NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
34 reportsClear category filterMileage unknown · Oct 16, 2015
SuspensionUnknown Or Other
MY 2004 JEEP LIBERTY WAS A RECALL WHICH I TOOK TO CHRYSLER FOR TO GET REPAIR FOR FRONT AND BACK SUSPENSION AND REPAIR AND GASOLINE TANK APPARENTLY WHEN I GOT MY VEHICLE BACK OIL WAS LEAKING ALL OVER THE ENGINE I TOOK MY VEHICLE BACK 2 DAYS AGO TO BE TOLD THAT THE COULD NOT HELP ME THEIR WAS NO OIL LEAKING WHEN I BROUGHT IT I…
Read full complaint
MY 2004 JEEP LIBERTY WAS A RECALL WHICH I TOOK TO CHRYSLER FOR TO GET REPAIR FOR FRONT AND BACK SUSPENSION AND REPAIR AND GASOLINE TANK APPARENTLY WHEN I GOT MY VEHICLE BACK OIL WAS LEAKING ALL OVER THE ENGINE I TOOK MY VEHICLE BACK 2 DAYS AGO TO BE TOLD THAT THE COULD NOT HELP ME THEIR WAS NO OIL LEAKING WHEN I BROUGHT IT IN THEY REFUSE TO ASSIST ME WITH THE PROBLEM CAN YOU PLEASE HELP ME
NHTSA ODI #10782610
Mileage unknown · Oct 8, 2015
Unknown Or Other
THERE IS A RECALL ON MY CAR FOR THE GAS TANK BEING TOO CLOSE TO THE REAR BUMPER. I BROUGHT IT TO JEEP IN NELLISTON,N.Y. THEY INSTALL A TRAILER HITCH TO CORRECT THE PROBLEM.THEY WORKED ON IT FOR ONE HOUR, AND THEN TOLD ME THEY CAN'T INSTALL THE TRAILER HITCH,BECAUSE THEY BROKE A HOLE TAP OFF IN ONE OF THE MOUNTING HOLES, THIS IS …
Read full complaint
THERE IS A RECALL ON MY CAR FOR THE GAS TANK BEING TOO CLOSE TO THE REAR BUMPER. I BROUGHT IT TO JEEP IN NELLISTON,N.Y. THEY INSTALL A TRAILER HITCH TO CORRECT THE PROBLEM.THEY WORKED ON IT FOR ONE HOUR, AND THEN TOLD ME THEY CAN'T INSTALL THE TRAILER HITCH,BECAUSE THEY BROKE A HOLE TAP OFF IN ONE OF THE MOUNTING HOLES, THIS IS NOT MY FAULT, THEY WILL NOT CORRECT MY RECALL, AND THEY WILL NOT EVEN CALL ME BACK, THEY TELL ME THERE IS NOTHING THEY CAN DO. SO THEY ARE NOT GOING TO HONOR THE RECALL ON MY CAR, AS FAR AS THEY ARE CONCERNED, I CAN JUST GO AHEAD AND BURN UP IN MY CAR, IF I GET REAR ENDED,
NHTSA ODI #10780933
Mileage unknown · Sep 30, 2015
Unknown Or Other
THE WINDOW ACTUATOR CAME APART AND WRAPPED AROUND THE DOOR LATCH MECHANISM IN THE BACK WHERE MY TODDLER SETS, WE WERE UNABLE TO OPEN THE DOOR. MY HUSBAND HAD TO TAKE THE DOOR PANEL APART FROM THE INSIDE AND CUT THE WIRE IN ORDER FOR THE DOOR TO BE OPENED. ALL OF MY WINDOW ACTUATORS HAVE STOPPED WORKING AND HAVE HAD TO BE REPLA…
Read full complaint
THE WINDOW ACTUATOR CAME APART AND WRAPPED AROUND THE DOOR LATCH MECHANISM IN THE BACK WHERE MY TODDLER SETS, WE WERE UNABLE TO OPEN THE DOOR. MY HUSBAND HAD TO TAKE THE DOOR PANEL APART FROM THE INSIDE AND CUT THE WIRE IN ORDER FOR THE DOOR TO BE OPENED. ALL OF MY WINDOW ACTUATORS HAVE STOPPED WORKING AND HAVE HAD TO BE REPLACED.
NHTSA ODI #10778749
183,150 miles · Sep 7, 2015
Electrical SystemPower TrainUnknown Or Other
I WAS DRIVING UP THE STREET HEARD SOMETHING LIKE A RAN OVER SOMETHING THEN JEEP CUT OFF GOT OUT TO SEE IF I RAN OVER SOMETHING BUT NOTHING WAS THERE AND JEEP WOULD NOT START BACK UP, WHAT IF I HAD BEEN ON THE HIGHWAY OR BUSY TRAFFIC I COULD HAVE BEEN SERIOUSLY HURT, WHICH U AM BLESSED THAT DID NOT HAPPEN, THE PROBLEM I HAVE IS C…
Read full complaint
I WAS DRIVING UP THE STREET HEARD SOMETHING LIKE A RAN OVER SOMETHING THEN JEEP CUT OFF GOT OUT TO SEE IF I RAN OVER SOMETHING BUT NOTHING WAS THERE AND JEEP WOULD NOT START BACK UP, WHAT IF I HAD BEEN ON THE HIGHWAY OR BUSY TRAFFIC I COULD HAVE BEEN SERIOUSLY HURT, WHICH U AM BLESSED THAT DID NOT HAPPEN, THE PROBLEM I HAVE IS CHRYSLER SHOULD NOTAKE ANYTHING THAT COULD CAUSE YOU BODILY HARM. A COMPUTER SHOULD NEVER GO OUT THAT IS DANGEROUS. I HAD TO HAVE THE JEEP TOWED TO MY HOME AND THEN TO A SHIP ON TWO DIFFERENT TIMES AN ONE TIME BACK HOME FROM THE SHOP BECAUSE I DID NOT HAVE 900.00 TO REPAIR. SO I'M STUCK WITHOUT HAVING MY JEEP REPAIRED BECAUSE I'M ON A FIXED INCOME. ALSO HAVING ELECTRICAL PROBLEM WHERE CHRYSLER DID POOR WIRING., CIGARETTE LIGHTER KEEP GOING OUT, BLINKER AND RADIO WIRING IS TERRIBLE AND ONE OF THE FRONT LIGHTS. CHRYSLER YOU GOT TO DO A BETTER JOB, BECAUSE I LOVED MY JEEP, BUT VERY DISAPPOINTED BECAUSE I CAN'T AFFORD TO HAVE IT REPAIR.
NHTSA ODI #10761956
100,032 miles · Aug 30, 2015
Unknown Or Other
WINDOW REGULATOR HAS FAILED ON FRONT PASSENGER WINDOW AND MANY REPORTS THIS IS DUE TO A CHEAP PLASTIC ASSEMBLY THAT SUPPORTS THE GLASS INSTEAD OF METAL.IT IS THE MANUFACTURES FAULT AS THIS FAILS FOR NO REASON.MY WINDOW WAS TILTED WHEN I GOT IN IT THIS MORNING,NO VANDALISM ,NOR STORMS.IT MAKE A WHIRRING NOISE WHEN USING THE UP BU…
Read full complaint
WINDOW REGULATOR HAS FAILED ON FRONT PASSENGER WINDOW AND MANY REPORTS THIS IS DUE TO A CHEAP PLASTIC ASSEMBLY THAT SUPPORTS THE GLASS INSTEAD OF METAL.IT IS THE MANUFACTURES FAULT AS THIS FAILS FOR NO REASON.MY WINDOW WAS TILTED WHEN I GOT IN IT THIS MORNING,NO VANDALISM ,NOR STORMS.IT MAKE A WHIRRING NOISE WHEN USING THE UP BUTTON AND WENT STRAIGHT WITH THE CABLE FROM THE REGULATOR SNAKING UP THE SIDE OF THE DOOR.IT IS UP NOW BUT WITH ALL THE INFO FOUND FEELING I SHOULD NOT PAY FOR IT AND THE ISSUE JUST REPEATS ITSELF AFTER REPLACEMENT BECAUSE OF INADEQUATE EQUIPMENT. PLEASE HELP ME AND SO MANY OTHERS HAVING THE SAME EXPERIENCE. I CAN SEE HOW THIS WOULD BE CONSIDERED A DANGEROUS ON THE HIGHWAY. PLEASE USE THE ATTACHED LINK TO SEE MANY MORE REPORTS OF THE SAME ISSUE HTTP://WWW.CARCOMPLAINTS.COM/JEEP/LIBERTY/2004/WINDOWS_WINDSHIELD/WINDOWS_FAIL.SHTML
NHTSA ODI #10760224
165,000 miles · Jun 10, 2015
Unknown Or Other
THE REAR WINDOW ON THE DRIVER'S SIDE DROPPED INTO THE DOOR TODAY. I LOOKED IT UP ONLINE AND IT APPEARS TO BE RELATED TO THE WINDOW REGULATOR AND IT IS A COMMONLY REPORTED PROBLEM. IF IT IS SO COMMON, I HAVE TROUBLE BELIEVING THAT THEY WOULDN'T CREATE A RECALL. I GUESS JEEP IS WAITING FOR A LARGE NUMBER OF INJURIES FIRST.
NHTSA ODI #10724502
42,000 miles · Jun 23, 2012
Latches/locks/linkagesUnknown Or OtherVisibility
REAR DRIVER'S SIDE WINDOW FELL INTO DOOR. COULD NOT GET IT BACK UP. WINDOW IS NOW HELD IN BY ZIP TIES. 6/23/2012 FRONT PASSENGER POWER DOOR LOCK STOPPED WORKING. PURCHASED VEHICLE USED IN JUNE 2007, REAR PASSENGER POWER DOOR LOCK NOT WORKING AT THAT TIME. OCCAISIONALLY VEHICLE WILL STALL AND RESTART WHILE DRIVING. *…
Read full complaint
REAR DRIVER'S SIDE WINDOW FELL INTO DOOR. COULD NOT GET IT BACK UP. WINDOW IS NOW HELD IN BY ZIP TIES. 6/23/2012 FRONT PASSENGER POWER DOOR LOCK STOPPED WORKING. PURCHASED VEHICLE USED IN JUNE 2007, REAR PASSENGER POWER DOOR LOCK NOT WORKING AT THAT TIME. OCCAISIONALLY VEHICLE WILL STALL AND RESTART WHILE DRIVING. *TT
NHTSA ODI #10462819
61,000 miles · Mar 29, 2011
Unknown Or Other
2004 JEEP LIBERTY SECOND REPLACEMENT OF A REAR WINDOW REGULATOR/MOTOR
NHTSA ODI #10393653
42,000 miles · Feb 15, 2011
Unknown Or Other
THE FIRST TIME THIS HAPPENED, I WAS DRIVING HOME FROM WORK, AND THE PASSENGER SIDE, FRONT WINDOW FELL INTO THE DOOR. AT FIRST, I DID NOT KNOW WHAT HAD HAPPENED, I JUST HEARD A LOUD "BANG" FROM THE SIDE OF MY CAR - I THOUGHT THAT SOMETHING MAY HAVE HIT THE CAR. FORTUNATELY, I WAS ONLY GOING ABOUT 35 MPH WHEN THIS OCCURRED, AND I …
Read full complaint
THE FIRST TIME THIS HAPPENED, I WAS DRIVING HOME FROM WORK, AND THE PASSENGER SIDE, FRONT WINDOW FELL INTO THE DOOR. AT FIRST, I DID NOT KNOW WHAT HAD HAPPENED, I JUST HEARD A LOUD "BANG" FROM THE SIDE OF MY CAR - I THOUGHT THAT SOMETHING MAY HAVE HIT THE CAR. FORTUNATELY, I WAS ONLY GOING ABOUT 35 MPH WHEN THIS OCCURRED, AND I WAS LEVEL HEADED ENOUGH TO KEEP DRIVING THE CAR IN MY LANE. THIS WAS ON ROUTE 35 IN EATONTOWN, NJ, WHICH IS A BUSY HIGHWAY DURING RUSH HOUR WHEN THIS INCIDENT OCCURRED. THE 2ND TIME THIS HAPPENED, THE REAR PASSENGER SIDE WINDOW FELL INTO THE DOOR. THIS WAS IN JUNE 2010, 47,000 MILES. THE THIRD TIME THIS HAPPENED, THE DRIVER SIDE FRONT WINDOW FELL INTO THE DOOR. THIS WAS FEBRUARY 14, 2011, 50,000 MILES. THANK GOD I WAS NOT DRIVING ON THE GARDEN STATE PARKWAY WHEN THESE INCIDENTS OCCURRED. I HAVE RECEIPTS FOR THE REPAIRS. I JUST GOT OFF THE PHONE WITH CHRYSLER, AND THEY ISSUED AN EXTENDED WARRANTY FOR THE 2006 AND 2007 MODELS, BUT NOT FOR THE 2004 JEEP LIBERTY MODELS. THE REAR WINDOW PASSENGER SIDE HAS NOT FALLEN INTO THE DOOR YET. MY GRANDSON'S CAR SEAT IS NEXT TO THAT WINDOW. I KNOW THAT IT IS UNSAFE, BUT I AM LOSING MY JOB THIS YEAR BECAUSE OF FORT MONMOUTH CLOSING. I AM NOW SERIOUSLY THINKING ABOUT GETTING A NEW CAR WHEN I FIND A NEW JOB. THE COMPONENT THAT FAILS IS THE WINDOW REGULATOR. IT HOLDS THE WINDOW IN PLACE, AND WHEN IT FAILS, THE WINDOW FALLS INTO THE DOOR.
NHTSA ODI #10383608
70,000 miles · Jan 5, 2011
Unknown Or Other
I WAS DRIVING UP TO KIDS SCHOOL TO PARK AND PARKED AND TRIED TO TAKE THE SEAT BELT OFF AND IT WAS STUCK. THE RED RELEASE BUTTON WAS STUCK DOWN. I WAS ABLE TO GET IT RELEASED, BUT THE RED RELEASE BUTTON WAS STILL STUCK DOWN. I TRIED TO RE-BUCKLE AND NOTHING WORKED. I WENT TO THE DEALERSHIP "NAPLETONS" AND THEY SAID THAT THE P…
Read full complaint
I WAS DRIVING UP TO KIDS SCHOOL TO PARK AND PARKED AND TRIED TO TAKE THE SEAT BELT OFF AND IT WAS STUCK. THE RED RELEASE BUTTON WAS STUCK DOWN. I WAS ABLE TO GET IT RELEASED, BUT THE RED RELEASE BUTTON WAS STILL STUCK DOWN. I TRIED TO RE-BUCKLE AND NOTHING WORKED. I WENT TO THE DEALERSHIP "NAPLETONS" AND THEY SAID THAT THE PART WAS ON NATIONAL BACK ORDER. I AM STILL WAITING.
NHTSA ODI #10375741
Official recalls
7May 1, 2018
Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.
Consequence & remedy
Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.
Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Mar 5, 2012
IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.
Consequence & remedy
Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Aug 3, 2006
ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.
Consequence & remedy
Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jul 8, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.7L ENGINES ONLY, TWO VALVE COVER STUDS MAY INTERFERE WITH THE FUEL INJECTOR AND ALTERNATOR WIRING HARNESSES.
Consequence & remedy
Consequence: DAMAGE TO THE ALTERNATOR WIRING HARNESS COULD RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL ADD PROTECTIVE CAPS TO THE VALVE COVER STUDS AND RE-ROUTE THE AFFECTED WIRING HARNESS TO PROVIDE CLEARANCE. OWNER NOTIFICATION BEGAN ON JULY 19, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Mar 4, 2004
ON SOME SPORT UTILITY VEHICLES, CERTAIN REMOTE KEYLESS ENTRY (RKE) INPUT MAY CAUSE THE BODY CONTROL MODULE (BCM) SOFTWARE TO ACTUATE THE DOOR LOCK MOTORS CONTINUOUSLY.
Consequence & remedy
Consequence: THIS CAN CAUSE THE LOCK MOTOR BEARINGS TO OVERHEAT AND SEIZE. IF THIS OCCURS, THE DOOR LOCK SYSTEM WILL BECOME INOPERATIVE.
Remedy: DEALERS WILL INSPECT AND REPLACE, AS NECESSARY, THE DOOR LATCH ASSEMBLIES AND THE BCM SOFTWARE WILL BE UPDATED. OWNER NOTIFICATION BEGAN ON MAY 10, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 3, 2004
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A RECENT SOFTWARE PROGRAMMING ERROR, THE TIRE, WHEEL, AND INFLATION PRESSURE INFORMATION WAS INADVERTENTLY OMITTED FROM THE VEHICLE CERTIFICATION LABEL.
Consequence & remedy
Consequence: THE VEHICLE OWNER WOULD NOT BE AWARE OF THE TIRE, WHEEL, AND INFLATION PRESSURE INFORMATION FOR THEIR VEHICLE.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED TIRE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN ON MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
EA11013 · Rear Suspension Control Arm Failure
Opened Sep 15, 2011 · Closed Mar 14, 2012
Status: closed (inferred from source dates) · Suspension; Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Additional source detail variants (2)
Suspension
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
PE11013 · Rear Suspension Control Arm Failure
Opened Apr 18, 2011 · Closed Sep 15, 2011
Status: closed (inferred from source dates) · Suspension:rear
During Preliminary Evaluation (PE11-013), the Office of Defects Investigation (ODI) conducted an analysis of consumer field data from its Vehicle Owner Questionnaire (VOQ) database and from complaint data submitted to ODI by Chrysler. ODI's analysis of VOQ data identified 13 complaints alleging failure of either the right or left rear lower control arm due to excessive corrosion.All of these complaints were associated with vehicles originally sold or registered in a salt belt state (for the purposes of this investigation, 'salt belt' includes Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).All of the complaints were associated with vehicles manufactured in model years (MY) 2004 or 2005. Three of these complaints also allege a loss of vehicle control due to the rear lower control arm failure. No complaints related to the alleged defect were identified on vehicles manufactured during MYs 2002 or 2003. Similarly an analysis of Chrysler complaint data identified 11 complaints (2 of which are duplicative of VOQs) alleging failure of a rear lower control arm due to excessive corrosion.All 11 of these complaints were from consumers operating vehicles in a salt belt state and vehicles manufactured in either MY 2004 or 2005. Three of these complaints (not duplicative of VOQs) also allege a loss of vehicle control due to the rear lower control arm failure.The original scope of PE11-013 included MY 2002 through 2005 Jeep Liberty vehicles as they were in the same generation.In response to an Information Request (IR) letter sent by ODI, Chrysler provided information and sample components identifying a substantial design change of the rear lower control arms after MY 2003 and beginning with MY 2004.Analysis of complaint data from both data sources (ODI and Chrysler) did not identify any applicable complaints (lower control arm failures due to excessive corrosion) from vehicles manufactured during MY 2002 or 2003.Similarly no complaints from either data source were found in states outside of those identified as salt belt states.Chrysler stated in its IR letter response that its investigation and analysis is ongoing to determine the scope, possible root causes of the unusual lower control arm corrosion, and define possible consequences to motor vehicle safety. Based on ODI's data analysis from both sources (ODI and Chrysler data), this investigation has been upgraded to an Engineering Analysis (EA11-013) focused on vehicles originally sold or registered in a salt belt state and produced during MY 2004 and 2005, to further assess the scope and potential safety consequences of the alleged defect.
EA06008 · Front Suspension Ball Joint Separation
Opened May 31, 2006 · Closed Aug 24, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE06004 · Front Suspension Ball Joint Separation
Opened Jan 6, 2006 · Closed May 31, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATION WHILE DRIVING IN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.ODI IS AWARE OF 93 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF TWO ALLEGED INJURY INCIDENTS RELATED TO THE ALLEGED DEFECT (ONE CRASH INCIDENT AND ONE NON-CRASH INCIDENT), BOTH RESULTING IN MINOR INJURY.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S DEFECT INFORMATION REPORT TO THE AGENCY (IN ACCORDANCE WITH 49 CFR PART 573) DATED NOVEMBER 4, 2003, ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATION IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-008) TO FURTHER STUDY THE FREQUENCY AND SCOPE OF THE ALLEGED DEFECT AND THE ADEQUACY OF THE REMEDY PROVIDED BY THE PRIOR SAFETY RECALL.
Illustration