2025 Kia EV6

I own a 2025 Kia EV6 Wind RWD. At approximately 14,655 miles, the vehicle experienced a confirmed Integrated Charging Control Unit (ICCU) failure that resulted in loss of 12-volt charging and reduced motive power. On August 1, 2026, while reversing the vehicle, I heard a loud pop from underneath the rear seating area. Immediately afterward, the red 12-volt battery warning light illuminated and the vehicle displayed a “Check Electrical Vehicle System” message. Because I was concerned that the vehicle was no longer charging the 12-volt battery, I externally charged the 12-volt battery with a smart charger and then measured the battery voltage with a multimeter. With the vehicle off, the battery measured 12.99 volts. After starting the vehicle and confirming it was in READY mode, the voltage measured only 12.35 volts, indicating that the vehicle was not maintaining the 12-volt electrical system. When I drove the vehicle to Hilltop Kia on August 3, 2026, the vehicle had substantially reduced propulsion and would not exceed approximately 45 mph. The dealer diagnosed the vehicle and documented DTC P1A961C, “LDC Internal Power Supply,” and DTC P1A9096, “LDC Input Voltage Sensor.” The dealer’s Kia diagnostic system showed LDC input voltage of only 1.7 volts, compared with a stated typical value of approximately 565.5 volts. The dealer replaced the Integrated Charging Control Unit (ICCU), part number 36400-1XF06, and the high-voltage ICCU fuse, part number 375F2-GI040, under warranty. The cooling system was bled, diagnostic trouble codes were cleared, and the vehicle was road tested and returned to me on August 6, 2026. I purchased the vehicle new on November 28, 2025. My vehicle is a 2025 model year EV6 and is outside the earlier 2022-2024 EV6 ICCU recall population. I am filing this complaint because the ICCU failure caused the vehicle to stop charging the 12-volt electrical system and resulted in significantly reduced motive power. The symptoms and dealer-confirmed

Hi, I had to transport a few lumber pieces that did not fit into the trunk of my Kia EV6, so I had to leave the hatch open (I pulled it down as far as possible and secured it via a rope against the latch). When I started driving the car started beeping frantically, but allowed me to drive. When I crossed an intersection traffic came to a temporary halt, and when I came to a stop my Kia all of a sudden shut off and would not allow me to put it back into gear again. When traffic around me continued I was unable to move and presented a security hazard with cars coming from behind almost running into me because they expected me to move, which I couldn't. I inquired about this at my dealership this morning and was told that there is no way to override the car's behavior and that this behavior was a "safety feature" to ensure the car wouldn't be driven with the hatch open. Now I'm asking since when is it a safety issue to knowingly drive with the hatch open to transport an oversize item - shouldn't that decision be left to the operator of the vehicle? In my opinion it's a much bigger safety issue to all of a sudden disable the entire powertrain of the vehicle when coming to a brief stop. What if the brief stop would have happened on a highway or freeway? Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ICCU failure. Car lost power while driving. I heard a "pop" sound and then the car displayed a warning light moments before losing power. Car was towed to the dealership where they diagnosed and replaced the ICCU and a fuse. This is a known problem since the 2022 model year and seems to be a very common failure that the manufacturer is unable definitively repair. Thankfully I was on a local street and not on a highspeed highway when this occurred.

ICCU failure within three (3) days of buying vehicle. Only 300 miles on it. Failed to charge with known working Level 1 charger on day 1, successfully charged with Level 3 charger on day 2, and then failed to charge at same Level 3 charger on day 3. Simply connecting the Level 3 charger on day 3 had the car emitting "charger errors", and then followed that up with an "On board charger" fault. Vehicle no longer charges. Returned to dealer for repair.

When shifting from reverse to drive there was a loud pop towards the back up the car. A check electrical system warning popped up, and then eventually a Check Power Supply stop now warning came up. The vehicle would not go above 26MPH and had to be stopped in a parking lot to be towed to the dealership. The ICCU went out and needed to be replaced, was at the dealership for 2 weeks for replacement.

The ICCU unit failed. Limited speed and no charging capabilities. The Dealer has been informed and an appointment has been made 3 weeks out as they are too busy. The ICCU has not been inspected yet. No warning lamps or messages appeared before the problem started. After a loud POP or bang in the rear of the car 1 warning light appeared and 1 message. (See Attached) POP happened at 16:15 hrs on the attached graph.

I have experienced a ICCU failure at 7200 miles on my 2025 EV6 GT Line. This failure is a safety hazard as it will quickly disable the vehicle and strand the occupants wherever they be at the time of failure. (highway, back roads, day or night). There are warning lights when this occurs, but there is a very limited time to get to safety, depending on the state of charge of the onboard 12v battery. This issue has been ongoing since this vehicle came out in 2022. There have been a number of recalls to address the problem, but apparently without success. I see postings all the time with others experiencing this failure. When I inquired about the availability of the replacement ICCU, I was told that the part was on national back order. I was also told there were 147 units in transit, 47 were already spoken for. This seems to indicate that this is a very common issue, affecting many drivers.

Erratic behavior before pulling out of parking lot: STOP vehicle check power, check 12V battery Stop safely engage parking brake. All dash lights started flashing, going black, power couldn’t be maintained, thankfully not on highway yet. Complete car failure, had to have 2025 EV6 jumped 4 times, battery still showed 41% charged, couldn’t keep charge to even get car in neutral for tow or doors locked. After each jump from tow company, power would last for less than 3-5 seconds, then dead, completely dead vehicle nothing worked.

After 2474 miles, the vehicle Integrated Charging Control Unit (ICCU) failed in my 2025 Kia EV6 making the vehicle undrivable so it had to be towed to the Kia dealer. The ICCU was replaced under warranty. The failure of the ICCU in Kia, Hyundai and Genesis electric vehicles is fairly common and they have yet to come up with a permanent solution.