIFT LEVER INTERMITTENTLY WON'T SHIFT(MO=26,471);20 NOV 01-GEAR SHIFT LEVER INTERMITTENLY WON'T SHIFT(MO=33,853);30 MAY 02-GEAR SHIFT LEVER INTERMITTENTLY WON'T SHIFT(MO=33,853);5 JUN 02-GEAR SHIFT LEVER INTERMITTENLY WON'T SHIFT(MO=33,933);19 JUN 02-GEAR SHIFT LEVER INTERMITTENLY WON'T SHIFT(MO=34,443);20 JUN 02-GEAR SHIFT LEVER INTERMITTENLY WON'T SHIFT(MO=34, 536);GEAR SHIFT ASSY CHANGED 4 TIMES--COMPANY CLAIMS CAN'T VERIFY PROBLEM. HAVE TWO WITNESSES WITH SIGNATURES FROM PLACE OF EMPLOYMENT WHO HAVE SIGNED STATEMENTS THAT THEY TRIED TO GET GEAR SHIFT LEVER OUT OF PARK WITHOUT SUCCESS. CAR GOES OUT OF BUMPER TO BUMPER WARRANTY IN LESS THAN 1500 MILES. POWER TRAIN WARRANTY STILL IN EFFECT. INFORMED COMPANY THAT REFUND IS DESIRED. FILED WITH BBB HERE IN CA AS REQUIRED. THIS PROBLEM PRESENTS A REAL DANGER TO MYSELF IF CAN'T GET CAR OUT OF PARK; CAN'T TRUST CAR.*AK
NHTSA ODI #763537
Mileage unknown · Mar 1, 2002
Exterior Lighting
CONSUMER STATES SHE CONTINUES TO HAVE PROBLEMS WITH THE INTERIOR LIGHTS BLOWING OUT, THE DEALER TOOK THE LIGHT OUT AND ATTEMPTED TO FIX THE PROBLEM, HOWEVER THE PROBLEM REOCCURED, CONSUMER TOOK THE VEHICLE INTO A REPAIR SHOP AND WAS INFORMED THAT THE PROBLEM WAS IN THE SOCKET AND THAT THE DEALER HAD MESSED UP THE BULB SOCKET, PA…
Read full complaint
CONSUMER STATES SHE CONTINUES TO HAVE PROBLEMS WITH THE INTERIOR LIGHTS BLOWING OUT, THE DEALER TOOK THE LIGHT OUT AND ATTEMPTED TO FIX THE PROBLEM, HOWEVER THE PROBLEM REOCCURED, CONSUMER TOOK THE VEHICLE INTO A REPAIR SHOP AND WAS INFORMED THAT THE PROBLEM WAS IN THE SOCKET AND THAT THE DEALER HAD MESSED UP THE BULB SOCKET, PARTS OF THE SOCKET WERE BENT CAUSING THE 10 AMP FUSE TO BLOW, ONCE THE BRAKE LIGHT COVER WAS SNAPPED BACK ON, THE FUSE WOULD BLOW.*JB
NHTSA ODI #564679
Mileage unknown · Sep 24, 2001
Electrical SystemEquipmentExterior Lighting
HORN IS INOPERATIVE, PARTS ARE ON ORDER, HOWEVER DUE TO HORN NOT WORKING A VEHICLE BACKED INTO CONSUMER, CAUSING INJURY TO CONSUMER AND DAUGHTER. *JB
NHTSA ODI #563225
Mileage unknown · Oct 10, 2000
Exterior Lighting
EA00-018, TURN SIGNALS AND 4-WAYS FLASHERS WILL NOT OPERATE WHEN VEHICLE'S TEMPERATURE IS BELOW 38-40 DEGREES. THEY WILL BEGIN TO WORK ONCE VEHICLE OR EXTERIOR WARMS UP. CONSUMER HAS TAKEN VEHICLE TO DEALER 5 TIMES, AND HAS REPLACED FLASHER SWITCH TWICE. ALSO, FLASHER ONCE, BUT DEFECT KEEPS OCCURRING.*AK
NHTSA ODI #872598
Mileage unknown · Feb 8, 2000
Exterior LightingLatches/locks/linkagesVisibility
WINDSHIELD WIPERS ALONG WITH OTHER SAFTEY FEATURES ON THE VEHICLE ARE NOT FUNCTIONING PROPERLY. DOOR LOCKS BECOME JAMMED FROM THE INSIDE AND OUTSIDE, AND THE SIGNAL LIGHTS ARE NOT VISIBLE FROM THE OUTSIDE OF VEHICLE. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #856476
Mileage unknown · Nov 15, 1999
Exterior Lighting
HEADLIGHT HIGH BEAM IS OFF BY 10 % TO LEFT. WHEN MAKING A RIGHT TURN, THERE IS A BLIND SPOT TO THE RIGHT, CAUSING VISIBILITY PROBLEMS, WHICH MAY RESULT IN A CRASH. DEALER SAID THERE WAS NO SOLUTION FOR THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #852886
NHTSA investigations
7EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
EA04004 · Refueling Spit Back
Opened Feb 3, 2004 · Closed Jul 29, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (7)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ03006 · Refueling Spit Back
Opened Aug 15, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (6)
Fuel System, Gasoline
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA02016 · NON-CRASH Engine Compartment Fires
Opened Aug 6, 2002 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Electrical System
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
PE02028 · Battery Cable Chafing
Opened Mar 6, 2002 · Closed Aug 6, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE00026 · Incorrect Battery JUMP-START
Opened Jul 10, 2000 · Closed Jul 31, 2000
Status: closed (inferred from source dates) · Electrical System
ALLEGE BATTETY MAY EXPLODE IF OWNER'S ATTEMPT TO JUMP-STATE THE VEHICLE BY FOLLOWING THE OWNER'S MANUAL DIAGRAM
Illustration