IllustrationDASHBOARD HAS CURLED UP IN FRONT (AGAINST WINDSHIELD). BECAUSE OF THIS THE DEFROSTER WILL NOT DEFROST THE DRIVER SIDE OF THE WINDSHIELD. AS A RESULT I AM UNABLE TO SEE ADEQUATELY TO DRIVE ANYTIME MY WINDSHIELD IS FOGGY. THIS MAY ALSO CAUSE PROBLEMS WITH AIRBAG DEPLOYMENT BUT I'M NOT SURE.
1996 Kia Sephia
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Kia Sephia do not stand out strongly from the model-year median of 107.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sephia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 118 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports4 fire reports8 injury reports
Unknown Or Other complaints
17 reportsTHE CENTER OF THE DASHBOARD NEAR THE WINDSHIELD VENTS HAS PEELED AWAY OVER THE LAST YEAR OR SO FROM THE DASH FRAME. RIGHT NOW IT IS STANDING AROUND 3" FROM THE FRAME AND I AM AFRAID THAT IT WILL CONTINUE TO TRANSGRESS INTO MY LINE OF SIGHT. I HAVE ALSO NOTICED THAT THE DEFROST/DEFOGGER ON THE CAR DOES NOT WORK WELL ANYMORE SI…
Read full complaint
THE CENTER OF THE DASHBOARD NEAR THE WINDSHIELD VENTS HAS PEELED AWAY OVER THE LAST YEAR OR SO FROM THE DASH FRAME. RIGHT NOW IT IS STANDING AROUND 3" FROM THE FRAME AND I AM AFRAID THAT IT WILL CONTINUE TO TRANSGRESS INTO MY LINE OF SIGHT. I HAVE ALSO NOTICED THAT THE DEFROST/DEFOGGER ON THE CAR DOES NOT WORK WELL ANYMORE SINCE THE PEELING HAS OCCURRED. THE DASH IS ALSO LIFTING AWAY FROM THE FRAME JUST ABOVE AND TO THE RIGHT OF THE INSTRUMENT PANEL. MY CAR IS EQUIPPED WITH DUAL FRONT AIR BAGS AND I BELIEVE THAT THIS WARPING OF THE DASH MAY IN SOME WAY EITHER CAUSE A PREMATURE RELEASE OF THE PASSENGER AIR BAG OR PREVENT THE RELEASE OF THE BAG WHEN IT MAY BE NEEDED. I HAVE NOTED THIS SAME PHENOMENON ON OTHER KIA SEPHIAS IN THE CITY WHERE I LIVE.
DASHBOARD WAS WARPING. DASHBOARD BEGAN DISCOLORING A YEAR 1/2 AGO, AND CURRENTLY WAS FALLING APART. DEALER ADVISED THAT IT WAS SIMPLY WEAR AND TEAR. CONSUMER FEELS THAT PASSENGER'S SIDE AIRBAG MAY DEPLOY. *AK *SLC
THE DASHBOARD ON MY KIA IS FOLDING AND BUCKLING PREVENTING THE DEFROST SYSTEM TO BLOW CORRECTLY. THUS, MAKE IT A HAZARDOUS CONDITION WHEN IT IS RAINING AND THE WINDSHIELD FOGS UP. THE BLOWER CANNOT REACH THE WINDSHIELD DUE TO THE BUCKLING OF THE DASH.
I'VE HAD TO REPLACE BOTH FRONT SEAT BELT RECEPTICLES DUE TO FAILURE OF LATCH. THE ENGINE CHECK LIGHT STAYS ON CONSTANT EVEN AFTER IT IS RESET. I WOULD LIKE TO KNOW WHY. *AK
VEHICLE WOULD NOT START AT CERTAIN TIMES, THEN THE TRANSMISSION WENT OUT WHILE DRIVING. DEALER REPLACED TRANSMISSION, AND NOW ENGINE CHECK LIGHT IS BACK ON. *AK
THE FIRST MONTH I HAD CAR THE IGNITION/STEERING LOCKED AND NEEDED TOWING BY KIA-NOTHING CHARGED TO ME. THE CHECK ENGINE LIGHT HAS BEEN COMING ON AND STAYING ON SHORTLY AFTER 'REPAIR' EVER SINCE I BOUGHT CAR 3-28-1998. I JUST GOT "RUN-AROUND' FROM WESTERN DIVERSIFIED/KIA AND INDEPENDENT REPAIR SHOP OVER AXLES. KIA TOLD ME NOTH…
Read full complaint
THE FIRST MONTH I HAD CAR THE IGNITION/STEERING LOCKED AND NEEDED TOWING BY KIA-NOTHING CHARGED TO ME. THE CHECK ENGINE LIGHT HAS BEEN COMING ON AND STAYING ON SHORTLY AFTER 'REPAIR' EVER SINCE I BOUGHT CAR 3-28-1998. I JUST GOT "RUN-AROUND' FROM WESTERN DIVERSIFIED/KIA AND INDEPENDENT REPAIR SHOP OVER AXLES. KIA TOLD ME NOTHING COVERED AFTER 36,000 MI.. AFTER I THOUGHT I COULD SEND IN BILL FOR AXLES TO EXTENDED WARRANTY INSTEAD OF CALLING AT THE TIME (MALE CHAUVINIST MECHANIC) AND AFTER WESTERN DIVERSIFIED SEEMINLY INDICATED AXLES PART OF ROUTINE MAINTENANCE (CV BOOT-DIDN'T KNOW WERE GOING BAD) AND I COULDN'T AFFORD $200-300 FOR DEALER TO CHECK CAR EARLIER-- DEALERS AND KIA THEN SAY I HAVE 5/60 WARRANTY ON ENGINE/TRANS AND NOW WON'T COVER AXLES BECAUSE OF INDEPENDENT MECHANIC TOUCHING CAR AND HE WON'T BACK UP HIS 'WARRANTY'. I JUST STARTED FULL-TIME WORK NOT AS A TEMP (BUT TERM) WITH CO I WORKED 5 1/2 YRS BEFORE. ALL MY MONEY IS GOING ALTERNATELY TO CAR REPAIRS THEN CATCH UP ON CAR PMTS AND INS AND I STILL NEED TO MOVE AND CAN'T AFFORD TO AND REALLY STEAMED AND WRITING TO ATTY GENERAL ABOUT KIA--Y2K MEANS YUCK TO KIA. *AK
REPETEDLY REPAIRED FOR SAME PROBLEMS AND STILL SAME THINGS NOT NEEDING TO BE REPLACD HAD TO BE CAR IS A LEMON
CHECK ENGINE LIGHT ILLUMINATES, INDICATING A MALFUNCTION WITHIN THE SYSTEM, CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
WAS DRIVING VEHICLE WHEN THE ENGINE CHECK LIGHT CAME ON. HAD TAKEN VEHICLE TO DEALER AT LEAST A DOZEN TIMES. EACH TIME TOLD PROBLEM FIXED, BUT IT REAPPEARS. *AK
Official recalls
102V216000 · Seat Belts:front:buckle Assembly
Aug 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.