Illustration"CHECK ENGINE" LIGHT HAS BEEN ON SINCE I BAUGHT THE CAR. I HAVE TRIED SEVERAL TIMES TO HAVE IT FIXED BUT THE LIGHT STILL COMES ON. MY CAR WILL NOT PASS CALIFORNIA SMOG WITH THE LIGHT ON WHICH MEANS THAT I CANNOT RENEW MY REGISTRATION THE NEXT TIME THE DMV REQUIRES A SMOG CHECK.
1996 Kia Sephia
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Kia Sephia do not stand out strongly from the model-year median of 107.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sephia years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 118 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 17 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports4 fire reports8 injury reports
Electrical System complaints
19 reportsCONSUMER WAS DRIVING THE VEHICLE WHEN THE WHOLE DASH BOARD CAME OFF. DEALER WAS NOT CONTACTED AT THE TIME OF THIS. TS
THE FIRST WIRING HARNESS THAT WAS ORDERED FOR THIS CAR ON 10/29/02 WAS DEFECTIVE. THEY ORDERED A SECOND ONE. I WENT TO PICK UP MY CAR THEY SAY WAS READY AND EVERYTHING IS WORKING. BEFORE I DROVE OFF THE LOT I NOTICED MY DOOR AJAR LIGHT ON. HOWEVER ALL OF THE DOORS WERE CLOSED INCLUDING THE TRUNK. SO TOMORROW I AM TAKING MORE T…
Read full complaint
THE FIRST WIRING HARNESS THAT WAS ORDERED FOR THIS CAR ON 10/29/02 WAS DEFECTIVE. THEY ORDERED A SECOND ONE. I WENT TO PICK UP MY CAR THEY SAY WAS READY AND EVERYTHING IS WORKING. BEFORE I DROVE OFF THE LOT I NOTICED MY DOOR AJAR LIGHT ON. HOWEVER ALL OF THE DOORS WERE CLOSED INCLUDING THE TRUNK. SO TOMORROW I AM TAKING MORE TIME OFF FROM WORK SO THEY CAN INSTALL A THIRD WIRING HARNESS. I HAVE TAKEN OFF 2 DAYS 3 HOURS SO FAR. THE NEAREST DEALERSHIP IS ABOUT 45 MILES AWAY. I ONLY HAVE THAT ONE CAR. THE CAR WAS TOWED OVER THERE THE LAST TIME BECAUSE THE GEAR SHIFT WOULD NOT MOVE. WITH ALL THE COMPLAINTS THAT I HAVE SEEN TONIGHT ON THIS WEB SITE YOU WOULD THINK THEY WOULD CALL A RECALL. I WILL NOT REST UNTIL SOMEONE TAKES RESPONSIBLITY FOR THE CAR THAT HAS BEEN IN AND OUT THE SHOP EVERY SINCE I HAD IT. DT
THIS IS THE THIRD WIRING HARNESS THEY ARE ORDERING. DT
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
THE TOP OF THE DASH ACTUALLY HAS A LARGE BURN SCORCH MARK ABOUT THE SIZE OF A GRAPEFRUIT AND THE FOAM LIKE MATERIAL IS BULGING OUT, THIS IS IN THE MIDDLE OF FLORIDA'S SUMMER HEAT AND VEHICLE HAS BEEN PARKED OUTSIDE OF MY WORK BUT A CAR ONLY 3 YEARS OLD SHOULD NOT HAVE THIS TYPE OF DAMAGE, OVER YEARS HAVE OWNED OLD CARS OVER TEN …
Read full complaint
THE TOP OF THE DASH ACTUALLY HAS A LARGE BURN SCORCH MARK ABOUT THE SIZE OF A GRAPEFRUIT AND THE FOAM LIKE MATERIAL IS BULGING OUT, THIS IS IN THE MIDDLE OF FLORIDA'S SUMMER HEAT AND VEHICLE HAS BEEN PARKED OUTSIDE OF MY WORK BUT A CAR ONLY 3 YEARS OLD SHOULD NOT HAVE THIS TYPE OF DAMAGE, OVER YEARS HAVE OWNED OLD CARS OVER TEN YEARS OLD BEFORE EVER SAW DASH PROBLEMS AND NOTHING LIKE THIS, DONT KNOW IF THIS COULD HAVE SOMEHOW IGNITED A FIRE OR IF DASH IS NOW LOOSE COMPROMISING OTHER EQUIPMENT IN THE DASH. I WOULD ALSO LIKE TO KNOW OF ANY OTHER PROBLEMS OR RECALLS WITH THIS MODEL. THANK YOU FOR YOUR ASSISTANCE.
WHILE DRIVING VEHICLE CAUGHT FIRE UNDER THE HOOD DUE TO WIRING HARNESSES FAILURE. YH
WAS DRIVING VEHICLE & NOTICED SMOKE COMING THROUGH THE VENTS. PULLED OVER & SMOKE FILLED THE INTERIOR. VEHICLE TOWED TO DEALERSHIP. MECHANIC CHECKED UNDER HOOD & NOTICED THE ELECTRICAL WIRES WERE FRAYED. COULD NOT LOCATE CAUSE OF THE FRAYED WIRES. *AK
DUE TO WIRING PROBLEMS VEHICLE HAD STALLED, A FIRE STARTED UNDERNEATH THE HOOD. *AK *ML
DASHBOARD GETS HOT AND IS DETERIORATING ABOVE INSTRUMENT PANEL
Official recalls
102V216000 · Seat Belts:front:buckle Assembly
Aug 16, 2002
ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE02051 · Safety Belt Buckle Malfunction
Opened Jun 17, 2002 · Closed Sep 20, 2002
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
BY LETTER DATED AUGUST 25, 2002, KIA ADVISED NHTSA THAT THE SUBJECT VEHICLES WILL BE RECALLED.SPECIFIC CORRECTIVE ACTION TO BE TAKEN BY KIA HAS NOT BEEN REPORTED TO NHTSA AT THIS TIME.THE SAFETY RECALL PROGRAM HAS BEEN ASSIGNED CAMPAIGN NO. 02V-216.