2020 Kia Optima

The contact owns a 2020 Kia Optima. The contact stated that while the vehicle was at a full stop, the red oil warning light illuminated; however, after driving off, the warning light disappeared. The vehicle was driven to an independent mechanic where it was diagnosed with an oil pump failure caused by low oil pressure while the vehicle was stationary, and the RPM was low. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 167,000.

The contact owns a 2020 Kia Optima. The contact stated that the vehicle was sputtering and vibrating abnormally while starting. There were no warning lights illuminated. The failure was intermittent but became a recurring failure. The vehicle was towed to an independent mechanic out of fear of the vehicle stalling on the highway. Prior to the engine failure, the contact became aware that there were oil spots where the vehicle was parked. The vehicle was diagnosed, and the mechanic sealed two holes in the oil pan and replaced the spark plugs that were fouled by engine oil. The vehicle was repaired; however, the failure reoccurred. The contact stated that the check engine warning light was illuminated. The vehicle was taken back to the same mechanic who diagnosed the vehicle and determined that the spark plugs were covered in oil again. The contact was advised to take the vehicle to a dealer to check for engine failure. The vehicle was taken to the dealer, and an oil consumption test was performed; however, the vehicle failed the oil consumption test. The dealer had not yet diagnosed the vehicle, but suggested that the engine needed to be disassembled to check for engine wear. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 91,185.

I took my vehicle to the dealership in Chantilly, VA on May 17, 2025. On July 24, 2025, I discovered that my vehicle had no oil, despite being approximately 4,000 miles away from my next scheduled oil change. I have video documentation confirming that there was no oil in the vehicle. The car was towed back to the dealership; however, no corrective action was taken. The dealership offered to perform a test, which I declined, as this issue did not exist before servicing my vehicle at their location. Additionally, no explanation or guidance regarding the oil was provided to me. I was only advised to pay for another oil change, or a 205 dollars to diagnose the car. Subsequently, I took the vehicle to Fairfax Auto Shop, where a dye test was conducted to check for oil leaks. While no leaks were found, they advised that the vehicle has an oil consumption issue. They recommended that I monitor and top off the oil every 1,000 miles and return for oil changes every 2–3 months.

While driving, the vehicle experienced a sudden loss of engine power and entered limp mode. The check engine light began flashing and the vehicle had very limited acceleration, creating a safety concern when driving in traffic. The vehicle was towed to a Kia dealership for diagnosis. The dealer retrieved diagnostic trouble code P1326 (Knock Sensor Detection System – range/performance). During inspection, the dealer found metal contamination in the engine oil and oil control valves and advised that the engine has internal damage and requires replacement.

I purchased in July 2020, from sept 2020 I've had it at the dealership with shuddering, stalling and loss of acceleration. I originally thought fuel pump or transmission but kia said no. then in 2022 I received a letter from kia corporate stating low pressure fuel pump failure. so i called the dealership and told them the letter states everything I had been in to see them about numerous times. made an appointment they said they found an error but had no fix. I complained heavily due to the fact I sat there for 4 hours, and they knew they had no fix as of yet. It was too dangerous like this. so the Manager said he'd just replace it with a whole new fuel pump but it could also fail. I sent the car in for 4 days just to find out they did not replace it. they only changed the fuel filter. stating kia wont let them put in a new pump due to their system not showing any other issue. The problem persisted and multiple visits to kia to no avail. Then on top of that my air bag light came on Jan 4, 2024. They said it was my responsibility it's not covered 1138.67 it would cost me. Then in Feb kia corporate sent me a letter about airbags. I did not go back because the light eventually went off by itself without a fix, then April 17, 2024 the original problem got even worse, shuddering, lack of acceleration , stalling feeling. Dec. 10, 2025 back to Kia. they have a code for dual clutch and flywheel so they ordered it & had my car for 19 days. I called numerous times to see about progress. I was told they are trying to chase down a code with a tech line. 7 days after that I picked it up & they said they did not change out any parts because there was no code. They only did a cap discharge. I have my car back now after 19 days & it's still not fixed. I called Jan5, 2026 and they said if kia is to fix it they need a code to be present or it'll cost me several thousand, even if its a known issue. so far it's been in the shop 9 times and 24 days total.

Immediately after getting Kia's latest recall "Voluntary Emissions Service Campaign" software update, my transmission began to Hard-Shift between neutral and 1st gear, and when slowing down, from a gear to a neutral position with the transmission. The car has lunged a few times when going from neutral to 1st gear position--concerning. This is most noticeable when car is cold, but is still always noticeable. Stop-and-go traffic it's also most noticeable. I have notified local dealership by phone message and email but have not heard back in 2 weeks.

Took to Kia for engine burning excessive oil. They determined the cylinder wall was scorched due to piston ring. The warranty people say it’s normal wear and tear and won’t honor the warranty. It’s still sitting in their engine bay because they want me to pay for the diagnostic which I don’t have. $4000 roughly for that but it needs a new engine. The warranty should be covering this! NEVER PAY FOR AN EXTENDED WARRANTY!!! They will not help you