2024 Kia EV6

My 2024 Kia EV6 is experiencing a total failure of the 12V charging system and requires manual jumpstarts to operate. The official ICCU safety recall (SC327) was previously performed, which is why the NHTSA database shows 0 unrepaired recalls for this VIN. However, the manufacturer's remedy has completely failed. Per NHTSA safety guidelines, this vehicle is currently subject to a sudden loss of motive power while driving and is unsafe to operate on public roads.

Car was totally dead even with a 68% charge. AAA came out to jump start. The next day while driving on the highway the car started to lose power. A red warning to check the electrical system came on along with "turtle mode". I was able to pull over off the highway, grateful the two small children were not with me. Car was towed to dealer who kept it for the three days. Only after repeated calling could I reach someone who said they couldn't reproduce the problem. I'm afraid to drive the car at this point as I feel it's just unsafe to do so. This seems to be an ongoing issue that Kia can't seem to fix.

We purchased a certified pre-owned 2024 Kia EV6 GT on 6/5/2026. On 6/6/2026 while driving on city streets, the display screen suddenly displayed a large and flashing red warning message "Stop vehicle and check power supply" in addition to the battery symbol. We took the vehicle to the dealership and they diagnosed that the ICCU had failed and needed to be replaced.

Component: ELECTRICAL SYSTEM:12V/LOW VOLTAGE BATTERY, PROPULSION system:Integrated Charging Control Unit (ICCU) Description: This vehicle previously had the mandated safety recall software update (Campaign SC327) applied by an authorized Kia dealership in December 2024 to protect the Integrated Charging Control Unit (ICCU). The corporate recall remedy failed. In January 2026, the vehicle suffered a sudden, catastrophic loss of motive power while driving on a public roadway due to a total ICCU failure, which created an immediate hazard for myself and my young child who was inside the vehicle. When the primary ICCU component failed, it starved the low-voltage system, causing severe deep-discharge damage to the 12V battery. Following the warranty repair of the ICCU in February 2026, the vehicle was returned to me. However, Kia's official corporate diagnostic and repair procedures for this defect are fundamentally flawed and incomplete; they do not mandate a comprehensive load-test or automatic replacement of the 12V battery following an ICCU collapse. Because of this failure in the official repair procedures, the vehicle was returned to service with a critically compromised low-voltage system. This directly resulted in recurring battery warning messages over the subsequent months, culminating on May 29, 2026, in a secondary, total 12V battery failure that completely bricked the vehicle. The failure of the manufacturer's official safety recall remedy and the subsequent inadequacy of their post-failure service protocol left this vehicle in a chronically un-roadworthy and unsafe condition.

I had an ICCU failure on 4/12/26. I was fortunate enough to be close to home, so I was able to get back home before the vehicle dropped into reduced power mode. As has been reported many other places, I heard a loud pop and moments later a number or warning messages came up on the display. It was towed to the dealer the following day and has been confirmed to be an ICCU failure.

2024 Kia EV6 leased January 2025. Vehicle is subject to NHTSA Recall 24V-867 / Kia campaign SC327 for the Integrated Charging Control Unit (ICCU). The recall remedy was performed at an authorized Kia dealer in July 2025 (software / operational logic update). The defect was not cured. Three months after the recall remedy was performed, the vehicle suffered complete loss of electrical power and would not move. It was towed to the Kia dealer. The dealer's own diagnostic recorded code P1A9096 — the exact diagnostic code Kia's recall instructs technicians to check for — and replaced the ICCU and high-voltage fuse. This is the recall-defined failure occurring AFTER the recall remedy was applied. Approximately three months later, the vehicle again suffered total loss of power and would not start in cold weather. It was towed in. The dealer replaced only the 12-volt battery and did not address the ICCU, despite the documented prior ICCU failure on this VIN. The 12V battery failure is a known downstream symptom of ICCU failure on this platform. Approximately one month after that, the vehicle returned for charging system failure ("vehicle charges briefly then stops") and a "check electrical/hybrid system" warning that appeared while driving. Diagnosed as charging port failure. Vehicle was out of service approximately 27 consecutive days. Total cumulative days out of service across four visits: approximately 35-40. Two safety-related stranding incidents resulted from these failures. Both occurred in winter conditions in Pennsylvania. In the first, the driver was stranded in a parking lot at night during a snowstorm in sub-zero conditions; three tow trucks were dispatched before a flatbed could recover the vehicle because the EV could not be towed conventionally with no power. In the second, the vehicle died in a school parking lot during a snowstorm; the first dispatched tow truck could not recover an EV with no power, and the driver had to walk multiple miles home in freezing

The vehicle’s ICCU unit stopped working out of the blue. This happened on a busy intersection and the car came to a sudden and violent halt. Luckily we were not involved in an accident. It’s a very well known issue with these vehicles and it’s really criminal that Kia has done nothing to fix it. They just change the ICCU unit and then it happens again.

Went to charge my vehicle in my garage on 4/15/26. When it was fully charged, I reached to disconnect the charger from the vehicle and the connector was hot to the touch; the charging hub on the vehicle was also hot, the charger had a slight plastic burning smell. I immediately tried to contact the company and learned that they had unbeknownst to me, ceased conducting operations in the US. So I ordered a new charger. I also tried it again on 4/17/26; and the heat was higher faster than it was on 4/15/26; so I hav disconnected the device and installed a new one. The electrician noted that the breaker was damaged and had to be replaced. I also recall, that a few months after the initial install of the charger, there was an incident where my wife saw sparks in the garage from the breaker and we heard a large pop; and then the charger went out. The company sent us a new one then that worked fine for a few years.