2025 Kia EV6

Failure to charge properly on both alternating current and direct current platforms. Trips electrical breakers at residence while charging at home on AC current. The vehicle will only DC fast charge for a few minutes before charge session is prematurely terminated. I have been told by the KIA that it is a failure in the integrated charge control unit (ICCU). They told me there were 47 current problems right now in the state of Tennessee. I have not been issued a recall at this time. The logistics for getting a new ICCU could 2 weeks or greater. This problem could be catastrophic on long road trips.

Erratic behavior before pulling out of parking lot: STOP vehicle check power, check 12V battery Stop safely engage parking brake. All dash lights started flashing, going black, power couldn’t be maintained, thankfully not on highway yet. Complete car failure, had to have 2025 EV6 jumped 4 times, battery still showed 41% charged, couldn’t keep charge to even get car in neutral for tow or doors locked. After each jump from tow company, power would last for less than 3-5 seconds, then dead, completely dead vehicle nothing worked.

After 2474 miles, the vehicle Integrated Charging Control Unit (ICCU) failed in my 2025 Kia EV6 making the vehicle undrivable so it had to be towed to the Kia dealer. The ICCU was replaced under warranty. The failure of the ICCU in Kia, Hyundai and Genesis electric vehicles is fairly common and they have yet to come up with a permanent solution.

I was driving on the highway when I heard a pop like a loud fuse sound from the back seat area. Suddenly the car dropped 15 mph from 70 mph to 55 mph and the battery and electrical system warning lights came on and the vehicle said check electrical system. I was able to continue with my hazard lights on to exit the highway, at which point the max speed of the vehicle dropped to 45 mph. It would not go faster no matter how hard I pushed the gas pedal. I was able to pull over to a gas station and park in a spot but the vehicle had to be towed. When the tow truck arrived, the vehicle also flashed with the 12V battery low warning. It was diagnosed as a failed ICCU, which rapidly drained the 12V battery. The car is only 4 months old with about 7,300 miles. This is a serious safety concern, especially with the sudden failure and loss of power. I’m lucky I wasn’t hit and that I was able to get off the road before it totally died.

Driving down local (residential) roads, the ICCU died; towed to dealership 12/3/2025. All 12 volt electrical was inoperable. So no hazard lights, no shift to neutral, no locking the doors. It was towed to the dealer. ICCU is now being ordered. The Master Warning light and 12V battery warning light illuminated. I was fortunate to be able to park in a parking lot just before all electrical died. An Internet search shows that this is a known issue; and, even after the replacement the situation can happen again. Took delivery 6/28/25. So, not even 6 months old.

On 2025-11-12, my car got BMS error P1B9700. On 2025-11-13, I took the car to local Kia dealer. The error is for battery temperature sensor. After 1 week, thst sensor have not been replaced nor any other numerous minor electrical defects were fixed. My car was just parked in dealer lot the whole time. No communication from Kia or dealer how to fix this potentionly dangerous battery problem.

Power completely dropped while driving in traffic. This occurred several times. I could have easily been rear ended. Also, I could have been stuck within an intersection, I could have been broadsided. I see researched this issue and found it was widely written about in KIA EV6 online forums. Kia should have checked for issues before I leased the 2025 EV and informed me before I made a decision to lease vehicle. This occured in first weeks I drove the new car.