NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
88 reportsClear category filter65,000 miles · Jul 14, 2003
Engine And Engine Cooling
REPEATED PROBLEM WITH BATTERY. REPLACED 3 TIMES. NEVER LIKED TO START, ALWAYS SHIMMIED.RETURNED TO DEALER FOR TUNE UP. CAR WAS RETURNED WITH MORE PROBLEMS THAT TURNED IN WITH. CAR WOULDN'T KEEP A CONSTANT GAS FLOW.*AK TRADED IT IN AND THE DEALER SAID THE MOTOR WAS BAD AND HEADED FOR A TOTAL BREAK DOWN. WHEN IT DIED - IT WA…
Read full complaint
REPEATED PROBLEM WITH BATTERY. REPLACED 3 TIMES. NEVER LIKED TO START, ALWAYS SHIMMIED.RETURNED TO DEALER FOR TUNE UP. CAR WAS RETURNED WITH MORE PROBLEMS THAT TURNED IN WITH. CAR WOULDN'T KEEP A CONSTANT GAS FLOW.*AK TRADED IT IN AND THE DEALER SAID THE MOTOR WAS BAD AND HEADED FOR A TOTAL BREAK DOWN. WHEN IT DIED - IT WAS THREE YEARS OLD WITH 60,000 MILES.
NHTSA ODI #10026058
Mileage unknown · Jul 11, 2003
Engine And Engine CoolingFire
WHILE DRIVING THE VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT. *MR *CB *NLM
NHTSA ODI #10029424
594 miles · Jul 4, 2003
Engine And Engine CoolingFuel System, GasolinePower Train
CONSUMER HAS EXPERIENCED SEVERAL PROBLEMS WITH 1999 KIA SEPHIA. NAR 07/21/2003.*MR TRANSMISSION, REAR BLINKERS, BRAKE PADS, FUEL PUMP AND VALVE. *CB
NHTSA ODI #10030046
Mileage unknown · Jun 26, 2003
Engine And Engine CoolingFire
WHILE DRIVING, THE CONSUMER HEARD A NOISE AND PULLED OVER, THE CONSUMER WAS THEN INFORMED BY A PASSING MOTORIST, THE VEHICLE WAS ON FIRE. *TS *JB
NHTSA ODI #10026154
Mileage unknown · Feb 10, 2003
Engine And Engine CoolingFire
AIR INTAKE MANIFOLD CAUGHT ON FIRE. *JB
NHTSA ODI #10008888
Mileage unknown · Jan 14, 2003
Engine And Engine Cooling
CONSUMER STATED THE RESONATOR SEPARATED AT THE SEAM AND COULD CAUSE VEHICLE FUMES. CONSUMER CONTACTED THE SERVICE DEPARTMENT, AND WAS TOLD THAT IT WAS A MANUFACTURER DEFECT, AND WAS NOT DAMAGED WITH NORMAL WEAR AND TEAR. SCC *JB
NHTSA ODI #10001956
Mileage unknown · Nov 13, 2002
Engine And Engine Cooling
THIS VEHICLE JUST TURNS OFF DURING DRIVING - STALLS OUT AT ANY TIME. HAD THE VEHICLE TOWED INTO DEALERSHIP 2 TIMES, ONLY TO DRIVE OFF BOTH TIMES AND BREAK DOWN. IT'S IN THE SHOP NOW FOR THE THIRD TIME. THEY SAID IT WAS THE FUEL PUMP (REPLACED, STILL STALLS), THEN THE CATALYTIC CONVERTERS (REPLACED, STILL STALLS), NOW THE WIRI…
Read full complaint
THIS VEHICLE JUST TURNS OFF DURING DRIVING - STALLS OUT AT ANY TIME. HAD THE VEHICLE TOWED INTO DEALERSHIP 2 TIMES, ONLY TO DRIVE OFF BOTH TIMES AND BREAK DOWN. IT'S IN THE SHOP NOW FOR THE THIRD TIME. THEY SAID IT WAS THE FUEL PUMP (REPLACED, STILL STALLS), THEN THE CATALYTIC CONVERTERS (REPLACED, STILL STALLS), NOW THE WIRING HARNESS. TOO DANGEROUS TO DRIVE THIS CAR. THEY DON'T HAVE A CLUE WHAT'S WRONG. I'M SCARED TO DRIVE IT AFTER I'VE BEEN VIRTUALLY RUN OVER WHEN THE ENGINE CUTS OFF. DT
NHTSA ODI #769684
Mileage unknown · Nov 12, 2002
Engine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING THE BRAKES FAILED, THE VEHICLE HAD TO BE STOPPED BY PULLING THE EMERGENCY BRAKE AT WHICH TIME THE CONSUMER NOTICED A FIRE UNDER THE HOOD OF THE VEHICLE, POSSIBLY BRAKE OR ENGINE FAILURE. NLM
NHTSA ODI #568217
30,000 miles · Oct 21, 2002
Engine And Engine CoolingPower Train
THE TRANSMISSION FAILED AT 30,000, WHEN THE VEHICLE WAS REPAIRED, CONSUMER WAS INFORMED THAT EVENTUALLY THERE WOULD BE PROBLEMS WITH THE ENGINE, CONSUMER STATED IT TOOK NUMEROUS TIRES TO GET THE VEHICLE TO START. TS *JB
NHTSA ODI #8021280
Mileage unknown · Oct 3, 2002
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
ON FOUR OCCASIONS THE IGNITION FAILED CAUSING THE VEHICLE TO STALL WHILE IN TRAFFIC, THE DEALER HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM. NLM
NHTSA ODI #567727
NHTSA investigations
12EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
EA04004 · Refueling Spit Back
Opened Feb 3, 2004 · Closed Jul 29, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (7)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly:filling/charging
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Other:storage:tank Assembly
BASED ON THE LOW RATE OF FUEL SPIT-BACK INCEDENTS (14.3 INCIDENTS PER 100,000 VEHICLES SOLD), A LOW WARRANTY CLAIMS RATE OF 0.02 PERCENT, AND THE LACK OF ENGINEERING INFORMATION THAT WOULD SUPPORT THE PRESENCE OF AN ENGINEERING DEFECT, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
RQ03006 · Refueling Spit Back
Opened Aug 15, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (6)
Fuel System, Gasoline
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Gasoline:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly:filling/charging
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Fuel System, Other:storage:tank Assembly
IN JUNE 2000, KIA NOTIFIED ODI OF A DEFECT CONDITION IN APPROXIMATELY 100,000 MY 1998-99 SEPHIA PASSENGER VEHICLES MANUFACTURED FROM OCTOBER 17, 1997 TO MAY 16, 1999, THAT COULD RESULT IN FUEL SPIT BACK WHILE REFUELING (EA99-034, RECALL 00V-175).ACCORDING TO KIA, MANUFACTURING CHANGES MADE TO THE ONBOARD REFUELING VAPOR RECOVERY (ORVR) VALVE COULD CAUSE FUEL SHUT OFF BEFORE THE TANK REACHED 95% OF NOMINAL CAPACITY DURING REFUELING.KIA STATED THAT IF THE CONSUMER THEN ATTEMPTED TO ADD MORE FUEL TO THE TANK, FUEL SPILLBACK OR SPITBACK FROM THE FUEL FILLER NECK COULD OCCUR.KIA REPLACED THE ORVR VALVES IN THE RECALLED VEHICLES.ODI HAS RECEIVED 16 COMPLAINTS OF FUEL SPIT BACK ON VEHICLES THAT HAVE RECEIVED THE RECALL AND 5 COMPLAINTS ON VEHICLES THAT WERE NOT COVERED BY THE RECALL.KIA HAS IDENTIFIED 2 FUEL SPIT BACK COMPLAINTS ON VEHICLES THAT WERE RECALLED AND 8 COMPLAINTS ON VEHICLES NOT COVERED BY THE ORIGINAL RECALL.KIA HAS ALSO PROVIDED WARRANTY INFORMATION SHOWING 191 CLAIMS POTENTIALLY RELATED TO FUEL SPITBACK ON NON-RECALLED VEHICLES. ODI HAS UPGRADED ITS INVESTIGATION TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE SCOPE, FREQUENCY, AND TREND OF THE FUEL SPITBACK RISK ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
EA02016 · NON-CRASH Engine Compartment Fires
Opened Aug 6, 2002 · Closed Oct 7, 2003
Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery:cables
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
Electrical System
ODI GATHERED FIRE DATA FROM VARIOUS SOURCES AND INSPECTED SUBJECT VEHICLES TO ASSESS THE SCOPE AND FREQUENCY OF NON-CRASH ENGINE COMPARTMENT FIRES CAUSED BY STARTER CABLE CHAFING.ODI'S ANALYSIS FOUND THAT MOST OF THE SUSPECT FIRES OCCURRED AFTER THE VEHICLE HAD RECEIVED SERVICE REPAIRS IN THE AREA OF THE SUBJECT CABLE.CONSUMER COMPLAINT DATA INDICATE THAT THE PROBLEM EXPERIENCE HAS DECLINED SINCE A PEAK IN LATE 2001.THE MOST RECENT KNOWN EVENT OCCURRED IN NOVEMBER OF 2002. KIA WILL PERFORM A SERVICE CAMPAIGN BEGINNING IN LATE 2003 TO INSPECT SUBJECT VEHICLES BUILT PRIOR TO JANUARY 2000 FOR CABLE DAMAGE AND WILL REPLACE DAMAGED CABLES AS NECESSARY. GIVEN THE DECLINING FIRE RATE AND KIA?S SERVICE CAMPAIGN, FURTHER EXPENDITURE OF AGENCY RESOURCES IS UNJUSTIFIED IN THIS MATTER.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED. FURTHER DETAILS MAY BE FOUND IN THE ATTACHED CLOSING REPORT.
PE02028 · Battery Cable Chafing
Opened Mar 6, 2002 · Closed Aug 6, 2002
Status: closed (inferred from source dates) · Electrical System
No summary supplied.
PE00028 · Transmission Oil Cooler Line
Opened Jul 12, 2000 · Closed Nov 7, 2000
Status: closed (inferred from source dates) · Power Train
THE OIL COOLER LINE ALLEGEDLY DEVELOPS LEAKS AT IT'S JUNCTION TO THE RADIATOR
EA00018 · Turn Sighal
Opened Jun 29, 2000 · Closed Jul 29, 2002
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00004 · Turn Signal, Traffic Safety Hazard
Opened Jan 13, 2000 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Exterior Lighting
ALLEGE THAT WHILE DRIVING, THE TRUN SIGNAL SWITCH FAILED.THIS FAILURE INCREASES THE RISK OF A VEHICLE CRASH DUE TO OPERATOR DISTRACTION AND DUE TO OTHER VEHICLES BEING UNINFORMED OF THE OPERATOR'S INTENTIONS.
EA99034 · Refueling Spit Back
Opened Dec 16, 1999 · Closed Jun 29, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
The number and dates of complaints and warrant claims reported by Kia indicates that fuel spit-back has been a serieous ongoing problem with the Sephia models.Kia has made changes in both the ORVR valve and in the installation process on the fuel tank check valve, in an attempt to correct the problem.The failure of the check valve, due to cracking during installation, could go undetected until problems develop with the ORVR valve.Should an ORVR valve malfunction, when the vehicle has a tank chech valve with a latent crack, significant fuel spitting out the fuel filler pipe during refueling is possible.Current owners of 1998 and 1999 models could still be driving vehicles with latent defects.
SQ99020 · Intermittent Stalling
Opened Jun 30, 1999 · Closed Jan 12, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
Additional source detail variants (2)
Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
Vehicle Speed Control:linkages
Kia issued a Kia Technical Times in October 1998 stating that, due to loose connections at the fuel pump ground at G300, the fuel pump may shut off intermittently.The corrective action is to solder the fuel pump ground terminals at the terminal connec
PE99042 · Refueling SPIT- Back
Opened Jun 24, 1999 · Closed Dec 16, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
The subject vehicles are equipped with Onboard Refueling Vapor Recover Systems.Owners report that, during the refueling process, fuel sprays out of the refueling opening and soaks the person refueling the vehicle with liquid gasoline
Illustration