2021 Kia K5

Within three days of purchase, the vehicle experienced a fuel system failure requiring the gas tank to be replaced. Shortly afterward, the check-engine light illuminated, indicating additional engine or emissions problems. The failures occurred without warning and made the vehicle unsafe to drive. The engine warning has continued to appear, suggesting a recurring or unresolved malfunction. The defects create risks including fuel leakage, stalling, engine shutdown, and potential fire hazard. The safety of the driver and others on the road is put at risk because the vehicle may fail while in motion. The problem appeared immediately after purchase and continues to recur. The dealer was notified but refused to diagnose or repair the vehicle further. No manufacturer inspection has occurred because the dealership declined to provide service. The warning light first appeared within the first week of ownership and has remained intermittent. The vehicle shows signs of unstable engine operation and ongoing system malfunction. The issue has been observed by the dealer, but they declined to perform proper diagnostics or repair. The defects are persistent and pose ongoing safety concerns.

The contact owns a 2015 Kia K5. The contact received notification of NHTSA Campaign Number: 25V794000 (Fuel System, Gasoline). The contact stated that days before the vehicle was scheduled for an unknown recall repair, while refueling, the contact observed gasoline pouring out of the tank. The vehicle was taken to a dealer, where it was diagnosed, and determined that the fuel tank had expanded due to fumes being trapped inside. The vehicle was not repaired due to parts not being available for the repair. The contact stated that the manufacturer has exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

My 2021 Kia K5 EX has a severe and unsafe steering problem. The vehicle consistently pulls hard to the right on its own, even on straight roads. If I loosen my grip even slightly, the car immediately veers to the right. The steering wheel does not stay centered, and I have to constantly fight the steering just to keep the car in the lane. This issue has continued despite multiple alignments, tire replacements, and inspections. Nothing has fixed the problem, and the steering behavior feels mechanical or electronic in nature. I no longer feel safe driving the vehicle because it feels like I could lose control at any time. Additionally, my vehicle is affected by the open recall (SC356 / NHTSA 25V794) involving fuel tank expansion and fire risk. The status says ‘Incompleted – remedy not available,’ meaning there is currently no repair solution. The combination of a steering defect and a fire-risk recall makes this vehicle unsafe to operate. I am reporting this because the steering issue appears to be a serious safety defect that needs investigation.

For the past 16 months I have been experiencing a fuel odor in my vehicle cabin while idling or when in slow moving traffic. Knowing this likely is due to a fuel leak, I have taken it to the dealership 6 times to find the leak and remedy it. The dealership always finds something to repair/replace under warranty, however, the fuel smell persists. Over the past 16 months, this has increased in how strong the smell is and how often I am smelling it. It started out as only smelling fuel once a week or so. Now the smell is there during ever drive. It seems as though if my tank of 7/8 or above full, it does not smell for some reason. Upon searching online, many other K5 owners are experiencing the same exact issue and the dealership has been unable to resolve this. The vehicle has had 3 seperate recalls for fuel issues and I believe another is necessary regarding this because the recalls has not fixed the fuel leak I and many others are experiencing. Kia is doing the bare minimum to resolve this and my children are breathing fuel fumes consequently. Please note, not all my repair invoices are attached. I do not have access to all of them at this time

The contact owns a 2021 Kia K5. The contact stated that fuel odor was entering the cabin of the vehicle. The contact stated that the rear passenger’s seat seemed to be inflated. While driving approximately 70 MPH, the contact became aware of fuel squirting out of the fuel filler neck. The fuel gauge fluctuated from full tank to half tank or empty. There was no warning light illuminated. The fuel odor became stronger, and the contact pulled over to the side of the road at a rest stop. A mobile service tech arrived to inspect the vehicle but found no failures. The contact continued driving to the residence. The vehicle was taken to the dealer, who found that the fuel tank and fuel line had failed and needed to be replaced. The dealer sent a photo to the manufacturer to confirm the necessary repair. The vehicle was not repaired. The manufacturer was informed of the failure and determined that the fuel tank and PCV valve were swollen and needed to be replaced. The manufacturer offered a buy-back for the vehicle and opened a case. The failure mileage was unknown.

The contact owns a 2021 Kia K5. The contact stated that while his daughter was driving approximately 15-20 MPH, the engine revved and the gears in the transmission unexpectedly failed. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. No warning lights were illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. Due to the safety concerns, the vehicle was no longer driven and remained parked at the residence. The manufacturer was not informed of the failure. The failure mileage was unknown.

While driving, the check engine light came on. Soon after, the rear floor of my 2021 Kia K5 lifted upward, and I noticed the fuel tank underneath had swollen. When I opened the gas cap, it blew off with force and gasoline sprayed on me, soaking my clothes. This could have caused a fire or explosion. The car is now unsafe to drive, and the rear seat cannot be used because the floor is deformed. I discovered that Kia has a Voluntary Emissions Service Campaign SC288 addressing this exact issue (fuel tank swelling and excessive pressure due to a faulty PCSV valve and EVAP system), but this is clearly a safety hazard, not just an emissions problem. Many other owners have reported the same issue online. I believe this defect should be escalated to a safety recall before someone gets seriously injured or worse.