IllustrationALL THE LIGHTS PERTAINING TO THE BREAK ABS AND STABILITY CONTROLS ARE ON. SOMETIMES WHEN BREAKING THE ABS KICKS IN AND WE ARE NOT BREAKING HARD AND ON DRY PAVEMENT ITS BEEN GOING ON FOR ABOUT A MONTH NOW. TOOK IT TO A REPAIR SHOP AND WAS TOLD THAT THERE IS A RECALL ON IT. BUT NOTHING COMES UP ON THIS SITE
2007 Jeep Liberty
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Jeep Liberty do not stand out strongly from the model-year median of 541.
About this comparison →How this year compares
Owner complaints by model year
Compare all Liberty years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
950–25K
11225–50K
11250–75K
6475–100K
78100–150K
32150K+
493 reports with mileage · 210 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 220 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
25 crash reports12 fire reports14 injury reports
Electronic Stability Control (esc) complaints
9 reportsTL* THE CONTACT OWNS A 2007 JEEP LIBERTY. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER AND FAILED TO STEER PROPERLY. THE ELECTRONIC STABILITY CONTROL AND TRACTION CONTROL INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE DEALER (DARCARS CHRYSLER DODGE JEEP RAM OF NEW CARROLLTON, 8100 ANNAPOLIS RD, NEW CARROLLTON, MD 20784, (301) …
Read full complaint
TL* THE CONTACT OWNS A 2007 JEEP LIBERTY. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER AND FAILED TO STEER PROPERLY. THE ELECTRONIC STABILITY CONTROL AND TRACTION CONTROL INDICATORS ILLUMINATED PRIOR TO THE FAILURE. THE DEALER (DARCARS CHRYSLER DODGE JEEP RAM OF NEW CARROLLTON, 8100 ANNAPOLIS RD, NEW CARROLLTON, MD 20784, (301) 459-6800) STATED THAT IT WOULD COST $180 TO DIAGNOSED THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 121,261.
WHEN STARTING UP MY CAR AFTER 4 DAYS OF NOT DRIVING, THE ABS, BRAKE & TRACTION SENSOR WARNING LIGHTS CONTINUELY STAY ON ONCE MY CAR IS STARTED AND MOVING, NHTSA RECALL REF#06V493000, STATES AND ABS CONTROL MODULE SOFWARE PROBLEM, MAY CAUSE LOSS OF VEHICLE CONTROL, NOT SURE WHAT MODEL THIS RECALL IS FOR, CONTACTED CRYSLER, AND RE…
Read full complaint
WHEN STARTING UP MY CAR AFTER 4 DAYS OF NOT DRIVING, THE ABS, BRAKE & TRACTION SENSOR WARNING LIGHTS CONTINUELY STAY ON ONCE MY CAR IS STARTED AND MOVING, NHTSA RECALL REF#06V493000, STATES AND ABS CONTROL MODULE SOFWARE PROBLEM, MAY CAUSE LOSS OF VEHICLE CONTROL, NOT SURE WHAT MODEL THIS RECALL IS FOR, CONTACTED CRYSLER, AND RECEIVED NO ASSIST OR ADVICE, I DON'T KNOW IF I SHOULD BE DRIVING MY CAR OR NOT, I'M VERY CONCERNED
ENGINE LIGHT STAYS ON ALL THE TIME. ALSO ABS, TRACTION, EPS LIGHTS FLASH ON INTERMITTENTLY FOLLOWING A WARNING SOUND. THIS PANEL ISSUE CAN OCCUR UPON STARTING THE VEHICLE OR WHILE DRIVING ON BOTH INTERSTATE AND ON CITY ROADS. HAVE BROUGHT IT TO MY MECHANIC THREE TIMES NOW. MY MECHANIC HAS PLUGGED THE UNIT INTO THE DIAGNOSTIC …
Read full complaint
ENGINE LIGHT STAYS ON ALL THE TIME. ALSO ABS, TRACTION, EPS LIGHTS FLASH ON INTERMITTENTLY FOLLOWING A WARNING SOUND. THIS PANEL ISSUE CAN OCCUR UPON STARTING THE VEHICLE OR WHILE DRIVING ON BOTH INTERSTATE AND ON CITY ROADS. HAVE BROUGHT IT TO MY MECHANIC THREE TIMES NOW. MY MECHANIC HAS PLUGGED THE UNIT INTO THE DIAGNOSTIC SYSREM TO CHECK ERROR CODES AND IT REGISTERED FIVE RANDOM ERROR CODES SIMULTANEOUSLY WHICH HE FELT WERE UNRELATED TO THE IISSUE, NOR WAS IT POSSIBLE TO HAVE THOSE FIVE RELATED CODES ALL AT ONCE. HE SUSPECTED THAT IT WAS A PANEL MALFUNCTION AND WONDERED IF A RECALL HAD BEEN ISSUED THAT HE WAS UNAWARE OF. BUT HE WENT THROUGH THE PROCESS OF CHECKING CONNECTION AND CLEANING CONNECTIONS ANYWAY. HE SUGGESTED TO BRING IT BACK TO A JEEP MANUFACTURER FOR FURTHER EVALUATION IF IT RECURRED AGAIN, WHICH IT DID! FROM THE COMPLAINTS LISTED, IT SOUNDS LIKE JEEP DOES KNOW EITHER BUT THEY CONTINUE TO CHARGE CONSUMERS FOR REPAIRS THAT HAVE NOT SOLVED THE PROBLEM. OBVIOUSLY DRIVING THE VEHICLE IS NOT SAFE PER CUSTOMERS COMPLAINTS EITHER. PERHAPS SOMEONE IS WAITING FOR A TRAGEDY BEFORE ANY TYPE OF RECALL IS CONSIDERED WHICH IS SAD.
THE AIRBAG CLOCKSPRING HAS BROKEN AND WE WERE TOLD THE AIRBAGS, ANTI LOCK BRAKES AND THE STABILITY CONTROL WILL NOT WORK WITHOUT THIS PART. WE HAVE NOT BEEN ABLE TO FIND THIS PART AND HAVE BEEN TOLD THAT IT IS ON BACK ORDER AND ANYWHERE FROM 35 TO 100 ARE ON THE WAITING LIST BEFORE US. THIS IS FOR THE MOPAR REPLACEMENT PART. NO …
Read full complaint
THE AIRBAG CLOCKSPRING HAS BROKEN AND WE WERE TOLD THE AIRBAGS, ANTI LOCK BRAKES AND THE STABILITY CONTROL WILL NOT WORK WITHOUT THIS PART. WE HAVE NOT BEEN ABLE TO FIND THIS PART AND HAVE BEEN TOLD THAT IT IS ON BACK ORDER AND ANYWHERE FROM 35 TO 100 ARE ON THE WAITING LIST BEFORE US. THIS IS FOR THE MOPAR REPLACEMENT PART. NO ONE ELSE IS MAKING THIS PART AND WE ARE FORCED TO DRIVE, WHAT WE FEEL IS AN UNSAFE CAR. NOTHING PARTICULAR HAPPENED, THE WARNING LIGHTS JUST WENT ON.
ONE WEEK AGO FROM 11/28/15, I WAS INFORMED MY BRAKE LIGHTS WERE OUT. JUST SUDDENLY NO LIGHTS, THEN ONE BY ONE TAIL LIGHTS STARTED GOING OUT. I HAD A 2008 COMPASS WITH THE SAME ISSUE, THAT WAS NEVER REPAIRABLE. I WAS DRIVING AT THE TIME, AND WITH NO MEANS OF OTHER TRANSPORTATION I HAVE TO DRIVE WITH NO LIGHTS.
THE STABILITY CONTROL WARNING LIGHT COMES ON AT ARBITRARY TIMES AND THEN REMAINS ON FOR THE REMINDER OF MY DRIVE. WHEN MAKING RIGHT HAND TURNS AT SPEED, THERE IS A "GRINDING" NOISE THAT EMINATES FROM THE LEFT FRONT TIRE & ALMOST FEELS LIKE I WILL LOSE CONTROL OF THE VEHICLE. TOOK VEHICLE TO THE DEALER AND DIAGNOSTIC REVEALED…
Read full complaint
THE STABILITY CONTROL WARNING LIGHT COMES ON AT ARBITRARY TIMES AND THEN REMAINS ON FOR THE REMINDER OF MY DRIVE. WHEN MAKING RIGHT HAND TURNS AT SPEED, THERE IS A "GRINDING" NOISE THAT EMINATES FROM THE LEFT FRONT TIRE & ALMOST FEELS LIKE I WILL LOSE CONTROL OF THE VEHICLE. TOOK VEHICLE TO THE DEALER AND DIAGNOSTIC REVEALED IT WAS A FAULTY CLOCK SPRING IN THE STEERING COLUMN AND THAT THE STEERING ANGLE SENSOR IS ERRATIC, THEREBY CAUSING THE SLIPPAGE. PART IS ON BACK ORDER FOR A *MINUMUM* OF THREE WEEKS FROM THE MANUFACTURER - WAS INFORMED THAT THERE ARE 113 OF THESE BACKORDERED PARTS ACROSS THE COUNTRY, WHICH LEADS ME TO BELIEVE THAT THIS HAS THE POTENTIAL FOR BEING A RECALL ISSUE. THE ISSUE OF THE SLIPPAGE ONLY HAPPENS WHILE MAKING RIGHT HAND TURNS AND NEVER WHEN MAKING LEFT HAND TURNS. THE ONLY WAY TO AVOID THIS ISSUE IS TO ALMOST LITERALLY STOP ON BUSY ROADWAYS TO THEN TURN RIGHT. WAS INFORMED THAT MY VEHICLE WILL NOT BE SAFE ON WATER-COVERED ROADWAYS AND AM EXTREMELY CONCERNED ABOUT THIS CONSIDERING THE UPCOMING INCLEMENT WEATHER WE ARE EXPECTING AS A RESULT OF THE HURRICANE, BUT YET IT IS MY ONLY MEANS OF TRANSPORTATION TO AND FROM WORK.
I TOOK MY 2007 JEEP LIBERTY IN FOR SAFTY LIGHTS THAT CAME ON ESP BAS AND ANTI SKID. SWANTYS OF BULLHEAD CITY TOLED ME I NEEDED A NEW CLOCKSPRING THAT CONTROLES THE AIRBAGE AND ANTI SCID BREAKING THIS WAS ON DECEMBER 2013.IWENT BACK AND COMPLAINED OF BRAKES GRABING THEN RELICING BRAKING NOT NORMAL. AGINE THAY SAID I NEEDED A NEW…
Read full complaint
I TOOK MY 2007 JEEP LIBERTY IN FOR SAFTY LIGHTS THAT CAME ON ESP BAS AND ANTI SKID. SWANTYS OF BULLHEAD CITY TOLED ME I NEEDED A NEW CLOCKSPRING THAT CONTROLES THE AIRBAGE AND ANTI SCID BREAKING THIS WAS ON DECEMBER 2013.IWENT BACK AND COMPLAINED OF BRAKES GRABING THEN RELICING BRAKING NOT NORMAL. AGINE THAY SAID I NEEDED A NEW CLOCKSPRING.AND THAT IT WAS ON BACK ORDER THAT IT WOULD BE AVALABLE JUNE 14,2014 THAT WERE RETOLING THE PLANT. THIS WAS BEBRUARY,27,2014. I KEPT CHECING BACK AFTER JUNE 14 I WAS INFORMED THAT TH THER WAS 500 ON BACK ORDER AND NO PROMIS DATE WAS AVALABLE I STARTED CHECING OTHER SOURCES AND RECIVED THE SAME INFORMATION. I JUST CHECED BACK AGINE AND WAS TOLED THAT THAY ARE STIL ON BACK ORDER WITH NO PROMIS DATE. THE DATE TODAY IS JULY 27,2015. I FILL THAT THIS SAFETY ISUE WAS IMPORTANT TO BRIN TO YOUR ATTENTION P.S.I WAS ALSO TOLED THA THER WAS 676 NOW ON BACK ORDER
ALL FOUR WINDOW REGULATORS HAVE FAILED ON MY 2007 JEEP LIBERTY. IT WAS PURCHASED BRAND NEW. *TR
Official recalls
618V278000 · Suspension:rear
May 1, 2018
Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.
Consequence & remedy
Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.
13V252000 · Fuel System, Gasoline:storage:tank Assembly; Structure
Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
12V085000 · Suspension:rear
Mar 5, 2012
IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.
Consequence & remedy
Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
07V089000 · Electrical System
Mar 9, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH VALEO HEATING, VENTILATION AND AIR CONDITIONING (HVAC), THE BLOWER MOTOR MAY OVERHEAT.
Consequence & remedy
Consequence: THIS COULD CAUSE AN INTERIOR FIRE.
Remedy: DEALERS WILL REPLACE THE HVAC BLOWER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON MAY 28, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
06V493000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
Dec 29, 2006
ON CERTAIN VEHICLES, THE ANTILOCK BRAKE SYSTEM (ABS) CONTROL MODULE SOFTWARE MAY CAUSE THE REAR BRAKES TO LOCK UP DURING CERTAIN BRAKING CONDITIONS.
Consequence & remedy
Consequence: THIS COULD RESULT IN A LOSS OF VEHICLE CONTROL AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPROGRAM THE ABS ELECTRONIC CONTROL UNIT. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
06V341000 · Power Train:automatic Transmission
Sep 7, 2006
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE SOFTWARE PROGRAMMED INTO THE POWERTRAIN CONTROL MODULE CAN CAUSE A MOMENTARY LOCK UP OF THE DRIVE WHEELS IF THE VEHICLE IS TRAVELING OVER 40 MPH AND THE OPERATOR SHIFTS FROM DRIVE TO NEUTRAL AND BACK TO DRIVE.
Consequence & remedy
Consequence: IF THE DRIVE WHEELS LOCKED UP, LOSS OF VEHICLE CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 2, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE06056 · Interior Fire, Passenger Side Dash Area
Opened Nov 21, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash; Visibility:defroster/defogger/hvac System:fan/motor
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Additional source detail variants (3)
Electrical System
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Electrical System:wiring:interior/under Dash
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Visibility:defroster/defogger/hvac System:fan/motor
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.