Engine. Review the 283 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 94 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

20 crash reports42 fire reports17 injury reports

Structure complaints

48 reports

Clear category filter

Mileage unknown · Jan 12, 2022

Structure

Paint started peeling on both sides of front windshield and has gotten worse over the years

NHTSA ODI #11447222

Mileage unknown · Oct 6, 2021

Structure

My car has 80,000 miles and the paint chipping on the bumper, hood, and roof is starting to cause rust on the car body.

NHTSA ODI #11435772

Mileage unknown · Sep 2, 2021

Structure

Read full complaint

I noticed a small spot of paint chipping one day. Then I was washing my car and noticed a lot of spots chipping. As I started watching them they kept chipping all over from my hood which is the worst to side of doors sides and roof around front window and front and back bumper. I looked online to research it and if anyone had this problem and it seems to be just the white kia that has this problem. I have contacted kia mutable times. I sent pictures of my car and 3 estimates. All I keep doing is getting the run around about what there going to do. It is now getting worse and starting to rust real bad.

NHTSA ODI #11431456

Mileage unknown · Jul 18, 2021

Structure

I noticed that the pain on the hood had a chip in it. About two months or so later there were a few spots where the paint has bubbled and peeled off. Later I noticed the the paint was doing the same along both sides of the windshield and above both doors. The spots are continuing to bubble and peel.

NHTSA ODI #11425341

129,000 miles · Jun 21, 2021

EngineStructureFire

Read full complaint

The contact owns a 2014 Kia Optima. The contact stated that while driving approximately 35 mph the vehicle shut off and rolled in a parking lot. There were no warning lights illuminated. Additionally, the dashboard and vents melted and the air conditioner became inoperable. The vehicle was taken to an independent mechanic where it was informed there were metal shavings in the engine. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted who referred the contact to a local dealer. The failure mileage was approximately 129,000.

NHTSA ODI #11421621

115,677 miles · Apr 9, 2021

Structure

PAINT HAS BEGUN BUBBLING AND PEELING IN SEVERAL AREAS. BODY SHOPS HAVE SAID IT IS DELAMINATION.

NHTSA ODI #11407249

66,752 miles · Apr 29, 2020

Structure

Read full complaint

THE ANTENNA FIN SCREWS SHEERED OFF AND PLASTIC SCREW HOLDER BROKE INTO PIECES CAUSING THE FIN TO COME LOOSE AND FALL OFF, EXPOSING ELECTRICAL COMPONENTS. THERE WAS NO PRIOR INTERFERENCE WITH THE FIN, I OBSERVED THE FIN SLIGHTLY LIFTED ON THE FRONT END AND IT PULLED RIGHT OFF. THE VEHICLE WAS IN THE PARKED POSITION AFTER JUST DRIVING IT 5 MINUTES. THERE IS NO EASY WAY OF FIXING THIS ISSUE, RAIN DAMAGE MAY OCCUR CAUSING ISSUES WITH RADIO AND OTHER ELECTRICAL COMPONENTS. OTHERS HAVE COMPLAINED OF THE SAME THING HAPPENING TO THEIR KIA OPTIMA ANTENNA FINS.

NHTSA ODI #11322717

80,000 miles · Oct 15, 2019

Structure

Read full complaint

2014 KIA OPTIMA SHARK FIN RADIO ANTENNA COVER BROKE OFF AFTER EXITING THE FREEWAY. ALL FIVE SCREW HOLDERS CRACKED INSIDE THE HOUSING, OBVIOUSLY A FAULTY DESIGN. THE 2016 KIA OPTIMA SHARK FIN RADIO ANTENNA WAS RECALLED FOR THE EXACT SAME PROBLEM. MY VEHICLE IS STORED IN A GARAGE EACH NIGHT AND HAS NEVER SUSTAINED ANY DAMAGED TO THE ROOF AREA. THIS IS A VERY UNSAFE PROBLEM HAPPENING TO MANY KIA OPTIMAS, GOD FORBID MY ANTENNA FLEW OFF AND HIT ANOTHER VEHICLE BEFORE I EXITED.

NHTSA ODI #11268741

104,000 miles · Sep 18, 2019

StructureUnknown Or Other

NOTICED THE SHARK FIN MISSING. AFTER CLOSER EXAMINATION IT APPEARS THAT IT SNAPPED OFF TO REPLACE THE HEADLINER MUST BE REMOVED I ORDER A NEW ONE AND I AM UNABLE TO REPLACE IT. TAKING TO DEALERSHIP AND HOPEFULLY THE WILL IT WHEN CHECKING ON MY STEERING ISSUE.

NHTSA ODI #11256314

123,000 miles · Jun 3, 2019

Structure

SHARK FIN ANTENNA SNAPS OFF, ONLY 4TINY SCREWS HOLD IT ON

NHTSA ODI #11217436

Official recalls

23V652000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Sep 25, 2023

Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.

Consequence & remedy

Consequence: An engine compartment fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

22V093000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Feb 17, 2022

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles that were previously repaired under NHTSA recall number 20V-100. The low pressure fuel hose may be damaged, or missing heat-protective tape, which can result in a fuel leak.

Consequence & remedy

Consequence: A fuel leak can increase the risk of a fire.

Remedy: Dealers will replace the low pressure fuel hose, free of charge. Owner notification letters were mailed August 2, 2022. Owners may contact Kia customer service at 1-800-33-4542. Kia's number for this recall is SC228.

21V331000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

May 10, 2021

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles previously recalled under recall 20V-519. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: An electrical short in the HECU increases the risk of a fire while parked or driving.

Remedy: Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. Dealers will install a new multi-fuse, and inspect the HECU for leaks, replacing the HECU if necessary, free of charge. Owner notification letters were mailed on July 2, 2021. This recall supersedes previous NHTSA recall number 20V-519. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC212.

20V519000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Aug 27, 2020

Kia Motors America (Kia) is recalling certain 2013-2015 Optima and 2014-2015 Sorento vehicles. Brake fluid may leak inside the Hydraulic Electronic Control Unit (HECU), possibly resulting in an electrical short.

Consequence & remedy

Consequence: If the HECU short circuits, there is an increased risk of an engine compartment fire.

Remedy: Kia will notify owners, and dealers will inspect the HECU for leaking brake fluid and replace the HECU if necessary, free of charge. Owners are advised to park outside and away from other vehicles and structures until the recall repair is completed. The recall began October 20, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC197.

20V100000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Feb 21, 2020

Kia Motors America (Kia) is recalling certain 2013-2014 Optima vehicles equipped with 2.4L Gasoline Direct Injection (GDI) or 2.0L GDI Turbo engines. The low pressure fuel hose may deteriorate and crack over time due to heat generated within the engine compartment.

Consequence & remedy

Consequence: If the fuel hose cracks, a fuel leak can occur, increasing the risk of a fire.

Remedy: Kia will notify Owners, and Dealers will inspect the low pressure fuel hose for damage or leaking, replacing it as necessary. If no damage or leaking is found, a heat-protective tape will be installed. Repairs will be performed free of charge. The recall began June 12, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC187.

18V907000 · Engine; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 19, 2018

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Additional source detail variants (2)

Engine

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

17V224000 · Engine And Engine Cooling:engine

Mar 31, 2017

Kia Motor Company (Kia) is recalling certain 2011-2014 Optima, 2012-2014 Sorento and 2011-2013 Sportage vehicles. Machining errors during the engine manufacturing process may cause premature bearing wear within the engine.

Consequence & remedy

Consequence: Bearing wear may result in the engine seizing, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect the engine assembly, and replace the engine if necessary, free of charge. The recall began June 20, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC147.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

DP22003 · Loss Of Motive Power

Opened Sep 12, 2022 · Closed Dec 12, 2023

Status: closed (inferred from source dates) · Engine

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP21003 · Throttle Control System Vulnerabilities

Opened Nov 12, 2021 · Closed Jun 20, 2023

Status: closed (inferred from source dates) · Vehicle Speed Control:throttle

The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.

EA19001 · Electrical Overstress

Opened Apr 19, 2019 · Closed Sep 19, 2024

Status: closed (inferred from source dates) · Air Bags: Air Bag/restraint Control Module

The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect. During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW. The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications. The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU. In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment. FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle. Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW. These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes. An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time. In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU. This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners. Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW. The risk associated with the ASIC is equally shared among all OEMS involved in the investigation. The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage. There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation. The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU. If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC. Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC. All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled. In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024. With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.

PE19004 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines (approximately 1.7 million vehicles). ODI also reviewed field and other data on other Kia vehicles (approximately 3.6 million additional vehicles) equipped with the same engines used in the above-mentioned vehicles.As a result of this PE, Kia has issued NHTSA Recalls 20V-750 and 21V-844 to address potential engine failures and fires in certain Kia vehicles equipped with various engine types.Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov.In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure-related recalls mentioned above and conducted previously.See the EA21-003 Opening Resume available at NHTSA.gov for more information.Also available in the downloadable version of this resume is a list of the reference numbers for the 444 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021.Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (392)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal:switch

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other

RQ17003 · Scope And Timeliness

Opened May 18, 2017 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Engine

NHTSA opened Recall Query (RQ) 17-003 to investigate the timeliness and scope of Kia?s Theta II GDI engine recall (Recall No. 17V-224), and Kia?s compliance with reporting requirements. On November 23, 2020, the Agency entered into a Consent Order with Kia to administratively resolve NHTSA?s assertions of violations of law in connection with RQ17-003. NHTSA?s assertions included that Kia may be liable for civil penalties on multiple grounds, including that Recall No. 17V-224 was untimely and Kia?s recall report contained certain inaccuracies.Under the Consent Order, Kia agreed to a total civil penalty of $70,000,000. The total civil penalty included a payment of $27,000,000 as a Non-Deferred Amount.Kia also agreed to a sum of $27,000,000 as an Abeyance Amount to be deferred and held in abeyance pending its satisfactory completion, as reasonably determined by NHTSA, of the requirements of the Consent Order.Kia also agreed to a $16,000,000 Performance Obligation Amount to be expended by Kia to fulfill specified Safety Data Analytics Infrastructure obligations. The Consent Order also includes other terms designed to enhance Kia?s safety practices, and requires Kia to retain a Third-Party Auditor who directly reports to NHTSA.Other than RQ17-003, the Consent Order is not intended to affect any other current or future investigation of NHTSA which may involve vehicles equipped with Theta II GDI engines. In particular, Engineering Analysis (EA) 21-003 (which is upgraded from Preliminary Evaluation (PE) 19-004) continues NHTSA?s evaluation of certain performance and design issues relating to the Theta II and other engines.Nothing in the Consent Order discharges Kia from any obligation to comply with the Safety Act or regulations thereunder, including the obligation to carry out recalls in accordance with the law, and to initiate a recall upon any future determination by Kia, or upon any finally adjudicated order from NHTSA, that vehicles equipped with Theta II GDI engines contain a defect related to motor vehicle safety or do not comply with an applicable FMVSS.This RQ is closed. Closure of this RQ has no bearing on the terms of the Consent Order, including Kia's ongoing performance obligations, and does not represent a determination by the agency as to Kia's performance under the Consent Order to date.

Additional source detail variants (2)

Engine