2023 Kia EV6

The vehicle experienced a total power failure resulting in complete inoperability (no start, no unlock, no electrical response). This is the second occurrence within approximately five weeks. The most recent incident occurred after the vehicle was fully charged and driven the day prior. There were no warning lights or messages before the failure. The vehicle was previously inspected by an authorized dealer and a manufacturer service campaign related to the charging/low-voltage system was performed, after which the problem recurred. This condition can strand the driver without warning and poses a safety concern.

First year of ownership rear engine needed to be replaced. The car literally stopped where I was on the road and had to be towed to dealer. It took a month to get the motor replaced. After that, my car stopped while I was leaving my house driving it out of my driveway. There were red warining lights and sounds and then it just suddenly died seconds later. It had to be towed to the dealer. They said it was fixed and that the 12v battery wasnt being charged. Then I was leaving church when my car died on me again. Same issue. Now, the third time in this vehicles 2 years of life, my car died while I was on the highway driving to work in the morning in the passing lane during rush hour. The dash went red and waring lights and sounds with a message get to safety quick check electrical system and it only gave me a few seconds the car suddenly just stopped running and I was coasting on the highway to try to get to safety. I was going 70mph in the passing lane during rush hour, I could not steer to the left to coast off the road because on my left it was just a ditch no side road to stop on, I saw in the right lane a car that was a length or so behind so I cut my wheel straight across the right lane where I coasted to a complete dead stop barely making it to the side of the road. The side of this highway was barely the width of my car so traffic flying next to me was just inches away from my drivers side door.... I called roadside assistance and had it towed to the dealer. They then told me about the recall - which I had already had it into the dealer to fix the last time it was there for this same issue. The car is 2 years old and so far I have had it stop dead in its tracks on me 4 times! I have such stress and anxiety about continuing driving this vehicle as it is completely unsafe! I almost died last week when this happened. My safety and others on the highway that day were at risk. This could have been catastrophic.

My 2023 Kia EV6 experienced a sudden ICCU and 12-volt system failure while traveling approximately 50 mph. Without warning, the vehicle instantly lost propulsion and all electrical power. This included loss of steering assist, braking assist, hazard lights, shift capability (unable to shift into Park), and even the ability to lock the doors. The failure effectively “bricked” the vehicle in motion. I was only able to get the vehicle off the roadway because the road happened to slope downward into a nearby lot. Steering required significant physical effort, the brake pedal went completely hard (“dead”), and the vehicle offered no functional parking brake or Park engagement once stopped. Because I was on a hill, we had to allow the car to roll to the bottom until it met a curb to prevent movement. After power loss, the doors could not be locked at all. This type of unrecoverable electrical failure creates an extreme safety hazard for the driver, passengers, and surrounding traffic. There is no pre-warning and no diagnostic indicator. The ICCU fuse appears to fail spontaneously and renders the vehicle uncontrollable in several critical respects. This is not an isolated issue. ICCU failures have been occurring across the Kia EV6 and Hyundai Ioniq 5/6 platforms for more than three years, including on brand-new 2025 models. The persistence of this defect across multiple model years indicates that the underlying design or component defect has not been resolved by the manufacturer. Given the suddenness of the failure, the total loss of vehicle control systems, and the long history of similar incidents reported by other owners, I am now hesitant to drive the vehicle due to the unpredictable and dangerous nature of the defect.

The vehicle can't be changed with a message "issue with electrical system". The message blinks very fast for 3sec and disappears. I have to turn on and off the car a few time to be able to read the message. The the car lost 12V secondary battery, it only shows 5.5V when measured. car is dead.. Replaced with new battery, car can start again but the car still can't be charged. Is it related to ICCU problem? KIA doesn't show any recall to this problem.

On several occasions, when traveling over 55mph, once the battery hits a certain threshold (35% or 55% so far) the “power is limited” warning will appear on the dash and the vehicle will lose power. This has not occurred at lower speeds but only at higher speeds, and not every time. This vehicle was purchased so my husband could do his freeway commute, but it is on a remote highway where there is often no shoulder, so it especially dangerous to suddenly lose power with limited ability to safely pull over. On one such occasion, he drove the vehicle straight to Kia for inspection. They said the soonest available appointment was in 2 weeks and because they had no technicians available, they could not run the diagnostic that would allow us to get a rental car in the meantime. They suggested going to a different Kia dealership. We called ahead and they said they could try to see it that day or the next, but when we arrived (with, again, the power failing on the drive to the next dealership), they said we were misinformed and they would have to hold the vehicle for at least a week with no rental option. We have since been unable to use the vehicle for commuting due to its unreliability and incredibly dangerous power failure.

I was driving my Kia EV6 2023 on I-110 in California when the driver rear tire suffered an instantaneous deflation. I was driving at or slightly below the 65mph speed limit, there was traffic in front and to the rear of me, the road surface was excellent. The tires had 11556 miles of use and were operating at the correct pressures as the vehicle has a tire monitoring system. The ambient air temperature was circa 76F. I was able to exit the freeway with some difficulty. The tire was a Continental Cross Contact 255-45 R20. I have been driving for nearly 60 years, had a wide range of cars and tires and never experienced an incident like that described which has all the indications of a product defect.

The contact owns a 2023 Kia EV6. The contact stated while attempting to unlock the driver's side door with the remote, the door failed to unlock. The contact manually unlocked the door with the key. In addition, while attempting to start the vehicle, the vehicle failed to start, with the message "12-Volt battery failure" displayed. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V200000 (ELECTRICAL SYSTEM); as a probable cause for failure. The manufacturer was notified of the failure. The approximate failure mileage was 30,000.