NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
418 reportsClear category filter10,000 miles · Apr 25, 2004
Service Brakes, Hydraulic
I HAVE A 2000 JEEP WITH RECURRING PROBLEMS WITH WHAT I AM TOLD ARE THE BRAKE ROTORS. THEY APPARENTLY KEEP WARPING, CAUSING MODERATE TO SEVERE SHIMMYING WHEN BRAKING AT HIGHER SPEEDS AND PULSATING WHEN BRAKING AT LOWER SPEEDS. AT 10,531 MILES I BROUGHT THE CAR IN. THEY RESURFACED THE ROTARS WHICH THEY CLAIM THE MANUFACTURER CLAIM…
Read full complaint
I HAVE A 2000 JEEP WITH RECURRING PROBLEMS WITH WHAT I AM TOLD ARE THE BRAKE ROTORS. THEY APPARENTLY KEEP WARPING, CAUSING MODERATE TO SEVERE SHIMMYING WHEN BRAKING AT HIGHER SPEEDS AND PULSATING WHEN BRAKING AT LOWER SPEEDS. AT 10,531 MILES I BROUGHT THE CAR IN. THEY RESURFACED THE ROTARS WHICH THEY CLAIM THE MANUFACTURER CLAIMED WOULD FIX THE PROBLEM. THEN AT 26,579 MILES I WAS BACK AT THE DEALER. THEY TOLD ME THE MANUFACTURER HAD A DIFFERENT SOLUTION. THEY REPLACED THE ROTORS, BRAKES AND CALIPERS. I WAS SKEPTICAL THAT THEY WERE REPLACING A DEFECTIVE PART WITH THE SAME DEFECTIVE PART. I TOLD THEM I HAD A 1995 GRAND CHEREKEE THAT HAD OVER 100 THOUSAND MILES AND NEVER HAD ANY PROBLEM WITH ROTARS SO WHY DIDN'T THE MANUFACTURER JUST USE THE 1995 PART BUT, AGAIN, I WAS ASSURED THE NEW ROTARS WERE DIFFERENT AND DEFECT FREE. NOW I HAVE 49,000 MILES ON THE CAR AND IT IS AGAIN AT THE DEALER FOR THE SAME PROBLEM. THE DEALER AND MANUFACTERER SAY THEY WILL NOT MAKE ANY FURTHER REPAIRS.THE SERVICE MANAGER TOLD ME I HAD THREE OPTIONS. ONE,THEY WOULD REPLACE THE ROTARS FOR $240.00. TWO,DO NOTHING BECAUSE THE MANUFACTURER ASSURES ME THAT THE PROBLEM DOES NOT EFFECT SAFETY OR MAINTENANCE FOR ANY OTHER PARTS ON THE VEHICLE.(WHICH BY THE WAY I FIND TO BE A LUDICROUS STATEMENT AND A CALLOUS DISREGARD FOR THE SAFETY OF THEIR OWN CONSUMERS LET ALONE OTHERS ON THE ROAD SINCE THE CAR BECOMES VERY HARD TO CONTROL WHEN THE FRONT END IS SHAKING VIOLENTLY) AND THIRD, I COULD BUY THE PART FROM A NON-DEALER AT AFTER MARKET PRICES AND GET ROTARS MADE OF A DIFFERENT AND PRESUMABLY STRONGER MATERIAL. NONE OF THESE OPTIONS WERE APPEALING SINCE EXPERIENCE WITH TWO JEEPS PRIOR TO THIS ONE DICTATED THAT THIS WAS NOT NORMAL WEAR AND TEAR, HAD NOTHING TO DO WITH MY DRIVING, AND WAS CLEARLY A DEFECTIVE PART. *AK
NHTSA ODI #10067777
Mileage unknown · Apr 19, 2004
Service Brakes, Hydraulic
THE BRAKES ON MY VEHICLE HAVE TO BE CONSISTENTLY REPAIRED. I HAVE BROUGHT THE VEHICLE TO THE DEALER THREE TIMES AND THE JEEP ONLY HAS 45,000 MILES. I HAVE ANOTHER JEEP THAT HAS ALSO BEEN BROUGHT IN THREE TIMES AND IT HAS LESS THAN 25,000 MILES. ALL FOR BAD BRAKES WHICH I'M CONSISTENTLY TOLD , " IS A KNOWN DEFECT" BY CHRYSLER …
Read full complaint
THE BRAKES ON MY VEHICLE HAVE TO BE CONSISTENTLY REPAIRED. I HAVE BROUGHT THE VEHICLE TO THE DEALER THREE TIMES AND THE JEEP ONLY HAS 45,000 MILES. I HAVE ANOTHER JEEP THAT HAS ALSO BEEN BROUGHT IN THREE TIMES AND IT HAS LESS THAN 25,000 MILES. ALL FOR BAD BRAKES WHICH I'M CONSISTENTLY TOLD , " IS A KNOWN DEFECT" BY CHRYSLER AND THE TECHNICAL STAFF.*AK
NHTSA ODI #10066487
Mileage unknown · Apr 7, 2004
EquipmentService Brakes, Hydraulic
I BOUGHT MY JEEP 6 MONTHS AGO. IT NOW HAS 79000 MILES AND I HAVE NO CLUE HOW MANY TIMES THE PREVIOUS OWNER CHANGED THE ROTORS. I ALSO HAVE THE PROBLEM OF A VIBRATING UNCONTROLLABLY WHEEL WHEN I START TO BREAK AT 30 MPH OR OVER. I GUESS I WILL HAVE TO CHANGE MY FRONT ROTORS AND THEN DEAL WITH IT AGAIN IN 20,000 MILES. I FIND …
Read full complaint
I BOUGHT MY JEEP 6 MONTHS AGO. IT NOW HAS 79000 MILES AND I HAVE NO CLUE HOW MANY TIMES THE PREVIOUS OWNER CHANGED THE ROTORS. I ALSO HAVE THE PROBLEM OF A VIBRATING UNCONTROLLABLY WHEEL WHEN I START TO BREAK AT 30 MPH OR OVER. I GUESS I WILL HAVE TO CHANGE MY FRONT ROTORS AND THEN DEAL WITH IT AGAIN IN 20,000 MILES. I FIND THIS TO BE RIDICULOUS. *AK
NHTSA ODI #10065729
6,000 miles · Apr 2, 2004
Service Brakes, Hydraulic
I HAVE HAD THE BRAKES FIXED ON MY 2000 JEEP GRAND CHEROKEE 3 TIMES. THE STEERING WHEEL SHAKES AND VIBRATES UNCONTROLLABLY WHEN THE BRAKES ARE APPLIED AT ANY SPEED. IT IS HARD TO CONTROL THE CAR, ESPECIALLY ON THE INTERSTATE. I HAVE A REAL CONCERN FOR MY SAFETY AND MY PASSENGERS SAFETY. I WENT TO GET THEM FIXED FOR THE FOURT…
Read full complaint
I HAVE HAD THE BRAKES FIXED ON MY 2000 JEEP GRAND CHEROKEE 3 TIMES. THE STEERING WHEEL SHAKES AND VIBRATES UNCONTROLLABLY WHEN THE BRAKES ARE APPLIED AT ANY SPEED. IT IS HARD TO CONTROL THE CAR, ESPECIALLY ON THE INTERSTATE. I HAVE A REAL CONCERN FOR MY SAFETY AND MY PASSENGERS SAFETY. I WENT TO GET THEM FIXED FOR THE FOURTH TIME, WITH ONLY 20,000 MILES ON THE CAR, AND I WAS TOLD I HAD TO PAY FOR IT, SINCE MY WARRANTY HAD JUST EXPIRED 3 MONTHS PRIOR. THIS PROBLEM REALLY SHOULD BE RECALLED. AND CHRYSLER IS NOT VERY NICE ABOUT ANY SITUATION LIKE THIS. THEY DON'T CARE HOW INCONVENIENCED YOU ARE. THEY NEVER OFFER YOU A CAR, WHILE YOURS IS SUPPOSE TO BE "BEING FIXED." I ONLY WISH IT WAS FIXED. NO MORE JEEPS FOR ME. IT'S A LEMON!! *JB
NHTSA ODI #10064370
Mileage unknown · Apr 1, 2004
Engine And Engine CoolingExterior LightingFuel System, Gasoline
CONSUMER STARTED EXPERIENCING PROBLEMS WITH THE BRAKES NINE MONTHS AFTER PURCHASE. *PH THE CONSUMER HAD ROTORS REPLACED SEVERAL TIMES. THERE WAS AN EXCESSIVE CRANK WHEN THE CONSUMER ATTEMPTED TO START THE VEHICLE, THE DEALER REPLACED THE FUEL PUMP QUAD RING. THE TAIL LIGHT BULB AND WATER PUMP WAS REPLACED. *JB
NHTSA ODI #10066870
Mileage unknown · Mar 30, 2004
Engine And Engine CoolingService Brakes, Hydraulic
WHEN APPLYING THE BRAKES AT ANY SPEED VEHICLE SHOOK. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE BRAKES, ROTORS AND CATALYTIC CONVERTER NEEDED TO BE REPLACED. *AK
NHTSA ODI #10065247
Mileage unknown · Mar 29, 2004
Service Brakes, Hydraulic
WHEN DEPRESSING THE BRAKE PEDAL AT ANY SPEED CONSUMER NOTICED THE BRAKE PEDAL PULSATED. VEHICLE WAS SERVICED SIX TIMES FOR BRAKES AND ROTORS, BUT PROBLEM RECURRED. *AK
NHTSA ODI #10065122
15,000 miles · Mar 18, 2004
Service Brakes, Hydraulic
MY 2000 GRAND HAS HAD THE ROTORS REPLACED OR RESURFACED 3 TIMES UNDER WARRANTY AND TWICE AT MY EXPENSE. BRAKES MAKE IT ALMOST IMPOSSIBLE TO STOP THE CAR AT SPEEDS OVER 55 MPH. UNSAFE TO DRIVE. DEALER CLAIMS THAT THE PROBLEM WAS FIXED FOR THE 2004 MODELS. WHY DID IT TAKE THEM 4 YEARS TO FIX THIS TYPE OF SAFETY PROBLEM?*AK
NHTSA ODI #10062498
Mileage unknown · Mar 15, 2004
Service Brakes, Hydraulic
DEFECTIVE BRAKES ON A 2000 JEEP GRAND CHEROKEE. THE DEALER REPLACED THE BRAKE ROTOR'S ONCE BEFORE THE WARRANTY WAS UP. BUT THE ROTOR'S ARE WARPED AGAIN AND THE CAR ONLY HAS 25,000 MILES ON IT. SURELY, THERE IS A PROBLEM WITH THIS DESIGN WHICH COULD LEAD TO A REALL PROBLEM WHEN THE CARE IS BEING DRIVEN ON A FREEWAY? I HAVE RE…
Read full complaint
DEFECTIVE BRAKES ON A 2000 JEEP GRAND CHEROKEE. THE DEALER REPLACED THE BRAKE ROTOR'S ONCE BEFORE THE WARRANTY WAS UP. BUT THE ROTOR'S ARE WARPED AGAIN AND THE CAR ONLY HAS 25,000 MILES ON IT. SURELY, THERE IS A PROBLEM WITH THIS DESIGN WHICH COULD LEAD TO A REALL PROBLEM WHEN THE CARE IS BEING DRIVEN ON A FREEWAY? I HAVE REPLACED THE BRAKE ROTORS ON THE REAR OF THE VEHICLE MYSELF BUT NOW THE FRONT ROTORS SEEM TO BE WARPED ALSO. WITH ONLY 25,000 MILES ON THE VEHICLE THIS IS REALLY A PROBLEM. *AK
NHTSA ODI #10062257
Mileage unknown · Mar 10, 2004
Engine And Engine CoolingService Brakes, Hydraulic
BOUGHT 2000 JEEP GRAND CHEROKEE NEW. NOW HAS 57000 MILES ON IT. TWO MAIN PROBLEMS NOW EXIST: 1. I HAD TO HAVE BRAKES REPLACED AFTER 25000 MILES. THEY NOW NEED REPLACED AGAIN. EXTREME VEHICLE SHAKING AND VIBRATION THRU THE STEERING WHEEL. APPEARS TO BE COMMON PROB EXPERIENCED BY MANY BASED ON THE VOLUME OF COMPLAINTS I AM …
Read full complaint
BOUGHT 2000 JEEP GRAND CHEROKEE NEW. NOW HAS 57000 MILES ON IT. TWO MAIN PROBLEMS NOW EXIST: 1. I HAD TO HAVE BRAKES REPLACED AFTER 25000 MILES. THEY NOW NEED REPLACED AGAIN. EXTREME VEHICLE SHAKING AND VIBRATION THRU THE STEERING WHEEL. APPEARS TO BE COMMON PROB EXPERIENCED BY MANY BASED ON THE VOLUME OF COMPLAINTS I AM SEEING. DEALER WILL NOT ASSIST. CHRYSLER REP WILL NOT ASSIST. 2. EXPERIENCED LOW OIL PRESSURE READING. TOOK CAR IN FOR ANALYSIS AND THEY TELL ME ENGINE NEEDS REPLACED. GUNK BUILDUP IN ENGINE THEY SAY IS CAUSE OF PROBLEM. OIL HAS BEEN CHANGED REGULARLY. I CANNOT PROVE RECORD OF ALL OIL CHANGES, BUT IT HAS BEEN CHANGED AT REPUTABLE SERVICE CENTERS. ENGINE $5600. CHRYSLER DISTRICT UNWILLING TO ASSIST. I AM FRUSTRATED AT THEIR LACK OF COMMUNICATION, ATTITUDES, AND LACK OF QUALITY IN THIS VEHICLE. THEY TRY TO MAKE YOU FEEL LIKE A COMMON CRIMINAL AND ARE UNWILLING TO STAND BEHIND THEIR PRODUCT. THIS VEHICLE COST ABOUT $35,000 AND IT IS FAR FROM BEING WORTH THE VALUE.*AK
NHTSA ODI #10061818
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
PE10031 · Crash Related Fuel Tank Fires
Opened Aug 23, 2010 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
DP09005 · Fuel Storage System Crash Related Fires
Opened Nov 6, 2009 · Closed Aug 23, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
EA05020 · Fan Blade Failure (engine Cooling Fan)
Opened Nov 14, 2005 · Closed Sep 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX CYLINDER) ENGINES MANUFACTURED FROM FEBRUARY 4, 2002 THROUGH JUNE 17, 2002; AND MY 2000 EQUIPPED WITH EITHER THE 4.0 LITER (SIX CYLINDER) OR THE 4.7 LITER (EIGHT CYLINDER) ENGINE MANUFACTURED FROM JANUARY 31, 2000 THROUGH JUNE 12, 2000.DCC NOTED THAT THEIR ANALYSIS OF FAILED PARTS SHOWED EVIDENCE OF BRITTLE FRACTURE OF THE FAN BLADE.DCC FURTHER STATED, POOR BONDING BETWEEN THE RESIN MATERIAL AND THE GLASS FIBERS WAS OBSERVED, WHICH MAY BE ATTRIBUTED TO THE INJECTION MOLDING PROCESS. SINCE THE ROOT CAUSE OF FAN FAILURE COULD NOT BE CONCLUSIVELY IDENTIFIED DCC DECIDED THE RECALL SCOPE WOULD BE DETERMINED BY THE BUILD DATE RANGE OF THE COMPLAINT VEHICLES.THERE WERE 48 REPORTS FOR MY 2000, AND 196 FOR MY 2002.ODI WILL CONTINUE TO MONITOR THIS ISSUE FOR REPORTS ON VEHICLES OUTSIDE OF THE RECALL SCOPE.
EA01017 · ROLL-AWAY In Reverse When Parked
Opened Nov 1, 2001 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Power Train
DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.
Illustration