2021 Kia K5

I was driving down the highway and my car made a loud bang noise. It would not accelerate over 50 mph no matter how hard I pressed the accelerator. Took to dealership and they told me I needed a new battery and charged me $365. Drove it and still won’t go over 50 mph. They kept it for a week and said it had a faulty valve that caused pressure to make the gas tank expand, pushing up back seat. Said it wasn’t a recall and would cost me $3600 to fix. Told me it was too dangerous to drive. Did research and saw that this was discovered over 2 years ago but I was never told. Now they say I have too many miles on my car to fix it. The gas fumes inside the car are intolerable and it still won’t go over 50.

HVAC is not working at all, not even blowing hot air. I've been told it could be a wiring issue or have to change my blower and resistor. KIA has told me they could not help because my car is over the 60,000 mile warranty. However, my car is 70,000 miles and about 4 years old. It has had other recall issues and just trying to be helped.

Just minutes before entering the highway, my son and I heard a very loud popping sound that startled us, like something large hit the car or a tire exploded. I immediately pulled into a gas station checked the exterior & all 4 tires, but everything appeared intact. Shortly after, while driving on hwy during morning rush hour at 65–70 mph in the far-left lane, the check engine light illuminated & almost immediately the car lost all engine power. My speed dropped quickly with cars behind me traveling at high speeds. I had to activate hazard lights & cut across 4 lanes of traffic to the shoulder, putting myself, my child passenger, & others at serious risk of a multi-car collision. While waiting for help, I plugged in my FIXD OBD-II reader later looking over diagnostics read code P0451 – EVAP System Pressure Sensor. 8 hours after car was towed & had been parked at my home & still not starting I researched the code to learn what that means & the possible cause for & found it is all emission related issues varying in reasons as simple as a gas cap replacement. Nothing of any engine failure while driving risking the lives of drivers & others so before sending my car to a mechanic, I went and checked the gas cap in case just a simple emissions type fix that is where I observed fuel still bubbling out of the tank have photos, my daughter, & sister, as witnesses. The next day car was towed to Kia Mall of Georgia on June 26, 2025. As of August 20, 2025, the dealership has confirmed the fuel tank expanded as of now there is no resolution from Kia for fixing once this happens can likely shift car frame & could be declared totaled. Component/system failed: Fuel tank/EVAP system (pressure failure). Vehicle is available for inspection at Kia Mall of Georgia. Safety risk:Complete engine shutdown at highway speeds with child passenger on board; risk of multi-car, high-speed crash. Fuel bubbling/spitting increased fire hazard. not a recall only emissions campaign needs to change

Check engine light came on and when filling up my gas tank, gas spit back out at me which has happened with the fuel tank i had in it last year and has since been replaced. Forward collision, EBS, traction control and forward safety sensor lights came on the next day and the car is running extremely rough. It was towed to a shop to see if it has to do with the fuel tank recall. Multiple people in Roanoke, Virginia are having the exact same problem as is a large portion of people online complaining about the exact same thing. Some going back 30 weeks ago.

My fuel tank expanded while I was driving on the highway, causing my car to stall and would not respond to me pushing on the gas. I pulled over on the side of the highway and looked back and saw my rear seats were pushed up. Got it towed to the Kia dealership and they informed me that my car was totaled because the gas tank expanded so much it bent my frame. This has been an ongoing issue with Kia/Hyundai vehicles but they have still not issued a formal recall, only a voluntary callback even though this is a very dangerous defect.

Expansion of air tank, causing to pop up frame in backseat and total car deemed unsafe to drive. No warnings car had never been in the shop prayer happened while driving over rule Mountain area with two children in the backseat. Kia inspected diagnostic ran stated it was air in gas tank under a recall claim to fix it for free and then two weeks later stated it was going to Kia America for a case number. Kia America called and stated that it was not safe to drive and the car is totaled.

Driving down highway, gas hand was on half a tank then all of a sudden gas hand drops to empty and light comes on, engine started sputtering. Heard a loud pop in the back seat looked back and back seat has popped up from base. Strong odor of gasoline poured into the car. Went to closest gas station to get off highway. Unable to put fuel into tank. Called Quality KIA of Greenwood they said get out of the car and do not drive it. Called for a tow, vehicle has been towed to Quality KIA of Greenwood.

I recently purchased a Kia k5 2021 gt line awd one month later I noticed there was recall I take to the dealership they let me know it will only take a few hours (3) and I can pick up later the same they call me 3h later and let me know sorry this case is going to take a few weeks and I should pick up rental car and they will pay for my rental so I did I come back one month later nothing as been done they just tell me to wait and they can’t release due to the safety recall the tank has swelled up it has been 3mont now and they still haven’t done anything to the car and I can’t sell the vehicle cause they won’t release it

My current 2021 Kia K5 FUEL TANK EXPLODED while driving. I’ve had this car for about 5 years and since driving it off the lot have experience issues with the vehicle and just a few hours ago, the fuel gas tank explode raising the back seat with passengers in the vehicle. It was extremely scary and something out of the blew. My friends and I were driving and I noticed the car engine light turn on (which was so odd to me as I keep a close eye to the car maintenance) and within 20 minutes we heard two EXTREMELY loud explosions sounds come from the car with the feeling of the car shake and rise a bit and felt as a tire exploded. I did not find this usual and we pulled over and the the seat my friend was sitting on was rose and unlatched. We then did some google searches and when looking into it, it appears there have been previous issues with this situation for other K5 Kia owners but KIA has done nothing regarding the matter. A few months ago I also went due to an internal thermostat exploding and causing the engine to overheat and smoke on the freeway and because they deemed it was not under the warranty, I left car-less for a week and a high bill. I don’t understand why I have to pay and endure these service costs when this is BASIC CAR FUNCTIONS. I do not appreciate the lack of empathy from dealer and service staff and feel unsafe and concerned for my safety for driving this vehicle. And now II have to endure the costs of being car less for 14 days per the dealer. Absurd.