SkipThatYearREAL DATA. SMARTER CAR DECISIONS.
← New search

1997 Kia Sephia

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 1997 Kia Sephia do not stand out strongly from the model-year median of 107.

About this comparison →
205Owner complaints

Model-year median: 107

1Recall campaigns

View recall details →

1Investigations

View investigation details →

How this year compares

Owner complaints by model year

Other model years Selected year
16
199464
1995118
1996205
1997491
1998428
1999266
2000
Compare all Sephia years →

Counts vary with age, sales and reporting. They are not failure rates.

What owners reported most

Service Brakes, Hydraulic
72Engine And Engine Cooling
44Electrical System
31Air Bags
30Power Train
30
All reported categories
Seat Belts
20Unknown Or Other
20Structure
19Visibility
14Fuel System, Gasoline
11Vehicle Speed Control
8Steering
7Tires
7Equipment
5Service Brakes, Air
4Suspension
4Exterior Lighting
2Interior Lighting
2Fuel System, Other
1Latches/locks/linkages
1Seats
1Wheels
1

Tap a category to read its complaints. One report may name several components.

When problems were reported

Mileage at the reported incident

Limited mileage data: 15 of 205 reports include usable mileage. There isn’t enough coverage to show a useful chart.

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes, Hydraulic. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine And Engine Cooling. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

30 crash reports5 fire reports20 injury reports

Fuel System, Gasoline complaints

11 reports
Clear category filter
Mileage unknown · Sep 28, 2001
Fuel System, Gasoline

THE CAR WAS ACTING UP, WE THOUGHT IT WAS OVERHEATING,BECAUSE WHEN THE CAR COOLED OFF IT WOULD START. ON 7/04/2001 WE WERE GOING DOWN THE ROAD AT 55 MPH WHEN IT SHUT OFF. IT WOULD NOT START AGAIN. TOOK IT TO A MECHANIC .HE SAID THE FUEL PUMP WAS BAD. REPLACED IT. TOOK A TRIP TO MASS. CAR DIED AGAIN. TOLD FUEL RELAY WAS BAD,REPLAC…

Read full complaint

THE CAR WAS ACTING UP, WE THOUGHT IT WAS OVERHEATING,BECAUSE WHEN THE CAR COOLED OFF IT WOULD START. ON 7/04/2001 WE WERE GOING DOWN THE ROAD AT 55 MPH WHEN IT SHUT OFF. IT WOULD NOT START AGAIN. TOOK IT TO A MECHANIC .HE SAID THE FUEL PUMP WAS BAD. REPLACED IT. TOOK A TRIP TO MASS. CAR DIED AGAIN. TOLD FUEL RELAY WAS BAD,REPLACED,08/10/2001. COMING HOME FIRST TIME CHECK ENGINE LIGHT CAME ON.TOOK IT TO DEALER.EGR VALVE REPLACED ABOUT 08/21/2001. 09/25/2001 CAR DIES TAKE IT TO A MECHANIC,CHECKS,FUEL PUMP BAD AGAIN. VERY DISTURBING, I DON'T WANT DEALERS TO WORK ON IT. SAY I NEED AN INVOICE# FOR WORK ORDER BEFORE I CAN GET FUEL PUMP. MECHANIC IS FRIEND KIA CERTIFIED I TRUST HIM TO FIX THE PROBLEM LONG TERM, NOT THE DEALER. IF YOU WEREN'T AWARE I MOVED TO VA.5 MNTHS AGO.*AK

NHTSA ODI #752704

Mileage unknown · Jan 19, 2001
Engine And Engine CoolingFuel System, GasolineUnknown Or Other

ENGINE & ENGINE CHECK LIGHT & POWER/FUEL INJECTION SWITCH. BEEN IN THE SERVICE DEPARTMENT FOR CHECKUPS AND REPAIRS 5 TIMES FOR THE SAME THING. CAR IS DEAD, TIMING CHAIN BROKE AND THE BLOCK FROZED UP.

NHTSA ODI #739629

Mileage unknown · Sep 26, 2000
Fuel System, GasolineFire

CONSUMER'S VEHICLE CAUGHT ON FIRE TOWARDS THE END AND ABOVE THE MUFFLER AND ABOVE FUEL TANK. DEALER HAS RECOGNIZED THE ACTUAL CAUSE OR REMEDY, BUT WAS READY TO HAVE CONSUMER PICK UP THE VEHICLE. PRIOR TO FIRE, VEHICLE WAS LOSING POWER AND WOULD NOT ACCELERATE. PLEASE FILLE ADDTIONAL INFORMATION. *AK

NHTSA ODI #871556

Mileage unknown · Sep 19, 2000
Fuel System, GasolineFire

FUEL TANK CAUGHT ON FIRE WHILE DRIVING. *AK

NHTSA ODI #870947

Mileage unknown · Jun 7, 2000
Electrical SystemEngine And Engine CoolingEquipment

ONGOING PROBLEM WITH BATTERY FAILURE; DEALER NOTIFIED, AND REPLACED FAULTY BATTERY ON TWO OCCASIONS, AND PROBLEM REOCCURRED. ALSO, AND PROBLEM ENGINE HESITATION. DEALER NOTIFIED. *AK THE CONSUMER FOUND OUT RIGHT AFTER LEASING THE VEHICLE, THAT THE RADIO WAS INOPERABLE. THE VEHICLE BEGAN SQUEEKING IN THE REAR END WHEN TURNIN…

Read full complaint

ONGOING PROBLEM WITH BATTERY FAILURE; DEALER NOTIFIED, AND REPLACED FAULTY BATTERY ON TWO OCCASIONS, AND PROBLEM REOCCURRED. ALSO, AND PROBLEM ENGINE HESITATION. DEALER NOTIFIED. *AK THE CONSUMER FOUND OUT RIGHT AFTER LEASING THE VEHICLE, THAT THE RADIO WAS INOPERABLE. THE VEHICLE BEGAN SQUEEKING IN THE REAR END WHEN TURNING. THE HEATER MALFUNCTIONED. THE LEFT REAR STRUT ASSEMBLY FAILED CAUSING KNOCKING NOISE AT RIGHT REAR. THE O-RING FAILED CAUSEING THE DISTRIBUTOR LEAK AND THERE WAS LOSS OF POWER WHILE DRIVING. *YH

NHTSA ODI #863221

Mileage unknown · Oct 13, 1999
Engine And Engine CoolingFuel System, GasolinePower Train

OXYGEN SENSOR FAILED CAUSING CHECK ENGINE LIGHT TO ILLUMINATE. MJS

NHTSA ODI #548983

Mileage unknown · Jun 4, 1999
Fuel System, GasolineFireInjury

CONSUMER WAS PUMPING GAS AT AN AMICO STATION---2216 PLANK RD. FREDRICKSBURG, VA. WHEN A FIRE BALL SHOT OUT OF GAS TANK AND IMMEDIATELY BEGAN TO BURN. CONSUMER FOUND A FIRE EXSTINGUSHER AND MANAGED TO PUT THE FIRE OUT. AK

NHTSA ODI #835219

Mileage unknown · Jan 18, 1999
Fuel System, Gasoline

I HAD THE VEHICLE REPAIRED FOR AN EMMISSIONS PROBLEM (SEE DEFECT INFO. #1)...7 DAYS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN. I TOOK THE VEHICLE BACK TO THE DEALER AND IT WAS BASICALLY THE SAME PROBLEM, EXCEPT I WAS TOLD IT WAS DUE TO THE GAS TANK BEING OVERFILLED. I DON'T SEE HOW THIS IS POSSIBLE SINCE I'VE BEEN DRIVING THE…

Read full complaint

I HAD THE VEHICLE REPAIRED FOR AN EMMISSIONS PROBLEM (SEE DEFECT INFO. #1)...7 DAYS LATER THE CHECK ENGINE LIGHT CAME ON AGAIN. I TOOK THE VEHICLE BACK TO THE DEALER AND IT WAS BASICALLY THE SAME PROBLEM, EXCEPT I WAS TOLD IT WAS DUE TO THE GAS TANK BEING OVERFILLED. I DON'T SEE HOW THIS IS POSSIBLE SINCE I'VE BEEN DRIVING THE VEHICLE FOR ONLY A YEAR AND THE PROBLEM HAS JUST STARTED. THE PROBLEM CONCERNS ME BECAUSE I DON'T KNOW IF FUMES ARE BUILDING UP WHICH MAY CAUSE A MAJOR SAFETY HAZARD.

NHTSA ODI #702326

Mileage unknown · Aug 28, 1998
Fuel System, Gasoline

FUEL PUMP/GAS TANK MALFUNCTIONL.

NHTSA ODI #540364

Mileage unknown · Jul 23, 1998
Engine And Engine CoolingFuel System, Gasoline

FUEL INJECTION WIRING HARNESS, IDLE SET TOO LOW, COULD NO FIX IT THE LAST TIME, ENGINE STALLS

NHTSA ODI #538715

Official recalls

1

02V216000 · Seat Belts:front:buckle Assembly

Aug 16, 2002

ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.

Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

PE02051 · Safety Belt Buckle Malfunction

Opened Jun 17, 2002 · Closed Sep 20, 2002

Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly

BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.