The contact owns a 2018 Kia Niro. The contact stated while driving approximately 65 MPH, the vehicle started shaking and vibrating abnormally. The contact stated that the accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the message "Engine Overheating - Request Service No…
Read full complaint
The contact owns a 2018 Kia Niro. The contact stated while driving approximately 65 MPH, the vehicle started shaking and vibrating abnormally. The contact stated that the accelerator pedal was depressed; however, the vehicle failed to respond as needed. The contact stated that the message "Engine Overheating - Request Service Now" and "Engine Control System" was displayed. The contact had taken the vehicle to an independent mechanic where it was diagnosed and determined that coolant had intruded into the engine block and the engine needed to be replaced. The vehicle had not been repaired. The contact attempted to contact the manufacturer but was unable to reach a Representative. The failure mileage was approximately 74,000.
Kia America, Inc. (Kia) is recalling certain 2017-2022 Niro and 2018-2022 Niro Plug-in Hybrid vehicles. Fluid may leak into the printed circuit board inside the hydraulic clutch actuator, which can result in an engine compartment fire.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Dealers will inspect and replace the hydraulic clutch actuator as necessary and install a new fuse, free of charge. Owner notification letters were mailed December 29, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC276.
Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles previously recalled under recall 18V-666. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance, which can overheat the rear seats.
Consequence & remedy
Consequence: Overheated rear seats increase the risk of a fire.
Remedy: Dealers will inspect the PRA and replace either the PRA or the Main Relay, as necessary, free of charge. Owner notification letters were mailed January 9, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC256. This recall supersedes NHTSA recall number 18V-666. Vehicles already repaired under the previous recall will need to have the new remedy completed.
Kia Motors America (Kia) is recalling certain 2017-2018 Kia Niro hybrid electric vehicles. The Main Relay within the Power Relay Assembly (PRA) may have inadequate connections between its contacts, causing increased electrical resistance.
Consequence & remedy
Consequence: The increased electrical resistance can overheat the rear seat which is above the PRA, increasing the risk of a fire.
Remedy: Kia will notify owners, and dealers will inspect the Power Relay Assembly (PRA) for damage. If no damage is found, the main relay will be replaced. If damage is found, the PRA will be replaced. These repairs will be performed free of charge. The recall began November 23, 2018. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC168.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2018 Kia Niro Problems, Complaints & Recalls | Skip That Year
Illustration