IllustrationMY CAR IS NOT STARTING. THIS IS THE THIRD TIME THIS YEAR THAT I HAD TO BRING IT IN TO THE DEALERSHIP. THE RED BOLT GOES ON LAST TWO TIMES AND I WAS ON THE ROAD DRIVING AND IT SLOWED DOWN. THIS TIME IT WON'T WORK. I TOOK IT TO DEALERSHIP TWICE ALREADY AND IT'S LESS THAN TWO MONTHS APART. THIRD TIME HAPPENING NOW.
2014 Jeep Patriot
Owner reports · Recalls · Investigations
More warning signs than most Patriot years
Owner complaints for the 2014 Jeep Patriot are substantially higher than the model-year median of 188.
About this comparison →How this year compares
Owner complaints by model year
Compare all Patriot years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1000–25K
7325–50K
9550–75K
7075–100K
28100–150K
8150K+
374 reports with mileage · 174 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 156 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 149 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports7 fire reports32 injury reports
Electrical System complaints
89 reportsTL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE LOST POWER AND DECELERATED TO APPROXIMATELY 1 MPH. THE CONTACT STATED THAT THE LIGHTNING BOLT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC…
Read full complaint
TL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE LOST POWER AND DECELERATED TO APPROXIMATELY 1 MPH. THE CONTACT STATED THAT THE LIGHTNING BOLT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000.
TOTAL CONTROL POWER MODULE (TIPM) FAILURE. WHILE DRIVING DOWN THE ROAD JEEP PATRIOTS LIGHTS STARTED FLICKERING, THE MOST OF THE DASH LIGHTS CAME ON. WHEN PULLING OVER THE VEHICLE STALLED AND LOST ASSISTED BRAKING AND POWER STEERING. ONCE STOPPED TURNED THE KEY OFF AND REGAINED COMPOSURE. AFTER IT SAT FOR A FEW SECOND THE JEEP ST…
Read full complaint
TOTAL CONTROL POWER MODULE (TIPM) FAILURE. WHILE DRIVING DOWN THE ROAD JEEP PATRIOTS LIGHTS STARTED FLICKERING, THE MOST OF THE DASH LIGHTS CAME ON. WHEN PULLING OVER THE VEHICLE STALLED AND LOST ASSISTED BRAKING AND POWER STEERING. ONCE STOPPED TURNED THE KEY OFF AND REGAINED COMPOSURE. AFTER IT SAT FOR A FEW SECOND THE JEEP STARTED RIGHT BACK UP AND WAS FINE. TOOK THE JEEP TO A LOCAL STORE TO HAVE THE STARTING AND CHARGING SYSTEM CHECKED AND WAS TOLD THAT EVERYTHING WAS OPERATING WITHIN NORMAL PARAMETERS. SINCE THEN WE HAVE HAD MULTIPLE REPEAT OCCURRENCES AND NOW THE JEEP HAS TO BE JUMP STARTED IF YOU WANT IT TO RUN. THE JEEP WAS DIAGNOSED WITH A BAD TIPM TOTAL INTEGRATED POWER UNIT. THIS IS VERY DANGEROUS SITUATION AND THUS MY VEHICLE IS NOW PARKED. THIS IS THE FIRST JEEP THAT I HAVE OWNED BUT DO NOT THINK THEIR WILL BE ANOTHER BEINGS THAT DODGE IS NOT WANTING TO CLAIM RESPONSIBILITY AND CORRECT THIS DANGEROUS SITUATION
THE VEHICLE STARTS TO REV UP REALLY HIGH AND THEN BEGINS TO PUT ALONE TURN IT OFF THE LIGHT GOES OUT THE FIVE MINUTES INTO DRIVING AND COMES BACK ON AND ALMOST CUTS OFF IN MID TRAFFIC
DRIVING MY NRKMAL ROUTE TO TAKE MY SON TO HIS SUMMER PROGRAM.(CITY STREET, 24MPH SPEED LIMIT) ON ARRIVAL, ONLY DRIVING 3 MILES FROM MY HOME, MY RPMS WERE WELL OVER 2000 AT A STOP LIGHT. THE CAR BEGAN STO SHAKE. THE ENGINE LIGHT, ELECTRONIC STABILITY CONTROL LIGHT, AND STABILITY CONTROL LIGHT COME ON. I PULLED OVER THE THE NEARE…
Read full complaint
DRIVING MY NRKMAL ROUTE TO TAKE MY SON TO HIS SUMMER PROGRAM.(CITY STREET, 24MPH SPEED LIMIT) ON ARRIVAL, ONLY DRIVING 3 MILES FROM MY HOME, MY RPMS WERE WELL OVER 2000 AT A STOP LIGHT. THE CAR BEGAN STO SHAKE. THE ENGINE LIGHT, ELECTRONIC STABILITY CONTROL LIGHT, AND STABILITY CONTROL LIGHT COME ON. I PULLED OVER THE THE NEAREST GAS STATION. TURNED CAR OFF AND BACK IN AGAIN. RPMS OVER 2500. THEY DIED DOWN AFTER 2 MIN. ALL LIGHTS STILL FLASHING. GOT IT TO SOMEWHERE YO HAVE CODES READ. "HIGH AIRFLOW VACUUM LEAK". NURSED IT HOME,.COULD NOT GO OVER 20MP. ANYTHING OVER 20MPH THE CAR SHOOK VIOLENTLY. RPMS WERE OVER 2000. ALL OF THIS DRIVING WAS KN CITY STREETS WITH SPEED LIMITS NOT GOING OVER 35MPH. WE TRIED TO REPLACE THE THROTTLE BODY TODAY. STILL HAVING THE SAME ISSUES. JEEP ON NEUTRAL (MANUAL TRANNY) RPMS OVER 2000 STILL.
TL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE, TRACTION CONTROL, AND ELECTRONIC THROTTLE CONTROL WARNING INDICATORS ILLUMINATED AND THE VEHICLE LOST ACCELERATION. THE CONTACT PULLED OVER IN A PARKING LOT AND TURNED OFF THE VEHICLE. AFTERWARDS, THE VEHICLE RESTARTED NORMALLY. THE C…
Read full complaint
TL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING APPROXIMATELY 40 MPH, THE CHECK ENGINE, TRACTION CONTROL, AND ELECTRONIC THROTTLE CONTROL WARNING INDICATORS ILLUMINATED AND THE VEHICLE LOST ACCELERATION. THE CONTACT PULLED OVER IN A PARKING LOT AND TURNED OFF THE VEHICLE. AFTERWARDS, THE VEHICLE RESTARTED NORMALLY. THE CONTACT STATED THAT THE FAILURE OCCURRED RANDOMLY ON A DAILY BASIS EVER SINCE JUNE 2, 2018. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 74,660.
ELECTRONIC THROTTLE LIGHT FLICKED ON AND OFF ON FOUR SEPARATE OCCASIONS WHILE ACCELERATING. VEHICLE SEEMED TO REV UP AND ALMOST BOTTOM OUT. DIAGNOSED BY INDEPENDENT SERVICE SHOP AS FAULTY ELECTRONIC THROTTLE. REPAIR COST WAS APPROXIMATELY $742.
TAKATA RECALL- 3 DASH LIGHTS ON ETC, MIL, AND ESC ACTIVATIONAL MALFUNCTION INDICATOR LIGHT ON- CAR MAKES SPUTTERING LOUD NOISE AND STALLS/TURNS OFF QUICKLY AFTER STARTING. CAR WILL NOT ACCELERATE AND IS JERKING/HARD TO PRESS BREAKS. FEELS DANGEROUS LIKE CAR IS GOING TO SHUT OFF AT ANY MOMENT. THIS STARTED LAST NIGHT WHEN 3 LIGHT…
Read full complaint
TAKATA RECALL- 3 DASH LIGHTS ON ETC, MIL, AND ESC ACTIVATIONAL MALFUNCTION INDICATOR LIGHT ON- CAR MAKES SPUTTERING LOUD NOISE AND STALLS/TURNS OFF QUICKLY AFTER STARTING. CAR WILL NOT ACCELERATE AND IS JERKING/HARD TO PRESS BREAKS. FEELS DANGEROUS LIKE CAR IS GOING TO SHUT OFF AT ANY MOMENT. THIS STARTED LAST NIGHT WHEN 3 LIGHTS APPEARED ON DASH BUT CAR SOUNDED NORMAL. SHORTLY AFTER IT SHUT OFF AND HAS GONE DECREASINGLY DOWN HILL.THIS SOUNDS LIKE A RECALL ISSUED FOR JEEP PATRIOTS BUT DOES NOT COVER MY VIN NUMBER.
TL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING 60 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE SPEED INDEPENDENTLY DECREASED TO 20 MPH. THE ETC (ELECTRONIC THROTTLE CONTROL) INDICATOR ILLUMINATED. THE VEHICLE WAS SHUT OFF FOR APPROXIMATELY ONE HOUR AND IT RESTARTED ON THE FIRST ATTEMPT; HOWEVER, THE FAILURE RECURRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2014 JEEP PATRIOT. WHILE DRIVING 60 MPH WITH THE ACCELERATOR PEDAL DEPRESSED, THE SPEED INDEPENDENTLY DECREASED TO 20 MPH. THE ETC (ELECTRONIC THROTTLE CONTROL) INDICATOR ILLUMINATED. THE VEHICLE WAS SHUT OFF FOR APPROXIMATELY ONE HOUR AND IT RESTARTED ON THE FIRST ATTEMPT; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER TO BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WERE EXISTING COMPLAINTS FOR THE FAILURE, BUT THERE WAS NO CURRENT RECALL AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
2014 JEEP PATRIOT STALLS OUT ON ME. TRAVELING AT SPEEDS ANYWHERE FROM 30MPH TO 55 MPH. PROBLEM INITIALLY STARTED IN EARLY 2016. DRIVING AT SPEED OF 55 MPH, CAR WILL START TO VIBRATE, THE ENGINE AND THE ETC (ELECTRIC THROTTLE CONTROL) LIGHTS WILL COME ON AND THE ENGINE WILL COMPLETELY SHUT OFF AND STALL OUT. THE LAST STALLING OU…
Read full complaint
2014 JEEP PATRIOT STALLS OUT ON ME. TRAVELING AT SPEEDS ANYWHERE FROM 30MPH TO 55 MPH. PROBLEM INITIALLY STARTED IN EARLY 2016. DRIVING AT SPEED OF 55 MPH, CAR WILL START TO VIBRATE, THE ENGINE AND THE ETC (ELECTRIC THROTTLE CONTROL) LIGHTS WILL COME ON AND THE ENGINE WILL COMPLETELY SHUT OFF AND STALL OUT. THE LAST STALLING OUT WHILE DRIVING OCCURRED 09/07/17. AFTER RESTARTING THE VEHICLE AND ATTEMPTING TO MERGE ONTO THE ROAD AFTER BEING ON THE SHOULDER, THE CAR WILL LUNGE FORWARD AND AGAIN STALL OUT. AFTER 5-7 ATTEMPTS AND NEARLY BEING HIT EACH TIME I TRY TO GET ON THE MAIN ROAD, THE PATRIOT WILL FINALLY GET ME STRAIGHT HOME. THIS HAS BEEN AN ONGOING EVERY 3-4 MONTH OCCURRENCE FOR THE PAST YEAR AND A HALF. I HAVE CONTACTED THE JEEP DEALERSHIP WHERE I PURCHASED THE VEHICLE AND THEY TELL ME THEY KNOW OF NO SUCH COMPLAINTS OCCURRING. THIS VEHICLE MUST BE RECALLED, IT IS A DEATHTRAP! I AM TERRIFIED TO DRIVE MY PATRIOT BUT SEEING AS I HAVE NO OTHER OPTION FOR TRANSPORTATION, I HAVE TO SAY A PRAYER AND DRIVE IT TO MY PLACE OF EMPLOYMENT. THE VEHICLE HAS STALLED OUT PULLING AWAY FROM MY DRIVEWAY AFTER BACKING OUT, TURNING THE CORNER AT THE END OF MY STREET AND WHILE DRIVING IT ON A STRAIGHT ROAD AT 55 MPH AND ALWAYS IN MOTION. NEXT TIME IT DOES HAPPEN, SINCE IT ALWAYS OCCURS MORE THAN ONCE, I WILL RECORD IT AND SEND IT TO THE NHTSA. I'VE BEEN READING MANY DIFFERENT MESSAGE BOARDS ACROSS THE INTERNET THIS IS A COMMON OCCURRENCE. THIS ISSUE NEEDS TO BE REPAIRED OR VEHICLES BOUGHT BACK OR REPLACED BEFORE SOMEONE DIES!
Official recalls
216V668000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Seat Belts:pretensioner
Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
13V552000 · Engine
Nov 6, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2013 Dodge Avenger and Chrysler 200, and model year 2014 Jeep Compass and Patriot vehicles equipped with 2.4L engines. Due to abrasive debris in the balance shaft bearings, these engines may have a loss of engine oil pressure, possibly resulting in an engine stall or engine failure.
Consequence & remedy
Consequence: If the engine stalls while driving it may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the engine balance shaft module, free of charge. The recall began on December 24, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N52.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.