2023 Kia EV6

The contact owns a 2023 Kia EV6. The contact stated that while driving 72 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact stated that the console displayed that the drive mode independently switched from rear wheel to front wheel only. The vehicle was driven to a safe location and parked. The contact allowed the vehicle to sit for approximately thirty minutes; then the vehicle was started the vehicle and driven to the destination. The failure reoccurred, and the failure was persistent. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 8,000.

Vehicle lost its power while trying to park. It could not be locked either. This is the second time this has happened. The first time, dealership said they replaced the auxiliary battery. When it got towed the second time, the dealership said, we only recharged the aux battery during the last complaint! Now, the dealership does not have anyone who can look into this issue for one week. Added to that, they do not have any loaner cars either! The car has 10,523 miles on it now. Car had 8000 miles during the first incident. We feel this is dangerous, unacceptable quality and not to mention, unbecoming of a vehicle brand not to give us a loaner car and expect us to wait a minimum of 10 days to figure out the problem.

Vehicle does not reliably handle the 12V battery well. Many times, I see it sitting at 12.8 VDC when driving the vehicle. On a ICE vehicle, the charging voltage is close to 14V when running/driving. On 3 separate occasions, when I tried to "start" the EV6, the 12V battery was too dead to allow the car to be started. Basically stranded. This can be life threatening if this occurs in frigid temps. Or a hazard to traffic if/when the car tells you to "pull over safely, immediately". OK, I can "block the box" because my car died??? Kia and Hyundai need to address this issue that's common to their recent "luxury" EVs. With all the high-tech these cars have, why can't it manage the charge-state of the 12V battery? Tesla vehicles do not have this issue (I believe). Tesla EVs do "lose" their 12V battery over time, but that is similar to the 12V battery that eventually dies in a regular ICE vehicle. This 3rd time that this occurred, I called 800-KIA and had the car towed. So far, "they cannot reproduce the problem".

I leased a 2023 Kia EV6 vehicle and on October 30, 2023, I was 45-60 minutes into my first road trip when a warning displayed in the dashboard followed immediately by a reduction of motive power. The warning displayed was a turtle icon and the words “Power Limited.” Traveling on CA I-5 when this occurred putting me in a very dangerous situation. I navigated several lanes of traffic, vehicle decelerating, to reach the shoulder and pull over then to merge into existing traffic traveling at a high rate of speed only to advance 7-10 miles before the warning display reappeared. I then repeated the process another 7-8 times until I reached my destination. Later that day, again, 45-60 minutes non-stop when the warning display reappears for the second time and I’m forced to repeat the process another 7-8 times to make it to the dealership. I was told the vehicle had a warranty defect in the VCSM which had to be replaced. On January 25, 2024, the issue reoccurred for a third time after and I drove the vehicle directly to the dealership. I was told the diagnostic test did not reveal any codes and they had a service advisor drive the EV6 home, over an hour to see if he could recreate the problem. The service advisor experienced the same issue, twice, and the diagnostic scan did not reveal any codes. My safety and well-being have been compromised on three-separate occasions and twice with a dealership service advisor. I contacted Kia Customer Care Center and opened a case #15946871 and a tech-line case #16141516 was opened with Kia America. NHTSA opened an investigation on the 2022 Kia EV6 and the 2023 Hyundai Ioniq 5 which shares the same E-GMP electric vehicle platform. The investigation confirmed “a range of loss of power and varying time intervals between the warning message and loss of power and all power to the vehicle was subsequently lost, immobilizing the vehicle.”

In addressing your inquiries: 1. **Component or System Failure:** - The charging system of my vehicle malfunctioned at DC Fast Charger and all charging levels. This can be inspected upon request. 2. **Safety Implications:** - On January 2, 2024, charging issues at a DC fast station resulted in error messages, and on January 8th, I was stranded for 3 hours in cold weather with only 3 miles of range, posing a significant safety risk. 3. **Confirmation by Service Center:** - The issue has been documented with the dealership, but a comprehensive resolution is pending. 4. **Inspections by Others:** - The vehicle has not been inspected by the manufacturer, police, or insurance representatives at this point. 5. **Warning Signs:** - Error messages occurred on January 2, 2024, during a DC fast charge, and the severity of the issue became evident on January 8th, resulting in an extended charging time.

The motor inverter for the rear motor failed while I was driving. The power cut out, and luckily I was able to drift over to the side of the road. On a highway, it would have been very dangerous. The dealer diagnosed the inverter issue, and said it needs to be replaced. The car has not been inspected by the manufacturer, the police, or insurance representatives. A warning message appeared the moment the power cut out. It said, "Check electric vehicle system."