2022 Kia K5

My 2022 Kia K5 panoramic sunroof spontaneously exploded while the car was parked. There was no impact, no debris, and no warning signs — just a loud explosion and shattered glass everywhere. I previously had a cracked windshield but was unable to afford repairs, as I am unemployed. Now the sunroof has blown out completely, and I believe this could be part of a structural or manufacturing defect. Kia will tow the vehicle to the dealership (Fred Anderson Kia of Raleigh) 06/05 between 8am-10am and I am requesting support under goodwill repair. This was a serious safety hazard and could have injured me, my toddler or others. I’ve since found other reports of Kia sunroofs exploding and believe this needs to be investigated further.

The contact owns a 2022 Kia K5. The contact stated that while attempting to accelerate from a complete stop at the red traffic light, the vehicle failed to respond upon depressing the accelerator pedal. The contact stated that upon shifting to park(P) and restarting the vehicle, the vehicle operated as needed. The vehicle was towed to the local dealer, but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000.

Driving this morning 5/7/2025 at 9:09am and smoke started emitting from the center consol accompanied by a burning smell. My husband noticed the smoke coming from the car charging area, it made a popping/poof sound accompanied with even more smoke. We immediately pulled the charger out of the charger port. My car charger was melted and slightly burned.

While accelerating in response to a green light I made a right hand turn and as I accelerated up to the speed limit of 55 mph I heard and felt a very loud “bang or pop”. I proceeded to pull the car over anticipating a tire blow out or something damaging the rear end of my car and upon a full visual inspection of all tires, undercarriage, under the hood and in the truck and main cabin of the car I was unable to locate and issues and there were zero codes or lights. After careful assessment I proceeded to get myself and child home but on the way the car started stumbling and there was a strong Oder of gas. A check engine Illuminated giving us an error code referencing our solenoid that works in pair with our fuel system. After checking the car and going inside for about two hours, my husband came to me and asked what happened to the backseat as the entire thing had been pulled up and underneath it was a very pressurized and round fuel system. I proceeded to call the car dealership service department and told them the codes and everything I was showing and what was happening and asked when I could get the car to them, and if it was safe to ride, they said if it’s still ran to go smoothly to the dealership which was a 10 minute drive. As directed by the dealership I brought the car for service and I also located a voluntary emissions report that Kia issued in April of 2024 along with a copy of letters said to be sent to each owner of my make and model. I never received these letters and update not completed. Kia failed to effectively notify all owners of this potential issue with an over pressurized fuel system, putting myself and my children in great risk. Kia America stated they needed to study my car. A recall still has not been issued, although there are several complaints of the same thing in their cars and now I’m forced into a very unfair buyback and I am being penalized due to Kia failing to alert All parties. There is still no recall.

The vehicle has experienced repeated transmission-related issues, including erratic shifting, delayed response, slippage, and sudden loss of power while driving. These symptoms significantly impact drivability and pose a safety risk, especially when accelerating or merging in traffic. The issue was previously addressed by the dealership under a recall repair. However, the same transmission behavior has returned approximately 3–4 months after the repair. The dealership performed repairs multiple times before, and the symptoms have now recurred. The problem has been confirmed by the authorized dealership and is scheduled for another inspection. There have been warning symptoms such as hesitation during gear shifts and intermittent power dips while in motion, which began reappearing recently. The component remains available for inspection. Given the repeat nature of the issue following an official recall, I believe this may be part of a broader unresolved defect in the vehicle’s transmission system. The issue initially reappeared briefly after the recall repair, then subsided. However, it returned more consistently and noticeably after a couple of months, and is now ongoing.

UNKNOWN. When the vehicle is turned on and parked with the vent opened letting outside air circulate into the cabin. there is a foul smell like coolant or engine fume that come with the air flow. I did change my air filter multiple times but the suffocating smell does not stop. it gives headaches. there are reddit threads on this issue with Kias. please take a look into it. thank you

I was driving on [XXX] and I heard a really loud sound like a Gun Shot in my Car I couldn't just pull over I had to get off at the next exit when I did I checked myself and then I checked my Windows then I opened my back door on the passenger side and saw that behind the seat had swollen up. I drove to work and call KIA where I purchased the car and told them what happened my husband carried the car to them and to make a long story short. After Months of back & forth it was determined that the GAS TANK had EXPANDED!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This has happened on 2 occasions, 1 while starting the car 1 while driving. Both times the cars volume went to max with either radio or Bluetooth on and produced a static noise with it. The volume knob did not adjust the piercing noise unless set to 0 or mute. This was remedied by pulling the amp fuze and reseting the radio. I had no lights or warnings pop up, and have yet to have this inspected by a dealership. This instant volume switch to max output with static while driving almost caused an accident as I was distracted trying to turn down my radio as quickly as possible with pain in my ears on the interstate. While stationary even after turning down the radio I still have lingering pain from how loud it was. From what I can tell this is something with the radio unit or amp within the car.

Brake Rotors from factory warp very early, noticable in under 30k miles. Warped rotors makes braking harsh, makes the brakes not work as well ans steering wheel jolt when braking making it dangerous. Was diagnosed by myself and other K5 drivers who took their cars to dealerships and mechanics. No warning lamps or anything, just very rough braking. Happened to me around 24,000 miles