2025 Kia EV6

I own a 2025 Kia EV6 Wind RWD. At approximately 14,655 miles, the vehicle experienced a confirmed Integrated Charging Control Unit (ICCU) failure that resulted in loss of 12-volt charging and reduced motive power. On August 1, 2026, while reversing the vehicle, I heard a loud pop from underneath the rear seating area. Immediately afterward, the red 12-volt battery warning light illuminated and the vehicle displayed a “Check Electrical Vehicle System” message. Because I was concerned that the vehicle was no longer charging the 12-volt battery, I externally charged the 12-volt battery with a smart charger and then measured the battery voltage with a multimeter. With the vehicle off, the battery measured 12.99 volts. After starting the vehicle and confirming it was in READY mode, the voltage measured only 12.35 volts, indicating that the vehicle was not maintaining the 12-volt electrical system. When I drove the vehicle to Hilltop Kia on August 3, 2026, the vehicle had substantially reduced propulsion and would not exceed approximately 45 mph. The dealer diagnosed the vehicle and documented DTC P1A961C, “LDC Internal Power Supply,” and DTC P1A9096, “LDC Input Voltage Sensor.” The dealer’s Kia diagnostic system showed LDC input voltage of only 1.7 volts, compared with a stated typical value of approximately 565.5 volts. The dealer replaced the Integrated Charging Control Unit (ICCU), part number 36400-1XF06, and the high-voltage ICCU fuse, part number 375F2-GI040, under warranty. The cooling system was bled, diagnostic trouble codes were cleared, and the vehicle was road tested and returned to me on August 6, 2026. I purchased the vehicle new on November 28, 2025. My vehicle is a 2025 model year EV6 and is outside the earlier 2022-2024 EV6 ICCU recall population. I am filing this complaint because the ICCU failure caused the vehicle to stop charging the 12-volt electrical system and resulted in significantly reduced motive power. The symptoms and dealer-confirmed

2025 KIA EV6 ICCU (part#36401 1XFD5) failed at 2,658 miles. Failure occurred when power was applied after reversing out of a parking space, switching to drive and applying power. No safety issues as vehicle remained controllable. Vehicle went into "limp" mode. Build date of vehicle is 6/20/2025. KIA Dealer has replaced failed ICCU with updated unit (part#36400 1XFD6). No indication of failure occured prior to the failure (an audible "POP" heard from the rear cabin when the unit failed).

The ICCU unit failed. Limited speed and no charging capabilities. The Dealer has been informed and an appointment has been made 3 weeks out as they are too busy. The ICCU has not been inspected yet. No warning lamps or messages appeared before the problem started. After a loud POP or bang in the rear of the car 1 warning light appeared and 1 message. (See Attached) POP happened at 16:15 hrs on the attached graph.

initially filed XXX (1/2/2026) 2nd (additional info) filed XXX (2/10/2026 3rd (3 page service report) XXX (2/11/2026) Vehicle is registered to Christopher Rojik, however it is my car that I drive, etc. today I am filing this for you folks that since I filed the complaint with Kia Corp. and sent them the service report, etc. Today, 2/19/2026 I received a formal Settlement Agreement and General Release to sign and accept. I am not signing it, as well as it fully releases Kia from any future issues, etc. outside of the warranty and whatever other details it claims. This will or should be the last for me to file. I had no idea they send me this kind of offer. As it is listed specifically as a "GOODWILL GESTURE" and they are not accepting fault or something like that. I attached inidividual pages, hopefully I can upload them as pdfs, we will see. If not I'll take quick pics and attach. thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving on a busy road at night, my vehicle displayed battery warning lights and went into "limp mode" which slowed me down to 25 mph before stopping completely. I was then stranded until a tow truck could be dispatched. The Kia dealer told me that the issue was an ICCU (integrated charging control unit) which they have to order. I have since learned that this issue is known and is common.

I was driving on the highway when I heard a pop like a loud fuse sound from the back seat area. Suddenly the car dropped 15 mph from 70 mph to 55 mph and the battery and electrical system warning lights came on and the vehicle said check electrical system. I was able to continue with my hazard lights on to exit the highway, at which point the max speed of the vehicle dropped to 45 mph. It would not go faster no matter how hard I pushed the gas pedal. I was able to pull over to a gas station and park in a spot but the vehicle had to be towed. When the tow truck arrived, the vehicle also flashed with the 12V battery low warning. It was diagnosed as a failed ICCU, which rapidly drained the 12V battery. The car is only 4 months old with about 7,300 miles. This is a serious safety concern, especially with the sudden failure and loss of power. I’m lucky I wasn’t hit and that I was able to get off the road before it totally died.