IllustrationMOTORCYCLE TURN SIGNALS (REAR) BREAK AND FALL TO HANG BY THE WIRES. *TR
2008 Kawasaki KL650E
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all KL650E years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 10 of 12 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Exterior Lighting complaints
7 reports1. THREE (3) TURN SIGNAL MOUNTS HAVE FAILED TO DATE, DURING NORMAL VEHICLE OPERATION. 2. FAILURES OCCURRED AT 1,800 MILES, 4,000 MILES, AND 7,300 MILES ON THE ODOMETER. MOUNTS FAIL IN NORMAL HIGHWAY OPERATION, LEADING TO TURN SIGNAL BULB/LENS/HALF-STALK DANGLING FROM THE WIRING. NO ACCIDENTS OCCURRED DUE TO THE FAILURES. 3…
Read full complaint
1. THREE (3) TURN SIGNAL MOUNTS HAVE FAILED TO DATE, DURING NORMAL VEHICLE OPERATION. 2. FAILURES OCCURRED AT 1,800 MILES, 4,000 MILES, AND 7,300 MILES ON THE ODOMETER. MOUNTS FAIL IN NORMAL HIGHWAY OPERATION, LEADING TO TURN SIGNAL BULB/LENS/HALF-STALK DANGLING FROM THE WIRING. NO ACCIDENTS OCCURRED DUE TO THE FAILURES. 3. FIRST ONE REPLACE AT CONSUMER'S EXPENSE, SECOND REPLACED AT DEALERS EXPENSE, THIRD BEING DEBATED BY DEALER. THIRD UNIT STILL IN OWNER'S POSSESSION. *TR
TURN SIGNALS FALLING OFF NEWLY PURCHASED KAWASAKI KLR-650 MOTORCYCLE. RUBBER MOUNT IS THIN AND HAS BEEN REPORTED TO BREAK AT THE WEB SITE KLR WORLD .COM. *TR
MY LEFT REAR TURN SIGNAL FELL OFF THIS TIME. (MY SECOND COMPLAINT). I WAS ACTUALLY RETURNING FROM THE KAWASAKI DEALERSHIP HAVING MY RIGHT REAR TURN SIGNAL REPAIRED WHEN THE LEFT TURN SIGNAL JUST FELL OFF AND STARTED FLOPPING IN THE WIND. I HAD TO TRAVEL 40+ MILES WITH NO TURN SIGNALS AFTER JUST LEAVING THE DEALERSHIP. KLR OWNER…
Read full complaint
MY LEFT REAR TURN SIGNAL FELL OFF THIS TIME. (MY SECOND COMPLAINT). I WAS ACTUALLY RETURNING FROM THE KAWASAKI DEALERSHIP HAVING MY RIGHT REAR TURN SIGNAL REPAIRED WHEN THE LEFT TURN SIGNAL JUST FELL OFF AND STARTED FLOPPING IN THE WIND. I HAD TO TRAVEL 40+ MILES WITH NO TURN SIGNALS AFTER JUST LEAVING THE DEALERSHIP. KLR OWNERS NOW RESORT TO PURCHASING AFTERMARKET TURN SIGNALS TO FIX THE PROBLEM THAT KAWASAKI HAS IGNORED. *TR
RIGHT REAR SIGNAL LIGHT FELL OFF OF MY MOTORCYCLE. UPON FURTHER INSPECTION AND CONSULTING WITH OTHER OWNERS OF THE SAME MOTORCYCLE I REALIZED THAT THIS IS NOT AN ISOLATED INCIDENT. I HAD NO DAMAGE TO MY BIKE, NO COLLISIONS, ETC. THE SIGNAL LIGHT RUBBER AND MOUNTING POINT ARE WEAK, CAUSING THEM TO COLLAPSE WITH NO WARNING, LEAVI…
Read full complaint
RIGHT REAR SIGNAL LIGHT FELL OFF OF MY MOTORCYCLE. UPON FURTHER INSPECTION AND CONSULTING WITH OTHER OWNERS OF THE SAME MOTORCYCLE I REALIZED THAT THIS IS NOT AN ISOLATED INCIDENT. I HAD NO DAMAGE TO MY BIKE, NO COLLISIONS, ETC. THE SIGNAL LIGHT RUBBER AND MOUNTING POINT ARE WEAK, CAUSING THEM TO COLLAPSE WITH NO WARNING, LEAVING THE RIDER WITHOUT SIGNAL LIGHTS. *TR
2008 KAWASAKI KLR650 MOTORCYCLE. 3 MONTHS OLD WITH 1800 MILES. RIGHT REAR TURN SIGNAL FELL OFF. LEFT REAR TURN SIGNAL IS CRACKED AND WILL FALL OFF SHORTLY. DEALER WILL REPLACE, PARTS ON ORDER BUT NOT REPLACED YET. I HAVE THE TURN SIGNAL DUCT TAPED ON AND WILL PUT DUCT TAPE ON THE LEFT AS WELL. I FEEL THIS IS DANGEROUS AS THEY FA…
Read full complaint
2008 KAWASAKI KLR650 MOTORCYCLE. 3 MONTHS OLD WITH 1800 MILES. RIGHT REAR TURN SIGNAL FELL OFF. LEFT REAR TURN SIGNAL IS CRACKED AND WILL FALL OFF SHORTLY. DEALER WILL REPLACE, PARTS ON ORDER BUT NOT REPLACED YET. I HAVE THE TURN SIGNAL DUCT TAPED ON AND WILL PUT DUCT TAPE ON THE LEFT AS WELL. I FEEL THIS IS DANGEROUS AS THEY FALL OFF UNEXPECTEDLY WITHOUT ABUSE. THE RUBBER DETERIORATES QUICKLY. AN INTERNET SEARCH WILL EXPOSE JUST HOW COMMON THIS IS AND THE TURN SIGNAL SEEMS TO BE REPLACED WITH THE SAME ONE THAT FAILS QUICKLY. IT'S AN ALMOST 200 MILE ROUND TRIP TO THE DEALER AND THIS HAS TO BE DONE 2 TIMES EACH TIME TO INSPECT AND ORDER THE PART AND AGAIN TO REPLACE THE PART. I THINK THERE IS A SAFETY ISSUE WITH THESE TURN SIGNALS AND KAWASAKI SHOULD RECALL THESE AND REPLACE THEM WITH SOMETHING MORE DURABLE! *TR
THE REAR TURN SIGNALS FELL OFF. THE RUBBER THAT HOLDS THEM IS INFERIOR AND CRACKS CAUSING THE SIGNALS TO FALL OFF. *TR
Official recalls
309V062000 · Electrical System:wiring
Feb 20, 2009
KAWASAKI IS RECALLING 16,167 MY 2008-2009 KLR 650 (KL650E8F/L, KL650E9F/L) MOTORCYCLES. WIRES IN THE WIRING HARNESS MIGHT BE DAMAGED DUE TO RUBBING CONTACT WITH A PORTION OF THE MOTORCYCLE FRAME.
Consequence & remedy
Consequence: THIS COULD RESULT IN LOSS OF ELECTRICAL POWER TO THE ENGINE CREATING A RISK OF A CRASH RESULTING IN INJURY OR DEATH.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE MAIN WIRING HARNESS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 24, 2009. OWNERS MAY CONTACT KAWASAKI AT 866-802-9381.
09V059000 · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Feb 19, 2009
KAWASAKI IS RECALLING 16,167 MY 2008-2009 KLR 650 (KL650E8F/L, KL650E9F/L) MOTORCYCLES. THE MUFFLER ASSEMBLY IS SECURED TO THE FRAME OF THE MOTORCYCLE BY TWO BOLTS. IT IS POSSIBLE THAT HEAT EXPANSION CYCLES OF THE MUFFLER, COMBINED WITH VIBRATION FROM VEHICLE OPERATION MAY CAUSE LOOSENING OF THE MUFFLER MOUNTING BOLTS.
Consequence & remedy
Consequence: IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE, CREATING A RISK OF A CRASH RESULTING IN INJURY OR DEATH.
Remedy: DEALERS WILL REMOVE THE PAINT FROM THE MUFFLER MOUNT TABS AND REPLACE THE MOUNT BOLTS, NUT, AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT KAWASAKI AT 866-802-9381.
07V486000 · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 16, 2007
ON CERTAIN MOTORCYCLES, INSUFFICIENT TIGHTENING OF THE MUFFLER MOUNTING BOLTS COULD ALLOW THE BOLTS TO LOOSEN.
Consequence & remedy
Consequence: IF THE BOLTS LOOSEN COMPLETELY, IT IS POSSIBLE FOR THE MUFFLER TO SEPARATE FROM THE MOTORCYCLE AND CREATE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL TIGHTEN TWO MUFFLER MOUNTING BOLTS TO THE PROPER TORQUE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.