IllustrationEVERY TIME FILLING THE JEEP WITH FUEL WHEN THE GAS PUMP KICKS OFF FUEL SPILLS OR SHOULD I SAY BLOWS BACK OUT OF THE FILLER NECK COVERING WHO EVER IS FUELING VEHICLE AS WELL AS THE SIDE OF VEHICLE AND THE GROUND. *TR
2009 Jeep Wrangler 4-DR 4X4
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler 4-DR 4X4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
5125–50K
2650–75K
1975–100K
14100–150K
2150K+
151 reports with mileage · 14 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports3 fire reports3 injury reports
What owners actually said
165 reportsI WAS DRIVING THE JEEP DOWN THE HIGHWAY THROUGH CONSTRUCTION ZONE AND IT VIBRATED VIOLENTLY AFTER I DROVE OVER A BUMP. I HAD TO SLOW DOWN VERY QUICKLY DURING RUSH HOUR AND WAS ALMOST HIT IN THE REAR BY ANOTHER CARE SO THE WOBBLE WOULD GO AWAY. I TOOK IT TO HAVE IT FIXED AND WAS TOLD THIS IS COMMON. I LOOKED IT UP ONLINE AND W…
Read full complaint
I WAS DRIVING THE JEEP DOWN THE HIGHWAY THROUGH CONSTRUCTION ZONE AND IT VIBRATED VIOLENTLY AFTER I DROVE OVER A BUMP. I HAD TO SLOW DOWN VERY QUICKLY DURING RUSH HOUR AND WAS ALMOST HIT IN THE REAR BY ANOTHER CARE SO THE WOBBLE WOULD GO AWAY. I TOOK IT TO HAVE IT FIXED AND WAS TOLD THIS IS COMMON. I LOOKED IT UP ONLINE AND WAS AMAZED. FOR A NEWER VEHICLE I WAS FLOORED THAT IT WAS NOT COVERED BY JEEP. I HAVE AN EXTENDED WARRANTY TOO. I TOOK IT TO JEEP AND THEY TOLD ME I HAD TO PAY TO FIX IT, SO WHAT WAS I GOING TO DO DRIVE AND UNSAFE CAR (AND IT IS UNSAFE, ANOTHER CAR ALMOST HIT ME). I PAID TO HAVE IT FIXED. THEY REPLACED A DAMPER AND GUESS WHAT THERE IS STILL A WOBBLE. THIS IS THE MOST RIDICULOUS ISSUE AND YET JEEP WILL NOT STAND BEHIND A POOR DESIGN THAT THEY CLEARLY KNOW IS A PROBLEM. SO, I AM LOOKING FOR HELP MAKING IT KNOW THAT IF THERE IS AN ACCIDENT INVOLVING THIS PROBLEM I HAVE ADVISED JEEP AND NOW NHTSA. I WILL SURELY CONTACT AN ATTORNEY AND BECOME VERY PUBLIC THAT THERE HAS BEEN WARNING OF THIS. ALL I WANT IS FOR MY WIFE AND KIDS TO BE SAFE IN A CAR. JEEP SHOULD STEP UP AND CORRECT THERE PROBLEM. *TR
DRIVING ON THE HIGHWAY AND THE VEHICLE STARTED TO SHAKE UNCONTROLLABLY. YOU HAVE TO SLOW DOWN TO A DANGEROUS SPEED IF YOU CANT PULL OVER RIGHT AWAY TO STOP. THE CAR SHAKES AS IF IT IS FALLING APART. THIS HAS HAPPENED ON SEVERAL OCCASIONS AND WE BROUGHT IT TO OUR MECHANIC. THEY INFORMED US THAT IT WAS THE STEERING DAMPENER AN…
Read full complaint
DRIVING ON THE HIGHWAY AND THE VEHICLE STARTED TO SHAKE UNCONTROLLABLY. YOU HAVE TO SLOW DOWN TO A DANGEROUS SPEED IF YOU CANT PULL OVER RIGHT AWAY TO STOP. THE CAR SHAKES AS IF IT IS FALLING APART. THIS HAS HAPPENED ON SEVERAL OCCASIONS AND WE BROUGHT IT TO OUR MECHANIC. THEY INFORMED US THAT IT WAS THE STEERING DAMPENER AND IT NEEDED TO BE REPLACED AND THAT IT IS HAPPENING TO JEEPS ALL OVER AND THAT CHRYSLER IS NOT COVERING REPAIRS. AFTER MY MECHANIC FIXED THE STEERING DAMPENER, THEY TEST DROVE IT AND FOUND THE SHAKE TO STILL BE THERE AND DID FURTHER INVESTIGATING. THEY FOUND THAT MOST OF THE PARTS IN THE STEERING SYSTEM WERE DAMAGED, IE. TIE RODS AND STEERING DRAG LINK. I AM BRINGING THE VEHICLE TO MY JEEP DEALER AND HAVE INFORMED CHRYSLER OF THE SITUATION. I AM HOPING THAT THEY WILL REPLACE THE BAD PARTS BUT DO NOT HAVE A GOOD FEELING. *TR
DRIVING DOWN A 2 LANE ROAD AT 55 MPH I HIT A BUMP ON A SMALL BRIDGE. THE VEHICLE STARTED SHAKING VIOLENTLY AND MOVED INTO THE ONCOMING TRAFFICS LANE AND ALMOST OFF THE ROAD. THE VEHICLE WAS DIFFICULT TO STOP DUE THE FRONT TIRES SHAKING SO BAD. IT HAS HAPPENED AT LEAST 5 MORE TIMES AT HIGHER SPEEDS (65-75 MPH) AND USUALLY ON SMAL…
Read full complaint
DRIVING DOWN A 2 LANE ROAD AT 55 MPH I HIT A BUMP ON A SMALL BRIDGE. THE VEHICLE STARTED SHAKING VIOLENTLY AND MOVED INTO THE ONCOMING TRAFFICS LANE AND ALMOST OFF THE ROAD. THE VEHICLE WAS DIFFICULT TO STOP DUE THE FRONT TIRES SHAKING SO BAD. IT HAS HAPPENED AT LEAST 5 MORE TIMES AT HIGHER SPEEDS (65-75 MPH) AND USUALLY ON SMALL BRIDGES WHERE THE PAVEMENT IS SLIGHTLY UNEVEN AND ON THE HIGHWAY WHEN I HIT A LARGE POT HOLE. I HAVE REPLACED THE FRONT TRACK BAR, STEERING DAMPER, UPPER AND LOWER CONTROL ARMS, TIE ROD ENDS, AND DRAG LINK MOSTLY WITH UPGRADED PARTS IN AN ATTEMPT TO STOP IT BUT IT CONTINUES TO HAPPEN. IT HAS ALSO BEEN ALIGNED 4 TIMES AT 2 DIFFERENT SHOPS AND THIS DOES NOT HELP. WHEN THIS HAPPENS TRAFFIC ON THE HIGHWAY MOVES TO GET AWAY FROM VEHICLE. WITH ALL NEW PARTS THIS IS DEFINITELY A DEFECT IN DESIGN BY JEEP. IF NOTHING IS DONE BY JEEP SOMEONE IS GOING TO GET HURT OR KILLED DUE TO THIS PROBLEM. *TR
DURING A ROUTINE WHEEL ROTATION, I WAS ALERTED TO ALL 4 OF THE NUTS THAT SECURE THE TIRE PRESSURE MONITORS (AND THE VALVE STEMS) BEING CRACKED ALONG THEIR LENGTHS. IF ONLY ONE HAD BEEN CRACKED, I WOULD CONSIDER IT ODD, BUT ALL 4 MEANS AN OBVIOUS AND EXTREMELY DANGEROUS DEFECT. WHEN (NOT IF) ONE FELL ONE FELL OFF, IT WOULD LEAD…
Read full complaint
DURING A ROUTINE WHEEL ROTATION, I WAS ALERTED TO ALL 4 OF THE NUTS THAT SECURE THE TIRE PRESSURE MONITORS (AND THE VALVE STEMS) BEING CRACKED ALONG THEIR LENGTHS. IF ONLY ONE HAD BEEN CRACKED, I WOULD CONSIDER IT ODD, BUT ALL 4 MEANS AN OBVIOUS AND EXTREMELY DANGEROUS DEFECT. WHEN (NOT IF) ONE FELL ONE FELL OFF, IT WOULD LEAD TO A SUDDEN LOSS OF AIR PRESSURE AND, VERY LIKELY, AN ACCIDENT. THIS IS A LOW MILEAGE VEHICLE THAT HAS HAD NO ABUSE, DAMAGE, OR ACCIDENTS THAT MIGHT HAVE CAUSED THE CRACKS TO OCCUR. *TR
TL* THE CONTACT OWNS A 2009 JEEP WRANGLER 4X4. THE CONTACT STATED THAT WHILE STOPPED AT A TRAFFIC LIGHT, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE ENGINE NEEDED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY STATED THAT THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2009 JEEP WRANGLER 4X4. THE CONTACT STATED THAT WHILE STOPPED AT A TRAFFIC LIGHT, THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THE ENGINE NEEDED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY STATED THAT THE VEHICLE WAS NOT UNDER RECALL. THE FAILURE AND THE CURRENT MILEAGE WAS 32,000. THE VIN WAS NOT AVAILABLE. UPDATED 8/23/12 *CN
CLOCK SPRING FAILED. *TR
ABOUT 4 MONTHS AGO I WAS FILLING UP AT PUMP AND THE AUTO-SHUT OFF DID NOT WORK CAUSING GAS TO GUSH OUT ALL OVER MY JEEP AND THE GROUND. TRIED SEVERAL GAS STATIONS AND IT CONTINUED TO HAPPEN. TOOK JEEP TO DEALER AND THEY WERE AWARE OF THE ISSUE - SAID IT WAS NOT A RECALL, THAT THEY HAD TO REPLACE THE FUEL TANK, O-RING, FUEL PUM…
Read full complaint
ABOUT 4 MONTHS AGO I WAS FILLING UP AT PUMP AND THE AUTO-SHUT OFF DID NOT WORK CAUSING GAS TO GUSH OUT ALL OVER MY JEEP AND THE GROUND. TRIED SEVERAL GAS STATIONS AND IT CONTINUED TO HAPPEN. TOOK JEEP TO DEALER AND THEY WERE AWARE OF THE ISSUE - SAID IT WAS NOT A RECALL, THAT THEY HAD TO REPLACE THE FUEL TANK, O-RING, FUEL PUMP AND LEVEL UNIT. LUCKILY I HAVE A WARRANTY, HOWEVER, I DID HAVE TO PAY A $100 DEDUCTIBLE. MY HUSBAND WAS RESEARCHING AND SAW THAT THIS IS AN EMISSIONS ISSUE AND READ THAT THE MANUFACTURER IS RESPONSIBLE FOR ANY EMISSION ISSUES DUE TO DEFECTIVE PARTS. I SEE SEVERAL PEOPLE HAVE MADE THE SAME CLAIM AS I AND I DO HOPE THAT SOMEONE LOOKS INTO THIS ISSUE WITH CHRYSLER/DODGE. I DO NOT FEEL I SHOULD HAVE HAD TO PAY A DEDUCTIBLE - THIS SOUNDS LIKE AN ISSUE WHERE IF IT HAPPENS, CHRYSLER/DODGE SHOULD BE COVERING THE WORK/PARTS. *JS
VIOLENT FRONT WHEELS WOBBLE AFTER HITTING A BUMP ON A ROAD. *TR
TL* THE CONTACT OWNS A 2009 JEEP WRANGLER 4-DR 4X4. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DROVE OVER AN UNEVEN ROAD SURFACE AND NOTICED THAT THE FRONT END OF THE VEHICLE SUDDENLY BEGAN TO WOBBLE ABNORMALLY. THE STEERING BECAME DIFFICULT TO MANEUVER AND BECAME UNCONTROLLABLE UNTIL THE CONTACT DECREASED SPEED TO APPROXIM…
Read full complaint
TL* THE CONTACT OWNS A 2009 JEEP WRANGLER 4-DR 4X4. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT DROVE OVER AN UNEVEN ROAD SURFACE AND NOTICED THAT THE FRONT END OF THE VEHICLE SUDDENLY BEGAN TO WOBBLE ABNORMALLY. THE STEERING BECAME DIFFICULT TO MANEUVER AND BECAME UNCONTROLLABLE UNTIL THE CONTACT DECREASED SPEED TO APPROXIMATELY 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TWICE FOR DIAGNOSTIC TESTING. THE TECHNICIANS WERE UNABLE TO DIAGNOSE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
Official recalls
109V118000 · Air Bags; Air Bags:frontal; Electrical System:wiring
Apr 9, 2009
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Electrical System:wiring
CHRYSLER IS RECALLING 4,314 MY 2009 DODGE JOURNEY, JEEP GRAND CHEROKEE, COMMANDER AND WRANGLER VEHICLES. WIRING MAY BE REVERSED ON THE STEERING COLUMN CONTROL MODULE DRIVER AIRBAG SQUIB CONNECTOR. THE DRIVER'S AIRBAG MAY NOT DEPLOY AS INTENDED.
Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S AIRBAG MAY NOT PROPERLY INFLATE AND MAY NOT BE ABLE TO PROPERLY PROTECT AN OCCUPANT, INCREASING THE RISK OF INJURIES.
Remedy: DEALERS WILL INSPECT THE DRIVER'S AIRBAG SQUIB WIRES AND REPLACE THE STEERING COLUMN CONTROL MODULE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA15007 · Air Bag Clockspring Wiring Failure
Opened Dec 4, 2015 · Closed Jul 6, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.
Additional source detail variants (4)
Air Bags
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.
Air Bags
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.
Air Bags:frontal
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.
Air Bags:frontal
On May 10, 2016, Fiat Chrysler America (FCA) submitted a Part 573 Defect Information Report announcing NHTSA recall 16V290 involving 394,258 model year (MY) 2007-2010 Jeep Wrangler vehicles.Under the recall FCA will replace the clockspring and install a steering wheel back cover and steering wheel column shroud.This recall also includes approx. 4,524 MY2007-2010 right hand drive (RHD) Jeep Wrangler vehicles commonly used for rural postal delivery services.In addition 7,180 MY 2011-2016 right hand drive Jeep Wrangler vehicles were also recalled under 16V288, the same remedy repair will be used.Upon review of the 1,942 MY 2007-2010 Jeep Wrangler consumer complaints, 17,195 warranty reports and field returned parts assessment, FCA concluded that a defect exists in the driver side clockspring assembly, a device that both connects (electrically) the driver air bag to the control module and allows rotational movement between the steering wheel and fixed steering column.Clockspring failure may compromise the air bag circuit causing illumination of the air bag warning lamp, and may result in non-deployment of the driver air bag in a frontal crash.FCA identified a contributing factor in that the recalled vehicles may be subjected to off-road dusty environments and/or usage with the vehicle roof top/doors removed thus allowing dust and moisture to enter the clockspring assembly.FCA advised that the MY 2011 and later Wrangler vehicles had an improved steering column cover/shroud that may reduce the amount of dirt/moisture that can enter the clockspring assembly.During the investigation FCA and the Office of Defects Investigation (ODI) also reviewed 193 MY 2011-2012 Jeep Wrangler consumer complaints, 3,918 warranty reports and field returned parts along with reports from other FCA vehicles that use the same clockspring assembly.Based on this review, the rate of repair and the failure mode does not indicate a defect trend at this time in the later MY Wrangler or other FCA vehicles.During the field return parts review, FCA found a significant number of MY 2011-2012 Wrangler returned parts that operated normally, the so called ?no trouble found? or NTF parts where no fault could be identified through bench testing.On June 10, 2016, FCA informed ODI of its intention to conduct a 15-yr, 150k mile extended warranty program due to the NTF issue and the MY 2011 and later vehicles having a somewhat elevated level of warranty replacement.Consumers will be notified of the program in writing.FCA will collect clocksprings replaced under the warranty extension program to further examine and study the root cause failure.ODI will monitor FCA?s analysis to determine if any further field action is warranted.Based on the actions taken by FCA to recall the MY 2007-2010 Jeep Wrangler vehicles and the MY 2008-2016 right hand drive Wrangler vehicles, this investigation is closed.FCA has also agreed to conduct a warranty extension and further evaluation of the MY 2011-2016 Wrangler.At the time of FCA's field data submission in PE 15-025 (September 2015), ODI was aware of a total of 416 MY 2007-2010 and 23 MY 2011-2012 VOQs relevant to this issue.In addition, there have been an additional 90 and 16 VOQs (respectively) received since the recall announcement (i.e., thru May 2016).The reports noted above can be viewed at SaferCar.gov under the reference (ODI) numbers cited on the attached listing.
PE15025 · Air Bag Clockspring Wiring Failure
Opened Jun 19, 2015 · Closed Dec 7, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal
In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the air bag warning light was allegedly on or came on afterward the crash, one of which also alleged injuries as a result of the non-deployment.FCA also provided data on other make, model and model year vehicles using the same clockspring.Additionally FCA provided 16,955 warranty claims related to the replacement of the air bag clockspring wiring assembly.It should be noted that FCA initiated an Extended Warranty Program on the left hand drive MY 2007 Wrangler in late calendar year 2011.6,777 of these claims are from the MY 2007 left hand drive Wrangler.FCA advises that some of the warranty claims involved clockspring failures that would not affect the air bag operation, for example due to noise, cruise control and/or radio operation issues.Many of these claims involved newer model year subject vehicles.FCA also noted that Wrangler's removable roof and door configuration may make it more susceptible to outdoor water/moisture and dust ingress.ODI investigated the right hand drive Wrangler in calender year 2011 for a similar clockspring issue under PE11-019.That investigation lead to NHTSA Safety Recall 11V258 on right hand drive model year (MY) 2008-2012 Wranglers.FCA redesigned the remedy clockspring to improve its durability and environmental protection and revised the design of the steering wheel to column shroud.Base on the data reviewed, this Preliminary Analysis (PE) is being upgraded to an Engineering Analysis (EA).The reports cited above are listed in the public investigative file available at SaferCar.gov under this investigation ID.
Additional source detail variants (2)
Air Bags
In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the air bag warning light was allegedly on or came on afterward the crash, one of which also alleged injuries as a result of the non-deployment.FCA also provided data on other make, model and model year vehicles using the same clockspring.Additionally FCA provided 16,955 warranty claims related to the replacement of the air bag clockspring wiring assembly.It should be noted that FCA initiated an Extended Warranty Program on the left hand drive MY 2007 Wrangler in late calendar year 2011.6,777 of these claims are from the MY 2007 left hand drive Wrangler.FCA advises that some of the warranty claims involved clockspring failures that would not affect the air bag operation, for example due to noise, cruise control and/or radio operation issues.Many of these claims involved newer model year subject vehicles.FCA also noted that Wrangler's removable roof and door configuration may make it more susceptible to outdoor water/moisture and dust ingress.ODI investigated the right hand drive Wrangler in calender year 2011 for a similar clockspring issue under PE11-019.That investigation lead to NHTSA Safety Recall 11V258 on right hand drive model year (MY) 2008-2012 Wranglers.FCA redesigned the remedy clockspring to improve its durability and environmental protection and revised the design of the steering wheel to column shroud.Base on the data reviewed, this Preliminary Analysis (PE) is being upgraded to an Engineering Analysis (EA).The reports cited above are listed in the public investigative file available at SaferCar.gov under this investigation ID.
Air Bags:frontal
In it's response to ODI's PE15-025 Information Request letter, FCA identified 1,703 consumer complaints, field reports and legal claims responsive to the subject defect condition on the subject Wrangler vehicles.Six of these reports alleged an air bag non-deployment in a crash in which either the air bag warning light was allegedly on or came on afterward the crash, one of which also alleged injuries as a result of the non-deployment.FCA also provided data on other make, model and model year vehicles using the same clockspring.Additionally FCA provided 16,955 warranty claims related to the replacement of the air bag clockspring wiring assembly.It should be noted that FCA initiated an Extended Warranty Program on the left hand drive MY 2007 Wrangler in late calendar year 2011.6,777 of these claims are from the MY 2007 left hand drive Wrangler.FCA advises that some of the warranty claims involved clockspring failures that would not affect the air bag operation, for example due to noise, cruise control and/or radio operation issues.Many of these claims involved newer model year subject vehicles.FCA also noted that Wrangler's removable roof and door configuration may make it more susceptible to outdoor water/moisture and dust ingress.ODI investigated the right hand drive Wrangler in calender year 2011 for a similar clockspring issue under PE11-019.That investigation lead to NHTSA Safety Recall 11V258 on right hand drive model year (MY) 2008-2012 Wranglers.FCA redesigned the remedy clockspring to improve its durability and environmental protection and revised the design of the steering wheel to column shroud.Base on the data reviewed, this Preliminary Analysis (PE) is being upgraded to an Engineering Analysis (EA).The reports cited above are listed in the public investigative file available at SaferCar.gov under this investigation ID.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den