2022 Kia Carnival

The contact owns a 2022 Kia Carnival. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 21V908000 (Latches/Locks/Linkages, Structure); however, the failure persisted. The contact stated that the rear passenger’s side power sliding door failed to latch securely. The contact used force while pushing the rear passenger’s side sliding door from the outside to latch the sliding door properly. The dealer was made aware of the failure and informed the contact that it was unrelated to the recall repair. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

Vehicle: 2022 Kia Carnival Component: Liftgate — right-side support/strut (shoulder) failure Safety Issue: The right-hand side trunk strut/support has completely broken, causing the liftgate to drop unexpectedly. The trunk will not stay open and can fall abruptly during use. This creates a significant safety hazard for adults and children standing underneath, and while loading/unloading cargo. There was no prior warning or misuse. The failure is structural and sudden. Resulting Risk: Risk of head/neck injury, especially for children or anyone attempting to open or hold the liftgate. The sudden drop makes the rear of the vehicle unsafe to use. Request: Investigation into whether this is a defect affecting other 2022 Kia Carnival vehicles.

The Kia Carnival was parked a slight decline and when the button to close the passenger sliding door the door closed rapidly like a guillotine. Thankfully no children or body part were in the path of the door because it would have severely damaged them. After it closed rapidly the door was unable to be opened. The dealership is still working on the Carnival and it has been over 3 weeks and they said they have never seen anything like this since it tore off a bolt in the body frame and caused damage to the body frame and they were unable to open it. Still don't have a timeline for repair. Also concerned it may happen to the other side and the safety issues around it.

The contact owns a 2022 Kia Carnival. The contact stated while driving 50 MPH, the driver's side windshield exterior A-Pillar trim flew off and struck the vehicle behind, almost causing a crash. The contact pulled over to the side of the road temporarily. The vehicle was taken back to the dealer, and the vehicle was inspected. The dealer determined that the trim needed to be replaced; however, the repair was not covered under the bumper-to-bumper warranty. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the dealer. The failure mileage was approximately 22,023.

The passenger side sliding door would not respond to any button pushed to open the door. Once I get it manually opened, it will not latch upon closure resulting in a beeping and warning in my dash. I can turn off power doors and manually force it to shut and most of the time that works but this specific incident it was not working. I ensured that there was nothing blocking the door from shutting and finally got it to shut and latch. I drove out of the location I was at and the sliding door flew open at about 20mph.

On [XXX], my kids were getting into the vehicle to go to a playdate. My [XXX] got in the car and into his seat. I was on the driver's side buckling my [XXX] in her car seat and my [XXX] was climbing into the door/her seat on the passenger side. The passenger side sliding door shut on my [XXX] 's hand. I immediately tried to open the door with the button next to the steering column and it would not respond. I then ran around to the other side of the car and used the button on the handle, but the door did not respond to open. I had to manually pull on the handle to force it open off of her hand. No fingers were broken, but the door was shut on her hand completely and she had bruising. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)