2024 Kia Carnival

My 2024 Kia Carnival smells strongly like gasoline after about 15–20 minutes of driving. The smell gets worse at idle, worse the longer I drive, and seems even stronger with the A/C on. Two dealerships in Las Vegas have told me this is “normal.” Meanwhile, I can’t park it in my garage because the smell fills my house. I’ve had headaches and nausea, and my kids have complained of headaches and stomach aches too.

On 8/25/2026 I dropped the vehicle at Plaza Kia, 2699 Nostrand Ave, Brooklyn, NY 11210 (Kia Repair Facility #7119189) for four open recalls: PI2501, PI2602, SC320, and SC368. Brakes were functioning normally at drop-off. Per repair order [XXX] dated 8/26/2026, only PI2501 and PI2602 (second-row seat recalls) were performed; SC320 (EGR valve) and SC368 (high-pressure crossover fuel pipe) were not completed — parts on special order. The dealer's multi-point inspection sheet, printed 8/26/2026 12:36 PM, marked brake fluid level/condition and brake system components as OK/green. The technician time log on the RO shows 0.0 actual hours for that day. The brake lining inspection panels on the sheet are blank. The dealer returned the vehicle to my residence via valet on 8/26/2026. On first use, the brake pedal was extremely hard and stiff with the engine running; the vehicle would only slow with full-force pedal pressure. I nearly collided with a parked vehicle exiting the parking space. I parked and did not drive it further. A vacuum-assist test (pump pedal engine off, hold, start engine) showed the pedal sinking only slightly, and braking under drive felt like engine-off braking — partial or total loss of power assist. Kia Roadside Assistance towed the vehicle to Plaza Kia. Plaza Kia refused to tow it themselves. Plaza Kia has since diagnosed a brake master cylinder failure and stated parts are approximately two weeks out. Repair is under warranty; updated RO pending. Kia Consumer Affairs case #[XXX] has been opened. Summary: brake power-assist failure on a 2024 Carnival at ~33,000 miles, occurring in dealer custody or immediately upon return from recall service, on the same day the dealer's inspection cleared the brake system. No prior brake symptoms. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The fuel pipe in my 2024 Kia Carnival has been identified by Kia as part of Safety Recall SC368 due to a fire risk. The component is available for inspection at the dealership where the vehicle is currently located. My safety and the safety of my family — including young children in car seats — was put at risk because the vehicle carries a known fire hazard related to the fuel pipe, yet no remedy is available until June 2026 at the earliest, according to Kia Customer Care. Kia confirmed the recall and the fire risk but has not provided adequate alternative transportation, leaving a family with young children without a safe vehicle for an extended period. The problem has been confirmed by Kia Customer Care, who verified that my vehicle is included in recall SC368. The dealership also confirmed the recall exists but stated the remedy is not yet available. However, when I contacted NHTSA by phone to file a complaint, the representative stated they could not find my vehicle in their recall database, directly contradicting Kia's confirmation. This discrepancy between Kia's internal records and NHTSA's database is concerning and may prevent other affected owners from being aware of the safety risk. The vehicle has been surrendered to the dealership via tow due to the fire risk. It has not yet been inspected or diagnosed by the dealership service department. I have requested written confirmation that the vehicle is safe to drive before accepting it back. I was notified via a CARFAX alert and the risk was identified/confirmed by the manufacturer.

The horn stops working when it’s cold and the horn installed does not match the amperage need for the vehicle. It has failed multiple times. I rarely use my horn. It failed for the first time around 20,000 miles. Separately, I have an oil leak that is also covered under warranty. This car has been serviced countless times and it has been in the shop for three weeks.

Horn stops working and needs to be replaced within a year or less. I reported the first time my horn stopped working and it took 4 months until I can have an appointment and order the part. The second time it stopped working was within a year and scheduling an appointment was difficult. I was almost in an accident and unable to use to both to alert the other driver.