IllustrationESP PROBLEM, I BEEN WORKING ON THE BREAKS, MASTER CYLINDER, CALIPERS, BRAKE CONTROL, SENSORS AND I DON'T HAVE A CLUE WHAT TO DO. *TR
2006 Jeep Liberty
Owner reports · Recalls · Investigations
More warning signs than most Liberty years
Owner complaints for the 2006 Jeep Liberty are substantially higher than the model-year median of 541.
About this comparison →How this year compares
Owner complaints by model year
Compare all Liberty years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
24025–50K
21450–75K
16675–100K
129100–150K
64150K+
1,014 reports with mileage · 358 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility. Review the 394 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 196 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports19 fire reports22 injury reports
Electronic Stability Control (esc) complaints
32 reportsMY ENGINE LIGHT IT ON
I'VE TO REPLACE THE REAR TAIL LIGHT ASSEMBLY 4 TIMES, IT KEEPS BLOWING OUT THE BRAKE AND TAIL LIGHT. I'VE ALSO HAD TO PURCHASE 5 A/C COMPESSORS FOR THIS TRUCK AND THE ABS, TRACTION LIGHT STAYS ON.
WHILE DRIVING MY 2006 JEEP LIBERTY, FOR NO APPARENT REASON, THE ESP, ABS, AND BRAKE LIGHTS ALL SARTED FLASHING AT ONCE. SINCE THEN, MY VEHICLE WOULD CONSTANTLY LOSE POWER AND STALL OUT WHEN ATTEMPTING TO ACCELERATE. DIAGNOSTIC CHECK INDICATED A DEFECTIVE SPEED SENSOR. IT WAS REPLACED, AND THE ISSUE CORRECTED ITSELF SOMEWHAT FOR …
Read full complaint
WHILE DRIVING MY 2006 JEEP LIBERTY, FOR NO APPARENT REASON, THE ESP, ABS, AND BRAKE LIGHTS ALL SARTED FLASHING AT ONCE. SINCE THEN, MY VEHICLE WOULD CONSTANTLY LOSE POWER AND STALL OUT WHEN ATTEMPTING TO ACCELERATE. DIAGNOSTIC CHECK INDICATED A DEFECTIVE SPEED SENSOR. IT WAS REPLACED, AND THE ISSUE CORRECTED ITSELF SOMEWHAT FOR A COUPLE OF MONTHS. HOWEVER...THE SAME EXACT ISSUE RETURNED. IT PROGRESSIVELY BECAME SO BAD I HAD TO REMOVE THE ABS FUSES IN ORDER TO EVEN DRIVE THE VEHICLE, THUS CREATING AN EQUALLY DANGROUS SITUATION. MY JEEP IS OUT OF WARRANTY, OF COURSE, AND I'VE READ TONS OF COMPLAINTS OF THE EXACT SAME PROBLEM WITH THIS VEHICLE, SO I AM BASICALLY (DANGEROUSLY) WAITING FOR A RECALL TO OCCUR.
WHILE I WAS DRIVING THE ABS BAS ESP STOPPED WORKING AND THE LIGHTS CAME ON. WE WERE LIVING IN FT WAYNE INDIANS AT THE TIME AND WITHOUT THOSE FEATURES THIS JEEP IS FLAT OUT DANGEROUS. I HAD THE WHEEL SPEED SENSOR REPLACED TWICE BUT THAT WASN'T IT. ONE DEALER REBUILT ALL FOUR OF MY BRAKES AND PURGED THE SYSTEM. THAT DIDN'T WORK. I…
Read full complaint
WHILE I WAS DRIVING THE ABS BAS ESP STOPPED WORKING AND THE LIGHTS CAME ON. WE WERE LIVING IN FT WAYNE INDIANS AT THE TIME AND WITHOUT THOSE FEATURES THIS JEEP IS FLAT OUT DANGEROUS. I HAD THE WHEEL SPEED SENSOR REPLACED TWICE BUT THAT WASN'T IT. ONE DEALER REBUILT ALL FOUR OF MY BRAKES AND PURGED THE SYSTEM. THAT DIDN'T WORK. I PAID FOUR DIFFERENT DEALERSHIPS OVER 3800$ PLUS RENT FEES. IT STILL IS T FIXED.
MY ANTI SKID, ABS, AND ESP LIGHTS ARE ON. THE CRUISE CONTROL IS NOT WORKING. ALSO, AT ABOUT 50 MPH, MY FRONT END ACTS UP. I AM TOLD THAT THIS IS A KNOWN PROBLEM WITH THE CLOCK SPRING.
AT 44,143 IN DEC 2009 I HAD 4 NEW TIRES AND REAR DISC PADS REPLACED. IN JULY 2012, ABOUT MILEAGE 54000, WHILE DRIVING IN TOWN, THE LEFT REAR WHEEL SPEED SENSOR FAILED CAUSING LOSS OF ABS, ESP, AND CRUISE CONTROL. I HAD DEALER REPAIR. AT 67,642,IN APRIL 2016, I NOTICED THE REAR DISC ROTORS WERE CAKED WITH A CRUSTY RUST AND IT AP…
Read full complaint
AT 44,143 IN DEC 2009 I HAD 4 NEW TIRES AND REAR DISC PADS REPLACED. IN JULY 2012, ABOUT MILEAGE 54000, WHILE DRIVING IN TOWN, THE LEFT REAR WHEEL SPEED SENSOR FAILED CAUSING LOSS OF ABS, ESP, AND CRUISE CONTROL. I HAD DEALER REPAIR. AT 67,642,IN APRIL 2016, I NOTICED THE REAR DISC ROTORS WERE CAKED WITH A CRUSTY RUST AND IT APPEARED THAT THE BRAKE PADS WERE WORN OUT.. THE REAR BRAKES COULD NOT HAVE BEEN WORKING. THE DEALER PUT ON NEW ROTORS, CALIPERS, PADS, AND FLUSHED THE SYSTEM. THE RUSTY ROTORS COULD NOT BE TURNED TO REUSE, THE CALIPERS WERE BOTH "STUCK" AND THE BRAKE FLUID WAS "BLACK". I ALSO HAD THE FRONT ROTORS TURNED AND NEW PADS INSTALLED. THE ABS, ESP, AND CRUISE CONTROL STILL LIGHTS UP ON THE DASH FOR A MINUTE THEN GOES OUT BY ITSELF, LEADING ME TO TOTALLY DISTRUST THE SYSTEM. I HAVE NEVER SEEN BRAKE ROTORS SO RUSTED IN MY 65 YEARS.
WENT TO START SMOKE CAME OUT FROM DASH WAS PARKED IN GARGAGE TRUCK IS STILL IN SHOP INS TOLD ME ONLY REASON THEY WOUL D COVER IS BECAUSE IS WAS A LONG COUSTOMER THY ONLY GAVE ME 883 TO REPAIR THERE ARE AT LEAST 14 CODES DUE TO THIS DON'T KNOW IF THEY WILL RESET IF NOT I HAVE TO PAY FOR REPAIRS I DO HAVE FIRE PROTECTION ON TRUCK …
Read full complaint
WENT TO START SMOKE CAME OUT FROM DASH WAS PARKED IN GARGAGE TRUCK IS STILL IN SHOP INS TOLD ME ONLY REASON THEY WOUL D COVER IS BECAUSE IS WAS A LONG COUSTOMER THY ONLY GAVE ME 883 TO REPAIR THERE ARE AT LEAST 14 CODES DUE TO THIS DON'T KNOW IF THEY WILL RESET IF NOT I HAVE TO PAY FOR REPAIRS I DO HAVE FIRE PROTECTION ON TRUCK THIS IS ALLSTATE I WILL SEND PAPER WORK IF NEEDED AT A LATER DATE I HAVE NONE ALSO WAITING FOR CHECK TOLD FOR ME TO PAY REPAIR SHOP
JEEP WOULD NOT START -HAD LIGHTS, RADIO, HORN ETC. BUT IT WOULD NOT TURN OVER AT ALL. TOWED TO DEALER. TECH PERFORMED DIAGNOSIS AND FOUND THE PROBLEM - STEERING COLUMN HAD TO BE REPLACED. TOTAL COST $798.00. I WAS TOLD THAT THE STEERING COLUMN AND IGNITION SWITCH WERE PROBLEM ISSUES IN THIS MAKE AND MODEL BUT NO RECALL WAS IN P…
Read full complaint
JEEP WOULD NOT START -HAD LIGHTS, RADIO, HORN ETC. BUT IT WOULD NOT TURN OVER AT ALL. TOWED TO DEALER. TECH PERFORMED DIAGNOSIS AND FOUND THE PROBLEM - STEERING COLUMN HAD TO BE REPLACED. TOTAL COST $798.00. I WAS TOLD THAT THE STEERING COLUMN AND IGNITION SWITCH WERE PROBLEM ISSUES IN THIS MAKE AND MODEL BUT NO RECALL WAS IN PLACE TO REPAIR. IGNITION SWITCH RECALL REPLACE IN 2006 JEEP LIBERTY MANUAL TRANSMISSION BUT NOT IN AUTOMATIC TRANSMISSION
ABS SYSTEM GOES OUT WHICH IN TURN MAKES THE CRUISE CONTROL GO OUT. THEN WHEN YOU USE THE VEHICLE AGAIN THE ABS IS ON SO IS THE CRUISE CONTROL BUT THE BRAKES DON'T WORK WELL AND GRAB. THEN WHEN YOU ARE USING THE LIGHTS AT NIGHT IT DIMS FOR NO REASON INSIDE AND OUT. STILL WAITING ON THE FIX FOR THE REAR END FUEL TANK ISSUE
Official recalls
918V278000 · Suspension:rear
May 1, 2018
Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.
Consequence & remedy
Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.
15V222000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
Apr 15, 2015
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
13V252000 · Fuel System, Gasoline:storage:tank Assembly; Structure
Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
12V085000 · Suspension:rear
Mar 5, 2012
IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.
Consequence & remedy
Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
07V089000 · Electrical System
Mar 9, 2007
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH VALEO HEATING, VENTILATION AND AIR CONDITIONING (HVAC), THE BLOWER MOTOR MAY OVERHEAT.
Consequence & remedy
Consequence: THIS COULD CAUSE AN INTERIOR FIRE.
Remedy: DEALERS WILL REPLACE THE HVAC BLOWER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON MAY 28, 2007. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
06V288000 · Suspension:front:control Arm:lower Ball Joint
Aug 3, 2006
ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.
Consequence & remedy
Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
06V072000 · Latches/locks/linkages:doors:latch
Mar 9, 2006
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS." AN INCORRECT RIGHT FRONT DOOR LATCH REINFORCEMENT PLATE MAY HAVE BEEN INSTALLED WHICH MAY CAUSE THE SECONDARY DOOR LATCH TO BECOME INOPERATIVE.
Consequence & remedy
Consequence: THIS INCREASES THE POSSIBILITY OF A DOOR BECOMING FORCED OPEN AND AN UNBELTED PASSENGER BEING EJECTED DURING CERTAIN CRASH CONDITIONS.
Remedy: DEALERS WILL INSPECT THE LATCH ASSEMBLY AND REPLACE THE RIGHT FRONT DOOR LATCH REINFORCEMENT PLATE FREE OF CHARGE. THE RECALL BEGAN ON MARCH 13, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
06V036000 · Electrical System:wiring:front Underhood
Feb 9, 2006
ON CERTAIN TWO WHEEL DRIVE SPORT UTILITY VEHICLES EQUIPPED WITH 3.7 LITER ENGINES, THE LEFT OXYGEN SENSOR WIRING HARNESS MAY CONTACT THE EXHAUST PIPE.
Consequence & remedy
Consequence: DAMAGE TO THE WIRING HARNESS COULD RESULT IN AN UNDERBODY FIRE.
Remedy: DEALERS WILL INSPECT THE OXYGEN SENSOR WIRING HARNESS TAKEOUT FOR DAMAGE. IF THE TAKEOUT IS DAMAGED, THE WIRING WILL BE REPAIRED AND A TIE WRAP INSTALLED TO SECURE THE EXCESS LENGTH OF WIRING HARNESS. IF THERE IS NO DAMAGE, A TIE WRAP WILL BE INSTALLED TO SECURE THE EXCESS LENGTH OF THE WIRING HARNESS. THE RECALL BEGAN ON APRIL 17, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE07041 · Diesel Fuel Leak
Opened Aug 8, 2007 · Closed Dec 7, 2007
Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Diesel: PRE-HEATER
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Diesel
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Diesel: PRE-HEATER
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE06056 · Interior Fire, Passenger Side Dash Area
Opened Nov 21, 2006 · Closed Mar 12, 2007
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:interior/under Dash; Visibility:defroster/defogger/hvac System:fan/motor
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Additional source detail variants (3)
Electrical System
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Electrical System:wiring:interior/under Dash
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
Visibility:defroster/defogger/hvac System:fan/motor
THIS INVESTIGATION WAS OPENED ON NOVEMBER 21, 2006 BASED ON TWO OWNER REPORTS AND ONE E-MAIL REPORT ALLEGING AN INTERIOR FIRE IN THE PASSENGER SIDE AREA OF THE DASH PANEL.DAIMLERCHRYSLER (DCC) HAS IDENTIFIED A DEFECT IN THE BLOWER MOTOR OF THE HVAC SYSTEM IN THE SUBJECT VEHICLES AND IN CERTAIN 2007 MODEL YEAR LIBERTY VEHICLES.THE DEFECT REPORT STATES, UNDER CERTAIN CONDITIONS THE HEATING, VENTILATION AND AIRCONDITIONING (HVAC) BLOWER MOTOR MAY OVERHEAT AND CAUSE AN INTERIOR FIRE.DCC WILL RECALL 149,065 VEHICLES TO REPLACE THE ORIGINAL HVAC BLOWER MOTOR WITH ONE OF A NEW DESIGN.THE VEHICLES INCLUDED IN THE RECALL ARE ALL 2006 MODEL YEAR AND 2007 MODEL YEAR JEEP LIBERTY VEHICLES BUILT FROM START OF PRODUCTION THROUGH AUGUST 15, 2006.SEE NHTSA RECALL NUMBER 07V089 FOR DETAILS.
EA06008 · Front Suspension Ball Joint Separation
Opened May 31, 2006 · Closed Aug 24, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.