My vehicle speed up and slow down all that itself. It will not maintain speed even with my foot steady on the gas. It will not accelerate, but the major problem is my seatbelt gets stuck all the time I’m afraid to get buckled. I am unable to remove my seatbelt multiple times so now I have buckled my seatbelt behind me so I can s…
Read full complaint
My vehicle speed up and slow down all that itself. It will not maintain speed even with my foot steady on the gas. It will not accelerate, but the major problem is my seatbelt gets stuck all the time I’m afraid to get buckled. I am unable to remove my seatbelt multiple times so now I have buckled my seatbelt behind me so I can start getting tickets. I’ve gotten like four tickets because I’m scared to be buckled that it’s not gonna come on down when I need it to be I’ve got 40 bought tickets. I was going about 20 mph when I went to the brakes for my vehicle accelerated by itself crashing into a pillar at the mall. I did call the police.
NHTSA ODI #11549529
Mileage unknown · Sep 5, 2014
EquipmentPower TrainVehicle Speed ControlCrash
I WAS IN A CRASH AND I HAVE TO SAY THAT THIS IS A PROBLEM. AFTER I RECEIVED MY CAR BACK FROM THE BODY SHOP THE CAR HAS BEEN MALFUNCTIONING ! THE 2.7L HAS STUMBLE ON AND AT ACCELERATION THE FAILURE IS THE THROTTLE POSITION SWITCH THIS IS A SAFETY PROBLEM FOR ALL DRIVER'S THAT DRIVE A 2007 KIA OPTIMA. THE MALFUNCTION OCCURS FIVE T…
Read full complaint
I WAS IN A CRASH AND I HAVE TO SAY THAT THIS IS A PROBLEM. AFTER I RECEIVED MY CAR BACK FROM THE BODY SHOP THE CAR HAS BEEN MALFUNCTIONING ! THE 2.7L HAS STUMBLE ON AND AT ACCELERATION THE FAILURE IS THE THROTTLE POSITION SWITCH THIS IS A SAFETY PROBLEM FOR ALL DRIVER'S THAT DRIVE A 2007 KIA OPTIMA. THE MALFUNCTION OCCURS FIVE TIME'S IN ONE DAY. THIS PROBLEM MAY CAUSE SEVERE OR FATAL INJURIES TO THE OCCUPANTS IN THE VEHICLE. NOTHING WAS DONE TO CORRECT THE FAILURE AND THE OLD THROTTLE POSITION SWITCH IS AVAILABLE! I REALLY THANK THAT THIS IS FOUND TO HAVE A DEFECT THAT AFFECTS SAFETY AND THE AUTOMAKERS NEED VOLUNTARILY ANNOUNCE A RECALLS ON ALL THE 2007 KIA OPTIMA THAT HAVE THE SAME THROTTLE POSITION SWITCH AS THIS VEHICLE. *TR
NHTSA ODI #10631170
40,000 miles · May 1, 2014
Electrical SystemVehicle Speed Control
HAD ONGOING ISSUES IN WHICH THE CAR GOT "STUCK" AND WOULD NOT ACCELERATE PAST 25 MPH, EVEN IF I "FLOORED" IT. I HAD TO TAKE MY FOOT COMPLETELY OFF THE GAS PEDAL, WAIT A FEW SECONDS (BY THEN THE CAR WOULD BE DOWN TO 10-15 MPH), THEN TRY TO ACCELERATE AGAIN, WHICH SOMETIMES TOOK SEVERAL TRIES. I WAS VERY WORRIED ABOUT GETTING INTO…
Read full complaint
HAD ONGOING ISSUES IN WHICH THE CAR GOT "STUCK" AND WOULD NOT ACCELERATE PAST 25 MPH, EVEN IF I "FLOORED" IT. I HAD TO TAKE MY FOOT COMPLETELY OFF THE GAS PEDAL, WAIT A FEW SECONDS (BY THEN THE CAR WOULD BE DOWN TO 10-15 MPH), THEN TRY TO ACCELERATE AGAIN, WHICH SOMETIMES TOOK SEVERAL TRIES. I WAS VERY WORRIED ABOUT GETTING INTO AN ACCIDENT WHEN THIS HAPPENED BECAUSE THERE WAS NO WARNING AND IF YOU SUDDENLY STOP MOVING AT THE SPEED OF TRAFFIC WITH NO INDICATION YOU ARE SLOWING DOWN, YOU COULD EASILY BE HIT. IN ONE CASE, I WAS TRYING TO PASS A SLOW-MOVING VEHICLE GOING 25 IN A 40. I ATTEMPTED TO GO AROUND THE VEHICLE, WHICH SHOULD HAVE BEEN A PRETTY LOW-SPEED PASS, AS I ONLY NEEDED TO GET UP TO ABOUT 35 MPH, BUT THE CAR STOPPED ACCELERATING AT 25 AND I COULD NOT GET PAST. I HAD TO TAKE MY FOOT OFF THE GAS, WAIT, TRY AGAIN, AND REPEAT THIS A COUPLE TIMES BEFORE THE CAR WOULD ACCELERATE AGAIN. THIS BECAME A VERY SCARY SITUATION BECAUSE BY THAT TIME, THERE WAS ONCOMING TRAFFIC APPROACHING AND I WAS LITERALLY STUCK IN THE PASSING LANE. I ALSO HAD THE CAR JUST COMPLETELY LOSE POWER AND SHUT OFF WHILE I WAS AT A RED LIGHT AT A BUSY URBAN INTERSECTION. TOOK IT TO A REPAIR SHOP. THEY DIAGNOSED IT AS A THROTTLE POSITION SWITCH PROBLEM, AND IT COST ALMOST $800 TO GET IT FIXED. AT FIRST I THOUGHT I JUST HAD BAD LUCK, BUT I LATER FOUND THIS MESSAGE BOARD IN WHICH PEOPLE WITH THIS SAME MODEL DESCRIBE THE EXACT SAME PROBLEMS. HTTP://REPAIRPAL.COM/FAULTY-THROTTLE-POSITION-SWITCH-355 ACCORDING TO THIS, KIA RELEASED A PART TO FIX THE SITUATION. IT SEEMS THAT LOSING ALL POWER/THE INABILITY TO ACCELERATE IN TRAFFIC POSES A VERY SERIOUS SAFETY CONCERN. IT BOTHERS ME THAT KIA APPARENTLY KNOWS ABOUT IT AND WOULD JUST ISSUE A NEW PART THAT COSTS OWNERS SEVERAL HUNDRED DOLLARS TO REPAIR (COST PROHIBITIVE TO MANY PEOPLE), RATHER THAN ISSUING A RECALL, OR AT LEAST NOTIFYING OWNERS OF THE ISSUE. *TR
NHTSA ODI #10585835
50,000 miles · Sep 7, 2011
Vehicle Speed Control
I HAVE HAD INTERMITTENT ISSUES WITH ACCELERATION WHILE DRIVING MY 2007 KIA OPTIMA. WHEN ACCELERATING WITH THE PEDAL DEPRESSED MODERATELY THE CAR WILL BEGIN TO ACCELERATE AND THEN WILL ALL OF A SUDDEN LOOSE ALL POWER. ESSENTIALLY IT SEEMS AS THOUGH THE PEDAL WERE COMPLETELY RELEASED. WHEN THIS HAPPENS HOWEVER, I WILL TRY AND GIVE…
Read full complaint
I HAVE HAD INTERMITTENT ISSUES WITH ACCELERATION WHILE DRIVING MY 2007 KIA OPTIMA. WHEN ACCELERATING WITH THE PEDAL DEPRESSED MODERATELY THE CAR WILL BEGIN TO ACCELERATE AND THEN WILL ALL OF A SUDDEN LOOSE ALL POWER. ESSENTIALLY IT SEEMS AS THOUGH THE PEDAL WERE COMPLETELY RELEASED. WHEN THIS HAPPENS HOWEVER, I WILL TRY AND GIVE IT MORE GAS TO COMPENSATE AND TRIED TO RELEASE THE PEDAL AND REAPPLY PRESSURE TO NO AVAIL. IT WILL USUALLY TAKE FIVE SECONDS OR SO UNTIL I REGAIN ANY SORT OF ACCELERATION. DURING ONE OCCURRENCE I HAVE TO GUIDE THE CAR TO THE SIDE OF THE ROAD AND STOP FOR BEFORE IT WOULD RESPOND AGAIN. THIS PROBLEM SEEMS TO HAPPEN WITHIN A FEW MINUTES OF STARTING THE CAR IN THE MORNING AND HAS OCCURRED ABOUT TEN TIMES IN THE LAST YEAR. THIS IS A DANGEROUS PROBLEM BECAUSE IT HAS HAPPENED A FEW TIMES WHILE CROSSING A BUSY INTERSECTION WITHOUT A TRAFFIC LIGHT. I HAVE ALMOST BEEN HIT TWICE. THE CAR WILL BEGIN TO ACCELERATE AND THEN WILL JUST COAST, WHICH IS PARTICULARLY PROBLEMATIC WITH ONCOMING TRAFFIC. *TR
NHTSA ODI #10424139
Mileage unknown · Sep 9, 2010
Air BagsVehicle Speed Control
MY 2007 KIA OPTIMA SEEMS TO BE HAVING ISSUES WITH THE DRIVER SIDE AIRBAG AND RANDOMLY WITH THE RADIO/CRUISE CONTROL SETTING ON THE STEERING WHEEL. MY PROBLEMS DID NOT APPEAR TO START UNTIL AFTER THE STEERING COLUMN WAS REPLACED BACK IN OCTOBER OF 2009 DUE TO THE NOISES THAT WAS COMING FROM IT. THE AIR BAG LIGHT HAS RECENTLY COME…
Read full complaint
MY 2007 KIA OPTIMA SEEMS TO BE HAVING ISSUES WITH THE DRIVER SIDE AIRBAG AND RANDOMLY WITH THE RADIO/CRUISE CONTROL SETTING ON THE STEERING WHEEL. MY PROBLEMS DID NOT APPEAR TO START UNTIL AFTER THE STEERING COLUMN WAS REPLACED BACK IN OCTOBER OF 2009 DUE TO THE NOISES THAT WAS COMING FROM IT. THE AIR BAG LIGHT HAS RECENTLY COME ON AND STAYS ON. ONE DEALER SAID THAT THE CODE THAT THEY WERE GETTING IS THAT CLOCK SPRING IN THE STEERING COLUMN NEED TO BE REPLACED AGAIN AND WOULD NOT BE COVERED. ANOTHER DEALER STATES THAT THEY ARE NOT GETTING ANY CODES AND THE AIR BAG WOULD NEED TO BE REPLACED AT $1200.00. THE NOISE FROM THE STEERING COLUMN CAN STILL BE HEARD AND I WAS TOLD THAT IT IS THE BEARING IN THE STEERING COLUMN AND THERE IS NOTHING THAT THEY CAN DO ABOUT THAT. THE ISSUES WITH THE CONTROLS ON THE STEERING WHEEL IS RANDOM AND THE DEALER STATES THAT IT NEVER DUPLICATES FOR THEM. NOW THAT THE WARRANTY PERIOD IS OVER I WOULD HAVE TO PAY OUT OF POCKET EVEN THOUGH SOME OF THE ISSUES STARTED BEFORE THE WARRANTY WAS OUT AND IT WAS SUPPOSED TO BE NOTED IN THEIR SYSTEM. KIA HEADQUARTERS OPEN UP A CASE WITH NO RESOLUTION OTHER THAN NO OF THE DEALERS CALLED THEIR HELPDESK FOR HELP OR MADE ANY CLAIMS OF MY ISSUES. THEY SUGGESTED THEY I TAKE THE CAR BACK AND HAVE THE DEALER CALL THEM AND REFERENCE THE CASE NUMBER. I HAVE CHECK TO SEE IF THERE HAS BEEN IN RECALLS ON MY PARTICULAR VEHICLE AND IT APPEARS TO HAVE NOT BEEN ANY. ALTHOUGH THERE HAVE BEEN OTHER KIA OWNERS TO POST THIS SAME ISSUES ON THE INTERNET AND BASICALLY HAVE THE SAME RESULTS THERE ARE STILL NO RECALLS. JUST THE DEALERS TRY THIS AND THAT. THE OWNERS PAYING FOR WHAT SUPPOSED TO BE THE RESOLUTION TO THE PROBLEM AND IT REALLY IS NOT. THE PROBLEM MAY GO AWAY FOR A WHILE AND THEN SHORTLY RETURN. IT IS MORE LIKE GETTING THE RUN AROUND WITH WASTED TIME AND MONEY. *TR
KIA MOTORS AMERICA, INC. (KIA) IS RECALLING CERTAIN MODEL YEAR 2006-2008 KIA OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JANUARY 29, 2008, AND MODEL YEAR 2007 AND 2008 KIA RONDO VEHICLES MANUFACTURED FROM SEPTEMBER 13, 2006, THROUGH MARCH 21, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S SIDE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. IF THE CLOCK SPRING CONTACT ASSEMBLY BECOMES DAMAGED, THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
Consequence & remedy
Consequence: IF THE CLOCK SPRING DEVELOPS HIGH RESISTANCE, IN THE EVENT OF A CRASH, THE DRIVERS AIR BAG WILL NOT DEPLOY AND WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.
Remedy: KIA WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE VEHICLE'S AIR BAG CLOCK SPRING CONTACT ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 11, 2012. OWNERS MAY CONTACT KIA CUSTOMER ASSISTANCE CENTER AT 1-800-333-4542.
KIA IS RECALLING CERTAIN MODEL YEAR 2006-2008 OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JUNE 13, 2007. THERE IS A POSSIBILITY THAT THE SHIFT CABLE MAY HAVE BEEN INSTALLED INCORRECTLY, CAUSING TENSION IN THE CABLE. IF PRESENT, THIS CONDITION COULD CAUSE THE CABLE TO DETACH FROM THE SHIFTER ASSEMBLY'S DOWEL PIN PREVENTING THE TRANSMISSION FROM BEING SHIFTED. THE SHIFT LEVER CAN THEN BE MOVED INTO THE PARK (P) POSITION WHILE THE VEHICLE'S TRANSMISSION IS STILL IN THE LAST USED GEAR BEFORE DETACHMENT.
Consequence & remedy
Consequence: IF THE DRIVER LEAVES THE VEHICLE WITHOUT ENGAGING THE PARKING BRAKE, THERE IS A POSSIBILITY THAT THE VEHICLE CAN ROLL INJURE A PERSON IN ITS PATH OR CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT THE SHIFT CABLE AND REINSTALL IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 23, 2011. OWNER MAY CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21003 · Throttle Control System Vulnerabilities
Opened Nov 12, 2021 · Closed Jun 20, 2023
Status: closed (inferred from source dates) · Vehicle Speed Control:throttle
The Office of Defects Investigation (ODI) of the National Highway Traffic Safety Administration (NHTSA) received a petition letter dated October 10, 2021, requesting an investigation of possible defects in the electronic throttle control (ETC) system on certain Kia vehicles resulting in the opening of DP21-003. Accordingly, Model Year (MY) 2005-2016 Kia Optima/K5, MY 2006-2015 Kia Sorento, MY 2007-2016 Hyundai Elantra, MY 2007-2016 Hyundai Santa Fe, MY 2006-2015 Hyundai Sonatas are all part of the subject population. The petition was originally filed as a Vehicle Owner Questionnaire that can be reviewed at NHTSA.gov under reference (ODI) number 11439675.On November 12, 2021, ODI opened Defect Petition DP21-003 to evaluate the petitioner?s request. ODI performed trend analyses of the VOQs related to vehicle speed control issues for all the subject vehicles and found that none of the 52 Model/Model Year Hyundai/Kia vehicles demonstrated any actionable trend that warranted an investigation.Petitioners submitted 1119 VOQs and non-VOQ cases in which sudden uncommanded acceleration (SUA) or loss of motive power (LOMP) incidents were alleged.For the 1119 reports, 220 were incidents involving crashes, from which 69 subject Hyundai-Kia vehicles were inspected by Hyundai/Kia dealer technicians, Hyundai/Kia engineers, and/or third-party representatives.ODI found the inspections identified no vehicle defects related to the ETC system.Of the 220 crash-involved reports, 13 Event Data Recorder (EDR) records were downloaded successfully and 11 of those indicated driver error: (i.e.) pedal misapplication.A condition where the accelerator pedal is mistakenly applied instead of the brake pedal when the driver wants to stop the vehicle.In addition, ODI reviewed a scientific journal paper published in Forensic Science International in 2016 by Mr. Park et al ., as well as related test videos. ODI does not believe there is any evidence of uncontrollable SUA occurrences in any of the tests reviewed. NHTSA's Office of Vehicle Safety Compliance (OVSC) reviewed the allegations regarding the potential noncompliance with Federal Motor Vehicle Safety Standard No. 124.Based on the information provided, the Agency concludes there is insufficient information for us to determine if a possible non-compliance exists.Finally, both Hyundai and Kia informed ODI that all their vehicles manufactured after 2012 were equipped with an ETC management system, in which the engine speed will go to idle when the system sees signals from both the brake pedal and accelerator pedal at the same time; this is commonly known as the brake-throttle override system.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Hyundai and Kia in response to an Information Request letter, and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that a formal investigation is warranted. After full consideration of appropriate factors, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be published.
PE10046 · Transmission Shift Cable Detachment
Opened Nov 22, 2010 · Closed Apr 5, 2011
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Additional source detail variants (3)
Power Train:automatic Transmission:gear Position Indication (prndl)
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Power Train:automatic Transmission
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
Power Train:automatic Transmission:lever And Linkage:floor Shift
During manufacture the automatic transmission shift cables in certain subject vehicles were installed incorrectly causing extra tension on the cable.This condition can cause the shift cable to detach from the gear shifter assembly's dowel pin preventing the transmission from being shifted.The shift lever can be moved into the Park (P) position while the vehicle transmission is still in the last used gear before detachment.If this were to occur, and if the driver leaves the vehicle without engaging the parking brake, the vehicle may inadvertently roll away thus creating the risk of a crash.Kia is conducting a safety recall (11V-153) to correct the subject problem in approximately 70,115 model year (MY) 2006 through 2008 Kia Optima vehicles produced from 9/29/2005 to 6/13/2007.Kia has stated that the early MY 2006 Optima vehicles built before 9/29/2005 had different automatic transmission shift cables and shift levers than the subsequent MY 2006 through early MY 2008 Optima vehicles built up to 6/13/2007.Beginning 6/14/2007, Kia changed the assembly process for the shift cables to ensure correct installation.As for the recall remedy, Kia dealers will inspect the shift cables for correct installation, and re-install them, if necessary.For more details on the recall, see NHTSA recall 11V-153.This investigation is closed.
2007 Kia Optima Problems, Complaints & Recalls | Skip That Year
Illustration