NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
95 reportsClear category filter17,000 miles · Dec 30, 2011
Fuel System, Gasoline
MY 2008 JEEP LIBERTY HAS OVERFLOWED FUEL WHEN FILLING THE TANK 3 OUT OF THE 6 TIMES I HAVE FILLED IT SINCE PURCHASED ON 11/28. IT HAS HAPPENED AT SEVERAL DIFFERENT GAS STATIONS. WHEN THE PUMP KICKS OFF THERE IS BETWEEN 2-8 OUNCES OF FUEL THAT SPITS BACK AROUND THE HANDLE WITH A FAIR AMOUNT OF PRESSURE. THE AREA UNDERNEATH THE …
Read full complaint
MY 2008 JEEP LIBERTY HAS OVERFLOWED FUEL WHEN FILLING THE TANK 3 OUT OF THE 6 TIMES I HAVE FILLED IT SINCE PURCHASED ON 11/28. IT HAS HAPPENED AT SEVERAL DIFFERENT GAS STATIONS. WHEN THE PUMP KICKS OFF THERE IS BETWEEN 2-8 OUNCES OF FUEL THAT SPITS BACK AROUND THE HANDLE WITH A FAIR AMOUNT OF PRESSURE. THE AREA UNDERNEATH THE FILLER CAP IS SOAKED AND A LARGE PUDDLE FORMS ON THE GROUND. I AM CONCERNED THAT AT SOME POINT A FIRE MAY RESULT. I ALSO FEEL I MUST WASH THE CAR AFTER EVERY INCIDENT BECAUSE I WORRY ABOUT THE GAS CAUSING A PAINT DEFECT. *KB
NHTSA ODI #10441738
50,000 miles · Dec 27, 2011
Fuel System, Gasoline
WHEN FILLING UP AT A GAS STATION, THE GAS TANK OVER FLOWS BEFORE THE PUMP STOPS. I ORIGINALLY THOUGHT IT WAS A BROKEN PUMP, HOWEVER, I HAVE NOW FILLED UP OVER 4 TIMES AT 4 DIFFERENT GAS STATIONS AND THE PROBLEM CONTINUES TO HAPPEN. THIS MOST RECENT TIME I HAVE LOST AROUND 1/2 GALLON OF GAS ON THE GROUND. I AM ALSO CONCERNED W…
Read full complaint
WHEN FILLING UP AT A GAS STATION, THE GAS TANK OVER FLOWS BEFORE THE PUMP STOPS. I ORIGINALLY THOUGHT IT WAS A BROKEN PUMP, HOWEVER, I HAVE NOW FILLED UP OVER 4 TIMES AT 4 DIFFERENT GAS STATIONS AND THE PROBLEM CONTINUES TO HAPPEN. THIS MOST RECENT TIME I HAVE LOST AROUND 1/2 GALLON OF GAS ON THE GROUND. I AM ALSO CONCERNED WITH THE EFFECT OF THE GAS ON MY PAINT/CAR BODY. *TR
NHTSA ODI #10441392
Mileage unknown · Dec 19, 2011
Fuel System, Gasoline
WHEN FILLING GAS TANK IT SPLASHES OUT AND GET ALL OVER THE JEEP AND THE PERSON FILLING THE TANK. *TR
NHTSA ODI #10440501
40,000 miles · Dec 19, 2011
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2008 JEEP LIBERTY. THE CONTACT STATED THAT AFTER REFUELING, FUEL WOULD SPILL BACK OUT FROM THE FILLER NECK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 01/24/12*LJ THE CONSUMER STATED WHEN HE FILLED THE …
Read full complaint
TL* THE CONTACT OWNS A 2008 JEEP LIBERTY. THE CONTACT STATED THAT AFTER REFUELING, FUEL WOULD SPILL BACK OUT FROM THE FILLER NECK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 01/24/12*LJ THE CONSUMER STATED WHEN HE FILLED THE VEHICLE UP WITH GAS, IT SPLASHED BACK OUT. THE DEALER REPLACED THE FUEL FILL TUBE. UPDATED 01/25/12
NHTSA ODI #10440382
40,000 miles · Dec 5, 2011
Fuel System, Gasoline
WHEN FILLING GAS TANK WITH FUEL, FUEL SPILLS OUT OF THE FILLER TUBE SPLASHING ON THE SIDE OF THE VEHICLE, THE PERSON PUMPING THE FUEL, AND ONTO THE GROUND. THERE IS AN OBVIOUS DEFECT INTERNAL RELATING TO THE FILLER VALVE OR FUEL TANK. THIS IS EXTREMELY DANGEROUS AND SHOULD BE EVALUATED AS A SAFETY RECALL. *TR
NHTSA ODI #10438570
Mileage unknown · Nov 29, 2011
Fuel System, Gasoline
EVERY TIME I FILL UP MY JEEP THE PUMP WILL SHUT OFF WHEN THE TANK IS FULL AND I REMOVE THE PUMP AND GAS WILL BUBBLE OUT OF THE TANK AND RUNS DOWN THE SIDE OF THE VEHICLE. *KB
NHTSA ODI #10437717
33,000 miles · Nov 25, 2011
Fuel System, Gasoline
THE LAST 3 TIMES I HAVE FILLED THE GAS TANK ON MY VEHICLE, GAS HAS OVERFLOWED ONTO THE GROUND. AFTER THE 2ND TIME, THE CHECK ENGINE LIGHT CAME ON. I BROUGHT IT TO THE DEALERSHIP AND WAS ADVISED THE CODE READ THAT THE FILLER NECK WAS FAULTY AND NEEDED TO BE REPLACED. I ADVISED THEM THAT I HAD AN ISSUE WITH GAS OVERFLOWING ONTO TH…
Read full complaint
THE LAST 3 TIMES I HAVE FILLED THE GAS TANK ON MY VEHICLE, GAS HAS OVERFLOWED ONTO THE GROUND. AFTER THE 2ND TIME, THE CHECK ENGINE LIGHT CAME ON. I BROUGHT IT TO THE DEALERSHIP AND WAS ADVISED THE CODE READ THAT THE FILLER NECK WAS FAULTY AND NEEDED TO BE REPLACED. I ADVISED THEM THAT I HAD AN ISSUE WITH GAS OVERFLOWING ONTO THE GROUND WHEN FILLING UP AND WAS ADVISED IT "MAY" BE FIXED BY THE NEW FILLER NECK SINCE THERE IS A SENSOR IN THERE. I HAD THE FILLER NECK REPLACED. I FILLED THE JEEP AGAIN TODAY, ROUGHLY A WEEK AFTER HAVING THE FILLER NECK REPLACED, AND AGAIN GAS OVERFLOWED AND LEAKED DOWN THE SIDE OF MY JEEP AND ONTO THE GROUND. UP UNTIL THIS POINT, WHEN FILLING MY JEEP, THE GAS PUMP WOULD CLICK OFF WHEN THE TANK WAS FULL. I HAVE GONE TO THREE DIFFERENT GAS STATIONS SO IT IS NOT A PROBLEM WITH THE PUMP AT THE STATION. *TR
NHTSA ODI #10437274
36,500 miles · Nov 20, 2011
Fuel System, Gasoline
EVERY TIME I FILL THE GAS TANK, FUEL GUSHES OUT OF THE FILLER NECK ONTO THE SIDE OF THE VEHICLE AND ONTO THE GROUND. MOST TIMES, THE AUTOMATIC FUEL SHUTOFF A THE GAS PUMP .... AT VARIOUS STATIONS ... DOES NOT STOP THE FLOW. AT OTHER TIMES, FUEL GUSHES OUT EVEN IF THE PUMP SHUTS OFF. I HAVE TRIED SLOWING THE RATE FUEL GOES INTO…
Read full complaint
EVERY TIME I FILL THE GAS TANK, FUEL GUSHES OUT OF THE FILLER NECK ONTO THE SIDE OF THE VEHICLE AND ONTO THE GROUND. MOST TIMES, THE AUTOMATIC FUEL SHUTOFF A THE GAS PUMP .... AT VARIOUS STATIONS ... DOES NOT STOP THE FLOW. AT OTHER TIMES, FUEL GUSHES OUT EVEN IF THE PUMP SHUTS OFF. I HAVE TRIED SLOWING THE RATE FUEL GOES INTO THE TANK. SOMETIMES THIS WORKS. OTHER TIMES, IT DOESN'T. THE ONLY WAY TO AVOID THIS POTENTIALLY DANGEROUS SITUATION IS TO TRY TO CALCULATE HOW MUCH FUEL IT WILL TAKE TO FILL THE VEHICLE AND THEN STOP THE FLOW MYSELF A COUPLE OF GALLONS EARLY. THERE IS A JEEP TSB OUT ON THIS PROBLEM. AND THERE HAVE BEEN NUMEROUS COMPLAINTS. THE FUEL SPILLAGE ISSUE IS DANGEROUS AND SHOULD BE A RECALL ITEM. *TR
NHTSA ODI #10436514
42,000 miles · Nov 16, 2011
Fuel System, Gasoline
I BOUGHT MY JEEP IN JUNE WITH JUST OVER 36000 MILES. IT WAS PREVIOUSLY A RENTAL VEHICLE. EVERYTHING WAS FINE UNTIL ABOUT SEPTEMBER WHEN I FILLED GAS AND THE PUMP CLICKED OFF AND GAS CAME OUT ALL OVER AT ABOUT 42,000 MILES. I THOUGHT IT WAS THE GAS PUMP, BUT THEN I WENT TO OTHER STATIONS AND IT HAPPENED EVERY TIME. I WAS GOING TO…
Read full complaint
I BOUGHT MY JEEP IN JUNE WITH JUST OVER 36000 MILES. IT WAS PREVIOUSLY A RENTAL VEHICLE. EVERYTHING WAS FINE UNTIL ABOUT SEPTEMBER WHEN I FILLED GAS AND THE PUMP CLICKED OFF AND GAS CAME OUT ALL OVER AT ABOUT 42,000 MILES. I THOUGHT IT WAS THE GAS PUMP, BUT THEN I WENT TO OTHER STATIONS AND IT HAPPENED EVERY TIME. I WAS GOING TO BRING IT IN TO HAVE IT LOOKED AT BUT I SEE OTHER PEOPLE HAVE THE SAME PROBLEM. IT IS VERY IRRITATING TO HAVE IT HAPPEN EVERY TIME! PLEASE HAVE A RECALL! *TR
NHTSA ODI #10436011
36,000 miles · Nov 15, 2011
Fuel System, Gasoline
A SIGNIFICANT AMOUNT OF GAS SPILLS OUT OF THE FUEL TANK OPENING AFTER THE AUTOMATIC SHUT-OFF OF THE PUMPS GAS FLOW. THIS OCCURS ALMOST EVERY TIME I FILL UP. I NOW HAVE TO ONLY ALLOW THE TANK TO FILL UP 3/4 FULL TO AVOID SPILLS. *TR
NHTSA ODI #10435975
Official recalls
4Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence & remedy
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Additional source detail variants (3)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Air Bags
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Power Train:driveline:driveshaft
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Nov 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 JEEP LIBERTY VEHICLES. THE VEHICLES ARE EQUIPPED WITH WINDSHIELD WIPER MOTORS THAT CONTAIN EXCESS ADHESIVE THAT MAY ALLOW FOR WATER INTRUSION, WHICH COULD RESULT IN INTERMITTENT AND EVENTUALLY INOPERATIVE WINDSHIELD WIPER OPERATION.
Consequence & remedy
Consequence: A FAILING OR INOPERATIVE WINDSHIELD WIPER SYSTEM WILL REDUCE A DRIVER'S VISIBILITY WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 1, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 8, 2008
CHRYSLER IS RECALLING 3,663 MY 2007-2008 DODGE NITRO AND MY 2008 JEEP LIBERTY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. THE PARK BRAKE LEVER CLUTCH DRUM MAY DISTORT AND REDUCE THE EFFECTIVENESS OF THE PARK BRAKE SYSTEM.
Consequence & remedy
Consequence: THIS COULD ALLOW THE VEHICLE TO MOVE INADVERTENTLY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PARK BRAKE LEVER ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 27, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Sep 9, 2008
CHRYSLER IS RECALLING 494 MY 2008 JEEP LIBERTY VEHICLES. THE WINDSHIELD AND/OR FIXED REAR QUARTER GLASS MAY HAVE BEEN ASSEMBLED USING INCORRECT URETHANE ADHESIVE. THIS COULD AFFECT GLASS RETENTION.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD AND/OR FIXED REAR QUARTER GLASS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 13, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
Illustration