IllustrationIDLER SHAFT LEVER RETAINER CAME APART INSIDE ENGINE, CAUSED SPRING TO FAIL EARLY WHICH ALSO CAME APART INSIDE ENGINE. THIS IS A KNOWN PROBLEM WITH THESE MACHINES SO I DID A CHECK TO SEE AND DISCOVERED THIS. I FOUND ALL THE LITTLE PIECES READY TO BE SUCKED UP INTO THE OIL PUMP WHICH WOULD HAVE CAUSED THE ENGINE TO SEIZE. *JB
2001 Kawasaki KLR650
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all KLR650 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 13 of 19 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
19 reportsI HAVE NOTICED RATTLE IN ENGINE ALMOST SINCE NEW. AT 21000 MILES I OPENED UP THE L SIDE ENGINE CASE. THERE WAS A BROKEN ENGINE BALANCER CHAIN ADJUSTER AND MANY CHUNKS OF METAL IN CRANKCASE. I CHECKED THE INTERNET AND APPARENTLY THIS IS VERY COMMON. I BELIEVE THIS FAILURE COULD CAUSE A REAL WHEEL LOCKUP/SEIZED ENGINE AND CON…
Read full complaint
I HAVE NOTICED RATTLE IN ENGINE ALMOST SINCE NEW. AT 21000 MILES I OPENED UP THE L SIDE ENGINE CASE. THERE WAS A BROKEN ENGINE BALANCER CHAIN ADJUSTER AND MANY CHUNKS OF METAL IN CRANKCASE. I CHECKED THE INTERNET AND APPARENTLY THIS IS VERY COMMON. I BELIEVE THIS FAILURE COULD CAUSE A REAL WHEEL LOCKUP/SEIZED ENGINE AND CONSEQUENT LOSS OF CONTROL WITH DEVISTATING CONSEQUENCES. BOTH MY DEALER AND KAWASAKI USA INDICATE THEY HAVE NEVER HEARD OF SUCH A PROBLEM. THIS IS A WELL KNOWN DEFECT IN ALL KLR650'S BUILT SINCE 1986!*AK
COUNTER BALANCER ADJUSTER FAILURE. *NLM
BROKEN BALANCER CHAIN TENSIONER ON A 2001 KAWASAKI KLR650 MOTORCYCLE.
FAILURE OF COUNTERBALANCE ADJUSTER. PART SHATTERED INTO THREE PIECES. ONE PIECE LOST IN CRANKCASE, REQUIRING FURTHER DIASSAMBLY OF ENGINE TO RECOVER
BALANCER IDLER SHAFT, TENSIONER LEVER FAILURE ON A 2001 KAWASAKI KLR 650 MOTORCYCLE, RESULTING IN PIECES OF STEEL ENTERING OIL SUMP, CRANKCASE AND TRANSMISSION OF ENGINE.
KAWASAKI KLR650 BALANCER TENSIONER AND CAM SPRING ON MOTORCYCLE LESS THAN ONE YEAR OLD WITH LOW MILEAGE. AFTER READING OF SIMILAR FAILURES IN OTHER MOTORCYCLES SOME OF WHICH REPORTEDLY RESULTED IN INJURY, I DECIDED TO OPEN THE ENGINE HOUSING TO INVESTIGATE. BOTH COMPONENTS HAD SHATTERED RESULTING IN METALIC FRAGMENTATION RESIDUE…
Read full complaint
KAWASAKI KLR650 BALANCER TENSIONER AND CAM SPRING ON MOTORCYCLE LESS THAN ONE YEAR OLD WITH LOW MILEAGE. AFTER READING OF SIMILAR FAILURES IN OTHER MOTORCYCLES SOME OF WHICH REPORTEDLY RESULTED IN INJURY, I DECIDED TO OPEN THE ENGINE HOUSING TO INVESTIGATE. BOTH COMPONENTS HAD SHATTERED RESULTING IN METALIC FRAGMENTATION RESIDUE DRAWN INTO THE OIL PUMP MECHANISM (BUT STOPPED BY OIL PUMP METALIC SCREENING).
CONSUMER HAD NOTICED THE SWING ARM BOLTS HAD BEEN COMING APART FROM MOTORCYCLE FRAME, WHICH WAS ATTACHED TO SUSPENSION, AND COULD CAUSE DRIVER TO LOSE CONTROL OF MOTORCYCLE. DEALER HAD BEEN CONTACTED. *AK CONSUMER STATED THAT THE PIVOT SHAFT BOLTS WITH COTTER PINS HAVE BEEN REFITTED SO THEY WILL NOT COME APART FROM MOTORCYCLE…
Read full complaint
CONSUMER HAD NOTICED THE SWING ARM BOLTS HAD BEEN COMING APART FROM MOTORCYCLE FRAME, WHICH WAS ATTACHED TO SUSPENSION, AND COULD CAUSE DRIVER TO LOSE CONTROL OF MOTORCYCLE. DEALER HAD BEEN CONTACTED. *AK CONSUMER STATED THAT THE PIVOT SHAFT BOLTS WITH COTTER PINS HAVE BEEN REFITTED SO THEY WILL NOT COME APART FROM MOTORCYCLE.*YD
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED TO BE AN UNDERSIZED BUSHING IN …
Read full complaint
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED TO BE AN UNDERSIZED BUSHING IN THE CLUTCH HUB. THE DEALER CHOSE TO REPLACE THE MOTORCYCLE SINCE IT WAS DEFECTIVE. *YH
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.