2024 Kia EV9

I am experiencing significant and persistent vibrations at highway speeds (60–75 mph) in my 2024 Kia EV9. Despite multiple dealership visits and repair attempts, the issue remains unresolved. The vibrations cause noticeable discomfort and potential safety risks, especially on long drives. Timeline of Events & Repairs: 1.First Visit to Kia dealer (Dec 24): The dealership performed a tire balance and determined one tire was defective, replacing it. Vibrations persisted. 2.Second Visit (Jan 25) The dealership replaced the remaining 3 tires 3. ThirdVisit (Feb 25): The dealership identified three wheels with lateral runout and replaced them. They also performed road force balancing, reportedly bringing all values below 16. 4.Test Drive (Feb 25): After picking up my vehicle, I drove on the interstate and found the vibrations had worsened, now starting at 60 mph instead of 70 mph. •A third-party wheel shop inspected the wheels and found the fourth wheel (not replaced by Kia) was defective and out of round. 5.Dealership’s Response: Despite these findings, Kia dealer dismissed my concerns and referred me to another dealership for a second opinion. They also stated that third-party evaluations are not accepted, creating an endless loop where I cannot get the issue properly addressed. Safety Concerns: •Vibrations impact vehicle stability and driver comfort, especially on long trips. •Extended driving with excessive vibrations may lead to fatigue, reduced control, and premature mechanical wear. •The fact that multiple components (wheels, tires) have required replacement raises concerns about a potential manufacturing defect affecting Kia EV9 models. Request for Investigation: The dealership has failed to resolve this issue despite multiple repair attempts, and their refusal to acknowledge third-party findings leaves me with no clear resolution path. I request that NHTSA investigate potential defects in the wheels, tires, or drivetrain system of the Kia EV9.

I brought the vehicle in to have recalls addressed on 12/30/24. Starting the next day we noticed the car was weaving without any steering, but thought it might have been icy road conditions and waited to see if it reoccured. The car has since weaved intermittently, but has righted itself after releasing the accelerator. However, on 1/15/25 while traveling about 50mph, the car started weaving on its own and when the accelerator was released the car started to wildly fishtail. Called dealer and they agreed this was a serious issue and agreed to see car the next morning. Service tech said when they drove the car it did the same thing and that the troubleshooting recommended I change the regenerative braking setting to "smooth" and sent me on my way. I did not get even a mile before the car began weaving rapidly again on its own. Went straight back to dealership where manager wanted me to drive the vehicle again with the tech in car which I refused as it is not safe to drive. So he said if I was ok with it tech would take car out again but if it was just acting how regenerative brakes work, there wasn't much else they could do. When manager returned to talk to me, he said he ended up going with the tech and it did replicate the weaving action two times during that drive. The car is steering on its own weaving wildly left and right and imposes a great danger and no longer feels like a safe vehicle to drive.

The display for the instrument cluster is completely blank, or shows unrelated information after starting the car and shows none of the vital information about the car's operation or status. After leaving the car off for 30 minutes, the instrument cluster display began functioning normally. This was the subject of a 2024 October recall which we got dealer service for but the issue is not resolved.

Car was new with 1,002 miles on odometer and with me for 3 weeks. The 12 volt battery died and needed to be replaced. This vehicle uses the 12v battery to start the electronics for the car which then enable operation of the car. The failure of this battery left the car without any power and it needed to be towed from my garage to the dealer. This is a common issue with Kia and Hyundai electric vehicles.

Our KIA EV9, which HAS HAD the software update installed to address NHTSA Recall Number 24V757 (Kia safety recall SC326) has again had the driver's instrument panel screen come up blank when the car was started. This is identical to behavior we observed multiple times before taking the car to the dealership for the software update. To resolve the issue, the car was turned off and permitted to sit for an hour before we attempted to start it again and the problem was no longer present.

Dashboard shows a message" Stop vehicle and check brake system", vehicle doesn't pass over the 10 mph. On the KIA access APP I have all this 6 Diagnostic Issues : FR_CMR C28B981, FR_CMR C164286, ADAS_DRV C28B086, ADAS_DRV 28B986, ADAS_DRV C28B881, ADAS_DRV C164286. Dealer was unable to fix the issue, they state that it fix by itself. Also I have a safety Recall SC326

Left screen where odometer should show become blackout at the middle of my driving. Went to drive for 200 miles without odometer and other warning signs because the screen are all blackout, 3rd time happen. 1st was Gear also not emgaging and blackout screen 3 months ago, then same incident happen 2 months ago and then another incident with same reason for this month.