NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
108 reportsClear category filter87,000 miles · Jul 22, 2010
Visibility
11 MONTHS AGO MY DRIVER SIDE REAR WINDOW REGULATOR BROKE AND I HAD TO HAVE IT FIXED. THEY SAID IT HAPPENS BECAUSE OF THE HEAT. FINE, I FORKED OUT A FEW HUNDRED DOLLARS AND A FEW HOURS OF MY TIME. THEN YESTERDAY I GOT INTO MY CAR AND SURE ENOUGH THE WINDOW WAS DOWN, WHEN I TRIED TO ROLL IT UP AND NOTHING HAPPENED I IMMEDIATELY CA…
Read full complaint
11 MONTHS AGO MY DRIVER SIDE REAR WINDOW REGULATOR BROKE AND I HAD TO HAVE IT FIXED. THEY SAID IT HAPPENS BECAUSE OF THE HEAT. FINE, I FORKED OUT A FEW HUNDRED DOLLARS AND A FEW HOURS OF MY TIME. THEN YESTERDAY I GOT INTO MY CAR AND SURE ENOUGH THE WINDOW WAS DOWN, WHEN I TRIED TO ROLL IT UP AND NOTHING HAPPENED I IMMEDIATELY CALLED THE DEALERSHIP. THEY SET ME UP WITH AN APPOINTMENT FOR THIS MORNING. THEY SAID IT HAPPENS ALL THE TIME AND CHRYSLER IS AWARE OF THE PROBLEM, BUT IS NOT DOING ANYTHING ABOUT IT, RATHER THEY ARE MAKING MORE MONEY OFF OF THE CUSTOMERS IN THE REPAIRS. THERE ARE THOUSANDS OF COMPLAINTS ABOUT THIS ONLINE, AND NOW THIS IS THE THIRD REGULATOR MY CAR HAS HAD, WITH NO GUARANTEE I WON'T BE BACK AGAIN NEXT YEAR FOR ANOTHER. *TR
NHTSA ODI #10344744
Mileage unknown · Jul 9, 2010
Visibility
I HAVE A 2004 JEEP LIBERTY AND ON 4 SEPARATE OCCASIONS HAVE HAD THE DRIVER'S FRONT AND REAR WINDOWS FALL INTO THE DOOR UNEXPECTEDLY DUE TO A FAILED WINDOW REGULATOR. ON TWO OF THESE OCCASIONS THE WINDOW FAILURE OCCURRED WHILE THE VEHICLE WAS IN OPERATION. ON ALL FOUR OCCASIONS, THE DEALERSHIP CHARGED ME $325 TO FIX THE WINDOW …
Read full complaint
I HAVE A 2004 JEEP LIBERTY AND ON 4 SEPARATE OCCASIONS HAVE HAD THE DRIVER'S FRONT AND REAR WINDOWS FALL INTO THE DOOR UNEXPECTEDLY DUE TO A FAILED WINDOW REGULATOR. ON TWO OF THESE OCCASIONS THE WINDOW FAILURE OCCURRED WHILE THE VEHICLE WAS IN OPERATION. ON ALL FOUR OCCASIONS, THE DEALERSHIP CHARGED ME $325 TO FIX THE WINDOW EVEN THOUGH THEY ADMITTED THAT IT WAS DUE TO A FAULTY PART BECAUSE I WAS NO LONGER UNDER WARRANTY. THE REAR DRIVER WINDOW HAS FAILED ON 3 SEPARATE OCCASIONS, EACH TIME, WITHIN LESS THAN A YEAR OF HAVING THE REGULATOR REPLACED AT A JEEP AUTHORIZED DEALERSHIP. THE SERVICE MANAGER AT MY JEEP DEALERSHIP HAS ADMITTED TO ME THAT IT IS A FAULTY PART AND THAT THE RIGHT THING WOULD BE IF CHRYSLER WERE TO ISSUE A RECALL FOR THE PARTS. *TR
NHTSA ODI #10342175
105,200 miles · Jun 23, 2010
Visibility
MY 2004 JEEP LIBERTY HAS HAD THE SAME BROKEN WINDOW THREE SEPARATE TIMES. THE REGULATOR INSIDE THE WINDOW MOTOR IS POORLY DESIGNED AND SNAPS. I HAVE JUST READ HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT THIS AND SEVERAL OTHER PEOPLE SAID THEY FILED A COMPLAINT AS WELL. THE WINDOW BASICALLY FALLS DOWN, AND IT COULD HAVE EASIL…
Read full complaint
MY 2004 JEEP LIBERTY HAS HAD THE SAME BROKEN WINDOW THREE SEPARATE TIMES. THE REGULATOR INSIDE THE WINDOW MOTOR IS POORLY DESIGNED AND SNAPS. I HAVE JUST READ HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT THIS AND SEVERAL OTHER PEOPLE SAID THEY FILED A COMPLAINT AS WELL. THE WINDOW BASICALLY FALLS DOWN, AND IT COULD HAVE EASILY SHATTERED ALL OVER MY THREE YEAR OLD WHO WAS SITTING BESIDE THIS WINDOW. NOW IT IS 100+ DEGREES HERE AND I HAVE TO TRY TO UNSAFELY RIG THIS WINDOW SO IT DOESN'T FALL AND BREAK. CHRYSLER WILL GIVE AN ESTIMATE OF OVER $500 TO FIX THIS. THIS IS THE THIRD TIME. SOMETHING NEEDS TO BE DONE TO FIX THIS ISSUE AND NOW. *TR
NHTSA ODI #10339755
57,000 miles · Jun 13, 2010
Visibility
I HAVE A 2004 JEEP LIBERTY. THE PASSENGER SIDE WINDOW FELL INTO THE DOOR. TOOK IT TO A REPAIR SHOP AND WAS TOLD THE REGULATOR HAD FAILED. I HAVE READ SEVERAL INSTANCES OF THIS TYPE OF FAILURE ON THIS MODEL VEHICLE. WHY ISN'T THE NHTSA DOING ANYTHING ABOUT THIS? *TR
NHTSA ODI #10336021
91,000 miles · Jun 8, 2010
Visibility
THE DRIVER'S SIDE WINDOW REGULATOR FAILED AND THE WINDOW WAS INOPERABLE. THE REGULATOR WAS REPLACED BY A MECHANIC. *TR
NHTSA ODI #10335388
100 miles · Jun 8, 2010
Visibility
JEEP LIBERTY WINDOW REGULATOR BREAKS ALLOWING WINDOW TO FALL DOWN INTO DOOR AND REMAIN INOPERATIVE UNTIL FIXED. WE OWN A 2004 LIBERTY AND HAVE NOW HAD 12 REGULATORS REPAIRED/REPLACED OVER 6 YEARS BECAUSE OF SOME EXECUTIVE DECISION TO CUT COST WITH A PLASTIC PART VS STEEL. BEEN CAUGHT IN MONSOON WITH BROKEN WINDOW, 100+ DEGREE TE…
Read full complaint
JEEP LIBERTY WINDOW REGULATOR BREAKS ALLOWING WINDOW TO FALL DOWN INTO DOOR AND REMAIN INOPERATIVE UNTIL FIXED. WE OWN A 2004 LIBERTY AND HAVE NOW HAD 12 REGULATORS REPAIRED/REPLACED OVER 6 YEARS BECAUSE OF SOME EXECUTIVE DECISION TO CUT COST WITH A PLASTIC PART VS STEEL. BEEN CAUGHT IN MONSOON WITH BROKEN WINDOW, 100+ DEGREE TEMPERATURES WITH BROKEN WINDOW. THIS CAN HAPPEN AT ANY TIME/MILEAGE, MOVING OR STATIONARY, USING OR NOT USING WINDOWS. *TR
NHTSA ODI #10335379
35,000 miles · Jun 8, 2010
Visibility
PURCHASED VEHICLE USED, LOW MILES 32,764, JANUARY, 2009. AROUND EARLY AUGUST, 2009, THE PASSENGER WINDOW FELL DOWN AND WOULDN'T GO BACK UP. YOU COULD HEAR MOTOR RUNNING WHEN WINDOW SWITCH WAS PRESSED. CALLED CHRYSLER ON 8/10/09. THEY ADVISED WINDOW REGULATOR WAS KNOWN ISSUE WITH CHRYSLER (THEY ASSIGNED CASE NUMBER). ADVISED …
Read full complaint
PURCHASED VEHICLE USED, LOW MILES 32,764, JANUARY, 2009. AROUND EARLY AUGUST, 2009, THE PASSENGER WINDOW FELL DOWN AND WOULDN'T GO BACK UP. YOU COULD HEAR MOTOR RUNNING WHEN WINDOW SWITCH WAS PRESSED. CALLED CHRYSLER ON 8/10/09. THEY ADVISED WINDOW REGULATOR WAS KNOWN ISSUE WITH CHRYSLER (THEY ASSIGNED CASE NUMBER). ADVISED ME TO CALL DEALER. I DID. OUT OF STOCK. TOO, THEY WOULD HAVE TO OPEN DOOR PANEL AND CHARGE ME $59.95 JUST TO TAKE PANEL OFF. HE WOULD THEN HAVE TO CALL CHRYSLER ONCE THE PANEL WAS OFF TO SEE IF THEY WOULD AGREE TO FIX IT. RIDICULOUS. TOLD HIM TO CALL BACK WHEN IN STOCK. WHEN I DIDN'T HEAR BACK, I PHONED A COUPLE MORE TIMES AND THEN GAVE UP. WENT AHEAD AND HAD IT FIXED BY A REPAIR MAN 9/2/09 AT A COST OF $230. THE THIRD WEEK OF OCTOBER, 2009, THE REAR DRIVER SIDE WINDOW FELL DOWN A FEW INCHES AND WOULDN'T GO UP OR DOWN. THE REAR PASSENGER SIDE WINDOW WOULD NOT GO UP OR DOWN. YOU COULD AGAIN HEAR THE MOTOR RUNNING WHEN THE WINDOW SWITCHES WERE PUSHED. THE TWO REAR WINDOWS COST ME $400 TO HAVE FIXED WITH MY REPAIR MAN. I HAD GIVEN UP ON THE DEALER. IN ALL THREE INSTANCES, I WAS SHOWN THE BROKEN PART THAT WAS TAKEN OUT OF THE DOOR PANEL. THE CABLES ARE BREAKING FREE IN THE WINDOW REGULATORS. *TR
NHTSA ODI #10335288
50,020 miles · May 31, 2010
Visibility
I HAVE A 2004 JEEP LIBERTY THAT I HAVE HAD FOR ABOUT 3 YEARS. WITHIN THE LAST YEAR I HAVE NOW HAD TWO OF THE WINDOWS SUDDENLY STOP WORKING WITH NO WARNING. THE FIRST ONE WAS THE DRIVER'S SIDE BACKSEAT WINDOW. LAST YEAR I WAS PUTTING IT DOWN DUE TO THE HEAT. WHEN I WENT TO PUT IT UP, I COULD HEAR THE MOTOR TRYING TO WORK BUT …
Read full complaint
I HAVE A 2004 JEEP LIBERTY THAT I HAVE HAD FOR ABOUT 3 YEARS. WITHIN THE LAST YEAR I HAVE NOW HAD TWO OF THE WINDOWS SUDDENLY STOP WORKING WITH NO WARNING. THE FIRST ONE WAS THE DRIVER'S SIDE BACKSEAT WINDOW. LAST YEAR I WAS PUTTING IT DOWN DUE TO THE HEAT. WHEN I WENT TO PUT IT UP, I COULD HEAR THE MOTOR TRYING TO WORK BUT TO NO AVAIL. AFTER CHECKING IT OUT, I COULD ACTUALLY SEE A LONG, METAL CORD OR CABLE STICKING OUT OF THE SMALL HOLE IN THE DOOR. AT THE TIME I TOOK IT TO THE LOCAL JEEP DEALERSHIP AND THEY SAID IT WOULD BE ABOUT $500 TO FIX! UNFORTUNATELY, THIS IS TOO MUCH FOR ME SO I HAVE BEEN USING DOORSTOPS TO KEEP THE WINDOW UP. TODAY, I HAD A SIMILAR EXPERIENCE WITH THE DRIVER'S SIDE WINDOW. THIS TIME THE WINDOW WOULD NOT GO BACK UP. I JUST SPENT THE LAST HOUR DISSECTING THE DOOR AND PRYING THE WINDOW BACK UP. AFTER LOOKING ONLINE, THIS SEEMS TO BE A VERY BIG PROBLEM FOR THIS CAR. I DO FEEL SOMETHING SHOULD BE DONE BY CHRYSLER. *TR
NHTSA ODI #10333962
Mileage unknown · May 21, 2010
Visibility
TWO WINDOW REGULATORS IN MY JEEP LIBERTY FAILED AND THE WINDOWS DROPPED. IT HAPPENED DURING A RAINSTORM AND I NEARLY DROVE OFF THE ROAD INTO A DITCH BECAUSE OF IT. SOMEONE IS GOING TO DIE BECAUSE OF THIS. THE WINDOWS JUST DROPPED. I HAD TO PUT A PERMANENT SUPPORT IN PLACE TO PREVENT THE WINDOW FROM FALLING. IT'S A COMMON PROBLEM…
Read full complaint
TWO WINDOW REGULATORS IN MY JEEP LIBERTY FAILED AND THE WINDOWS DROPPED. IT HAPPENED DURING A RAINSTORM AND I NEARLY DROVE OFF THE ROAD INTO A DITCH BECAUSE OF IT. SOMEONE IS GOING TO DIE BECAUSE OF THIS. THE WINDOWS JUST DROPPED. I HAD TO PUT A PERMANENT SUPPORT IN PLACE TO PREVENT THE WINDOW FROM FALLING. IT'S A COMMON PROBLEM AND CHRYSLER WILL NOT ADDRESS IT. SAFETY IS BEING COMPROMISED FOR PROFIT. *TR
NHTSA ODI #10331555
40,233 miles · May 14, 2010
Visibility
2004 JEEP LIBERTY WINDOWS FALL DOWN. REGULATORS ARE JUNK!!! THIS IS MY 5TH REPLACEMENT!!! *TR
NHTSA ODI #10330462
Official recalls
7May 1, 2018
Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.
Consequence & remedy
Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.
Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Mar 5, 2012
IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.
Consequence & remedy
Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Aug 3, 2006
ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.
Consequence & remedy
Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jul 8, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.7L ENGINES ONLY, TWO VALVE COVER STUDS MAY INTERFERE WITH THE FUEL INJECTOR AND ALTERNATOR WIRING HARNESSES.
Consequence & remedy
Consequence: DAMAGE TO THE ALTERNATOR WIRING HARNESS COULD RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL ADD PROTECTIVE CAPS TO THE VALVE COVER STUDS AND RE-ROUTE THE AFFECTED WIRING HARNESS TO PROVIDE CLEARANCE. OWNER NOTIFICATION BEGAN ON JULY 19, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 4, 2004
ON SOME SPORT UTILITY VEHICLES, CERTAIN REMOTE KEYLESS ENTRY (RKE) INPUT MAY CAUSE THE BODY CONTROL MODULE (BCM) SOFTWARE TO ACTUATE THE DOOR LOCK MOTORS CONTINUOUSLY.
Consequence & remedy
Consequence: THIS CAN CAUSE THE LOCK MOTOR BEARINGS TO OVERHEAT AND SEIZE. IF THIS OCCURS, THE DOOR LOCK SYSTEM WILL BECOME INOPERATIVE.
Remedy: DEALERS WILL INSPECT AND REPLACE, AS NECESSARY, THE DOOR LATCH ASSEMBLIES AND THE BCM SOFTWARE WILL BE UPDATED. OWNER NOTIFICATION BEGAN ON MAY 10, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 3, 2004
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A RECENT SOFTWARE PROGRAMMING ERROR, THE TIRE, WHEEL, AND INFLATION PRESSURE INFORMATION WAS INADVERTENTLY OMITTED FROM THE VEHICLE CERTIFICATION LABEL.
Consequence & remedy
Consequence: THE VEHICLE OWNER WOULD NOT BE AWARE OF THE TIRE, WHEEL, AND INFLATION PRESSURE INFORMATION FOR THEIR VEHICLE.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED TIRE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN ON MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
EA11013 · Rear Suspension Control Arm Failure
Opened Sep 15, 2011 · Closed Mar 14, 2012
Status: closed (inferred from source dates) · Suspension; Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Additional source detail variants (2)
Suspension
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
PE11013 · Rear Suspension Control Arm Failure
Opened Apr 18, 2011 · Closed Sep 15, 2011
Status: closed (inferred from source dates) · Suspension:rear
During Preliminary Evaluation (PE11-013), the Office of Defects Investigation (ODI) conducted an analysis of consumer field data from its Vehicle Owner Questionnaire (VOQ) database and from complaint data submitted to ODI by Chrysler. ODI's analysis of VOQ data identified 13 complaints alleging failure of either the right or left rear lower control arm due to excessive corrosion.All of these complaints were associated with vehicles originally sold or registered in a salt belt state (for the purposes of this investigation, 'salt belt' includes Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).All of the complaints were associated with vehicles manufactured in model years (MY) 2004 or 2005. Three of these complaints also allege a loss of vehicle control due to the rear lower control arm failure. No complaints related to the alleged defect were identified on vehicles manufactured during MYs 2002 or 2003. Similarly an analysis of Chrysler complaint data identified 11 complaints (2 of which are duplicative of VOQs) alleging failure of a rear lower control arm due to excessive corrosion.All 11 of these complaints were from consumers operating vehicles in a salt belt state and vehicles manufactured in either MY 2004 or 2005. Three of these complaints (not duplicative of VOQs) also allege a loss of vehicle control due to the rear lower control arm failure.The original scope of PE11-013 included MY 2002 through 2005 Jeep Liberty vehicles as they were in the same generation.In response to an Information Request (IR) letter sent by ODI, Chrysler provided information and sample components identifying a substantial design change of the rear lower control arms after MY 2003 and beginning with MY 2004.Analysis of complaint data from both data sources (ODI and Chrysler) did not identify any applicable complaints (lower control arm failures due to excessive corrosion) from vehicles manufactured during MY 2002 or 2003.Similarly no complaints from either data source were found in states outside of those identified as salt belt states.Chrysler stated in its IR letter response that its investigation and analysis is ongoing to determine the scope, possible root causes of the unusual lower control arm corrosion, and define possible consequences to motor vehicle safety. Based on ODI's data analysis from both sources (ODI and Chrysler data), this investigation has been upgraded to an Engineering Analysis (EA11-013) focused on vehicles originally sold or registered in a salt belt state and produced during MY 2004 and 2005, to further assess the scope and potential safety consequences of the alleged defect.
EA06008 · Front Suspension Ball Joint Separation
Opened May 31, 2006 · Closed Aug 24, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE06004 · Front Suspension Ball Joint Separation
Opened Jan 6, 2006 · Closed May 31, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATION WHILE DRIVING IN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.ODI IS AWARE OF 93 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF TWO ALLEGED INJURY INCIDENTS RELATED TO THE ALLEGED DEFECT (ONE CRASH INCIDENT AND ONE NON-CRASH INCIDENT), BOTH RESULTING IN MINOR INJURY.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S DEFECT INFORMATION REPORT TO THE AGENCY (IN ACCORDANCE WITH 49 CFR PART 573) DATED NOVEMBER 4, 2003, ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATION IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT AND THE ADEQUACY OF THE REMEDY PROVIDED BY THE PRIOR SAFETY RECALL.
Illustration