NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
418 reportsClear category filter58,000 miles · Oct 4, 2010
Service Brakes, Hydraulic
ALL 1999-2002 GRAND CHEROKEE WJ MODELS BUILT THROUGH MAY 10, 2002 CAME EQUIPPED WITH BRAKE CALIPERS MADE BY TEVES. THEY ARE BLACK IN COLOR WITH AN OPEN-SIDED BRACKET DESIGN. DUE TO POOR CALIPER CENTERING, THE TEVES CALIPERS CAUSED THE ROTORS TO WARP, A PROBLEM THAT HAS PLAGUED GRAND CHEROKEES. AT THE VERY END OF THE 2002 MODEL Y…
Read full complaint
ALL 1999-2002 GRAND CHEROKEE WJ MODELS BUILT THROUGH MAY 10, 2002 CAME EQUIPPED WITH BRAKE CALIPERS MADE BY TEVES. THEY ARE BLACK IN COLOR WITH AN OPEN-SIDED BRACKET DESIGN. DUE TO POOR CALIPER CENTERING, THE TEVES CALIPERS CAUSED THE ROTORS TO WARP, A PROBLEM THAT HAS PLAGUED GRAND CHEROKEES. AT THE VERY END OF THE 2002 MODEL YEAR, JEEP CHANGED TO "FULLY-CLOSED" STYLE CALIPERS DESIGNED BY AKEBONO. TO ADDRESS THE WARPED ROTOR PROBLEM JEEP ISSUED A TSB, #05-003-02. WE BELIEVE IT SHOULD BE A FULL RECALL DO TO THE MAJOR WHEEL SHAKE TO THE POINT OF THE DRIVER ALMOST LOOSING CONTROL OF THE SUV DO TO THIS VIBRATION. JEEP HAS LONG KNOWN ABOUT THIS ISSUE & WAS SUED IN A CLASS ACTION LAW SUIT WHICH THEY SETTLED THE PROBLEM IS EXCESSIVE ROTOR THICKNESS VARIATION GENERATED BY POOR CALIPER CENTERING. THIS CAUSES STEERING WHEEL SHAKE. GRAND CHEROKEE BRAKES UP THROUGH MAY 10TH 2002 WERE DESIGNED BY TEVES. SAME BRAKES USED ON BMW & FORD EXPEDITION BUT THE GRAND CHEROKEE WAS THE FIRST TO USE A TWIN PISTON CALIPER DESIGN. CHRYSLER WANTED TWIN PISTONS BECAUSE OF THE WEIGHT OF THE VEHICLE. THE CALIPER SPRING CAUSES THE INBOARD PAD TO DRAG. IT TAKES A LOT OF HEAT (CHERRY RED) TO WARP ROTORS, SO THE MAIN CAUSE OF ROTOR VARIATION IS NOT HEAT BUT UNEVEN WEAR. *TR
NHTSA ODI #10359010
125,000 miles · Jul 15, 2010
Exterior LightingService Brakes, Hydraulic
2000 JEEP GRAND CHEROKEE REAR BRAKE LIGHTS OUT BECAUSE OF DEFECTIVE DESIGN. BRAKE LIGHTS STOP WORKING WHEN HEADLIGHTS TURNED ON. BRAKE LIGHTS WORK FINE WHEN HEADLIGHTS OFF. PROBLEM DESIGN IS IN THE TAIL LIGHT ASSEMBLY. WHEN YOU REMOVE THE LIGHT SOCKET FOR THE TAIL/BRAKE LIGHT IN THE LIGHT ASSEMBLY, YOU WILL SEE 3 SILVER CONTA…
Read full complaint
2000 JEEP GRAND CHEROKEE REAR BRAKE LIGHTS OUT BECAUSE OF DEFECTIVE DESIGN. BRAKE LIGHTS STOP WORKING WHEN HEADLIGHTS TURNED ON. BRAKE LIGHTS WORK FINE WHEN HEADLIGHTS OFF. PROBLEM DESIGN IS IN THE TAIL LIGHT ASSEMBLY. WHEN YOU REMOVE THE LIGHT SOCKET FOR THE TAIL/BRAKE LIGHT IN THE LIGHT ASSEMBLY, YOU WILL SEE 3 SILVER CONTACT POINTS INSIDE THE BLACK PLASTIC RING. TWO ARE GROUPED TOGETHER AND THERE IS ONE THAT IS OPPOSITE OF THE TWO. THE ONE BY ITSELF IS THE GROUND; THE OTHER TWO ARE THE CONTACTS FOR THE TAIL LIGHT AND BRAKE LIGHT. THE PROBLEM LIES WITH THE GROUND CONNECTOR. YOU SHOULD NOTICE THAT THE GROUND CONTACT IS DEPRESSED INTO THE PLASTIC AND THE PLASTIC ITSELF IS SLIGHTLY WARPED DOWN. MOST CARS HAVE LIGHT SOCKETS WITH THEIR WIRING ATTACHED. THE SOCKET TWISTS INTO THE LAMP ASSEMBLY. ON THE GRAND CHEROKEE, THE SOCKET DOES NOT HAVE THE WIRING ATTACHED. INSTEAD, THE WIRING GOES INTO THE LAMP ASSEMBLY AND THE SOCKET HAS THREE ELECTRICAL CONTACTS THAT, WHEN TWISTED INTO THE ASSEMBLY, WILL MAKE THE CONTACT. WHAT SEEMS TO BE THE MOST FREQUENT MALFUNCTION IS THAT THE ELECTRICAL CONTACTS (WHICH MAKE CONTACT WITH THEIR RESPECTIVE ELECTRICAL PATHS WHEN THEY ARE INSERTED INTO THE ASSEMBLY) ARE PRESSED TIGHT TO ENSURE GOOD CONTACT WITH THE ASSEMBLY...AND ON MANY TAILLIGHTS, THE PLASTIC RING CONTAINING THE RESPECTIVE PATHS OFTEN BEGINS TO SEPARATE FROM THE FATIGUE OF THE CONTACTS PRESSING SO HARD. OF THE THREE CONTACTS (REAR TAIL LIGHT, REAR BRAKE LIGHT AND GROUND), THE GROUND IS WHAT MOST COMMONLY LOSES ITS CONTACT DUE TO FATIGUE CRACKING. THIS IS A SERIOUS SAFETY ISSUE BECAUSE OFTEN DRIVERS ARE UNAWARE THAT THERE IS A PROBLEM. IT ONLY HAPPENS WHEN THE HEADLAMPS ARE ON, SO IF CHECKED IN DAYLIGHT, THE PROBLEM OFTEN GOES UNDETECTED. ONLY WHEN ANOTHER DRIVER OR THE POLICE POINT IT OUT DOES IT LOOKED AT. THIS IS A WIDESPREAD PROBLEM THAT OCCURS FOR NEARLY EVERY 2000 JEEP GRAND CHEROKEE. IT IS NOT AN ISSUE OF WILL IT HAPPEN, RATHER WHEN IS IT GOING TO HAPPEN! *TR
NHTSA ODI #10343382
90,000 miles · Mar 28, 2010
Engine And Engine CoolingLatches/locks/linkagesService Brakes, Hydraulic
MY WIFE AND I PURCHASED A 2000 JEEP GRAND CHEROKEE FROM THE DEALERSHIP. ABOUT TWO YEARS AGO THE 4.0 LITER 6 CYLINDER ENGINE STARTED USING COOLANT AND CAUSING THE COOLANT LIGHT TO ALARM. THE OIL PRESSURE WOULD DROP TO "0" AND SOUND THE CHECK GAUGES ALARM. WE TOOK THE CAR TO THE MECHANIC SHOP FOR COSTLY REPAIRS AND TROUBLESHOOTING…
Read full complaint
MY WIFE AND I PURCHASED A 2000 JEEP GRAND CHEROKEE FROM THE DEALERSHIP. ABOUT TWO YEARS AGO THE 4.0 LITER 6 CYLINDER ENGINE STARTED USING COOLANT AND CAUSING THE COOLANT LIGHT TO ALARM. THE OIL PRESSURE WOULD DROP TO "0" AND SOUND THE CHECK GAUGES ALARM. WE TOOK THE CAR TO THE MECHANIC SHOP FOR COSTLY REPAIRS AND TROUBLESHOOTING. THEY REPLACED THE WATER PUMP, COULDN'T FIND ANY LEAKS, AND REPLACED THE OIL PUMP AND REAR MAIN SEAL. THEY CHECKED THE BEARING CLEARANCES AND FOUND THEM WITHIN TOLERANCE. THE CAR IS STILL USING ONE TO TWO PINTS OF COOLANT EVERY THREE DAYS AND THE OIL CONTINUES TO DROP TO "0" AFTER WARM-UP. WE REPLACE THE 4 WHEEL DISC BRAKES AND ROTORS EVERY TWO YEARS. THE HOOD GAS SHOCKS WON'T HOLD THE HOOD UP AND THE SHOCKS COST $150 A PAIR FORM THE DEALER AND ONLY LAST ONE YEAR. WE TO HAVE ELECTRIC DOOR LOCKS THAT SCREECH AND DON'T LOCK THE DOORS AS WELL AS REAR LIGHT PROBLEMS THAT WORK OFF AND ON. THE EMISSIONS ARE MUCH HIGHER THAN NORMAL ON OUR RECENT SMOG TEST. THIS IS AN INDICATION THAT THE #3 AND 4 CYLINDER IS USING THE MYSTERIOUS ANTIFREEZE LOSS. AS A RETIRED MECHANICAL ENGINEER I ALSO BELIEVE THE OIL PROBLEM TO BE RELATED. MY WIFE HAS THE GRAND CHEROKEE AND I PURCHASED A TJ WRANGLER NEW IN 2000. I'M CONCERNED THIS VEHICLE WILL DEVELOP THE SAME PROBLEMS HAVING THE SAME ENGINE. WE HAVE INVESTED OVER $50 THOUSAND IN THESE TWO CARS. WE NEED YOUR HELP TO HELP US OFFSET THIS BURDEN. *TR
NHTSA ODI #10322525
80,000 miles · Dec 21, 2008
Electrical SystemEquipmentExterior Lighting
BOTH TAIL LIGHT ASSEMBLIES STOPPED WORKING AND WAS CITED BY A POLICE OFFICER. REPLACEMENT WAS ~$500. REAR LIFT GATE LOCK ACTUATOR IS BROKEN, SO CANNOT OPEN LIFT GATE. RIGHT REAR DOOR LOCK WILL NOT ALLOW OPENING FROM INSIDE. SHIFT SENSOR/SOLENOID HAS GONE BAD TWICE LEADING TO PROBLEMS WITH SHIFTING FROM GEARS (REVS REALLY HIG…
Read full complaint
BOTH TAIL LIGHT ASSEMBLIES STOPPED WORKING AND WAS CITED BY A POLICE OFFICER. REPLACEMENT WAS ~$500. REAR LIFT GATE LOCK ACTUATOR IS BROKEN, SO CANNOT OPEN LIFT GATE. RIGHT REAR DOOR LOCK WILL NOT ALLOW OPENING FROM INSIDE. SHIFT SENSOR/SOLENOID HAS GONE BAD TWICE LEADING TO PROBLEMS WITH SHIFTING FROM GEARS (REVS REALLY HIGH BEFORE SHIFTING). ROTORS ARE CONSTANTLY BECOMING WARPED AND BRAKES HAVE TO BE READJUSTED. LEFT BLINKER NO LONGER WORKS AND TO FIX IT, THE DEALERSHIP TOLD ME THEY HAVE TO REPLACE THIS ENTIRE ENGINE BLOCK FOR ABOUT $800. POWER WINDOW LOCK NO LONGER WORKS. OTHER THAN THAT, CAR RUNS GREAT :). *TR
NHTSA ODI #10252464
50,000 miles · Dec 4, 2008
Air BagsEngine And Engine CoolingExterior Lighting
MY CAR HAS MAJOR PROBLEMS AND I CAN'T AFFORD TO FIX, THEN I FIND THE PROBLEM THAT I HAVE IS DUE TO THE AUTOMAKER'S PROBLEM BECAUSE THE CAR IS ON RECALLS FOR THE PROBLEMS I AM HAVING. I RECEIVED NO NOTICES ON ANY RECALL, AND WHEN I GOT ON THE WEB-SITE TO CHECK FOR RECALLS THERE ARE AS MANY AS 10 MAJOR PROBLEMS WITH MY CAR AND JEE…
Read full complaint
MY CAR HAS MAJOR PROBLEMS AND I CAN'T AFFORD TO FIX, THEN I FIND THE PROBLEM THAT I HAVE IS DUE TO THE AUTOMAKER'S PROBLEM BECAUSE THE CAR IS ON RECALLS FOR THE PROBLEMS I AM HAVING. I RECEIVED NO NOTICES ON ANY RECALL, AND WHEN I GOT ON THE WEB-SITE TO CHECK FOR RECALLS THERE ARE AS MANY AS 10 MAJOR PROBLEMS WITH MY CAR AND JEEP. SOME COULD CAUSE ME TO CRASH OR EVEN EXPLODE WHILE DRIVING. WHERE ARE MY RECALL NOTICES? *TR
NHTSA ODI #10250735
Mileage unknown · Aug 18, 2008
EquipmentLatches/locks/linkagesService Brakes, Hydraulic
BRAKE ROTORS WARP EASILY,DOOR LATCHES BRAKE DOWN,AIR CONDITIONING SYSTEM MAKES NOISES AND DOES NOT WORK PROPERLY. *TR
NHTSA ODI #10238787
91,000 miles · Mar 15, 2008
Engine And Engine CoolingService Brakes, Hydraulic
MY 2000 JEEP GRAND CHEROKEE IS HAVING PROBLEMS LIKE MANY OTHER PEOPLE. THE LOW COOLANT LIGHT CONSTANTLY COMES ON AND I HAVE TO ADD COOLANT WEEKLY, ALTHOUGH THERE IS NO VISIBLE LEAK. MECHANICS HAVE TOLD ME THEY CANNOT FIND THE PROBLEM UNTIL THIS PAST WEEK WHEN A MECHANIC TOLD ME THE COOLANT WAS LEAKING INTO MY ENGINE AND MIXING…
Read full complaint
MY 2000 JEEP GRAND CHEROKEE IS HAVING PROBLEMS LIKE MANY OTHER PEOPLE. THE LOW COOLANT LIGHT CONSTANTLY COMES ON AND I HAVE TO ADD COOLANT WEEKLY, ALTHOUGH THERE IS NO VISIBLE LEAK. MECHANICS HAVE TOLD ME THEY CANNOT FIND THE PROBLEM UNTIL THIS PAST WEEK WHEN A MECHANIC TOLD ME THE COOLANT WAS LEAKING INTO MY ENGINE AND MIXING WITH MY OIL. THE MECHANIC ESTIMATED I WILL NEED A COMPLETELY NEW ENGINE WITHIN A FEW MONTHS SINCE THE COOLANT-OIL MIXTURE HAS BEEN RUNNING THROUGH MY ENGINE FOR SOME TIME NOW. THE MECHANIC STATED THAT THE ENGINE WILL STOP RUNNING IN THE VERY NEAR FUTURE. MY REAR LEFT BRAKE AND TAIL LIGHT GOES OUT WHEN I STEP ON THE BRAKES. I HAVE HAD SEVERAL ISSUES WITH THE ROTORS AND FINALLY HAD THE MECHANIC REPLACE THEM WITH A DIFFERENT KIND. *TR
NHTSA ODI #10221280
19,000 miles · Feb 7, 2008
Service Brakes, Hydraulic
MY 2000 JEEP GRAND CHEROKEE 6 CYL. 4X4 HAS HAD EXTENSIVE ROTOR PROBLEMS LEADING TO REPLACEMENT OF ROTORS AT 19,000 (COVERED BY DEALER), 40,000 (AT MY EXPENSE), AT 63,520, AGAIN AT MY EXPENSE, AT 90,000, AND NOW AGAIN, REPLACING ALL 4 ROTORS AT 363.50 PER SET AT 112,000 MILES. THIS NEEDS TO BE RECALLED AND INVESTIGATED IMMEDIATE…
Read full complaint
MY 2000 JEEP GRAND CHEROKEE 6 CYL. 4X4 HAS HAD EXTENSIVE ROTOR PROBLEMS LEADING TO REPLACEMENT OF ROTORS AT 19,000 (COVERED BY DEALER), 40,000 (AT MY EXPENSE), AT 63,520, AGAIN AT MY EXPENSE, AT 90,000, AND NOW AGAIN, REPLACING ALL 4 ROTORS AT 363.50 PER SET AT 112,000 MILES. THIS NEEDS TO BE RECALLED AND INVESTIGATED IMMEDIATELY. *TR
NHTSA ODI #10217373
Mileage unknown · Sep 30, 2007
Engine And Engine CoolingExterior LightingLatches/locks/linkages
I HAVE A 2000 JEEP GC LAREDO, AND ALONG WITH MANY,MANY OTHER PEOPLE I HAVE NUMEROUS PROBLEMS. THE WARPED ROTORS ARE VERY DANGEROUS WHEN YOU HAVE TO USE YOUR BRAKES, ESPECIALLY WHEN YOU HAVE CHILDREN IN THE CAR AS I DO, ALSO THE TAILLIGHT/BRAKE LIGHT ISSUE, THAT HAS GOTTEN ME PULLED OVER MORE THAN ONCE, EVEN THOUGH I PUT A NEW BU…
Read full complaint
I HAVE A 2000 JEEP GC LAREDO, AND ALONG WITH MANY,MANY OTHER PEOPLE I HAVE NUMEROUS PROBLEMS. THE WARPED ROTORS ARE VERY DANGEROUS WHEN YOU HAVE TO USE YOUR BRAKES, ESPECIALLY WHEN YOU HAVE CHILDREN IN THE CAR AS I DO, ALSO THE TAILLIGHT/BRAKE LIGHT ISSUE, THAT HAS GOTTEN ME PULLED OVER MORE THAN ONCE, EVEN THOUGH I PUT A NEW BULB IN IT EVERY TIME. THE DOOR LOCK ACTUATOR THAT IS VERY ANNOYING NOT TO MENTION MY TRANSMISSION HAS A SHIFTING PROBLEM THAT I CAN'T DO ANYTHING ABOUT AND NOW MY RADIATOR FAN WILL NOT WORK SO MY CAR WILL OVERHEAT IF I AM STOPPED FOR TOO LONG. *JB
NHTSA ODI #10204487
Mileage unknown · Jul 26, 2007
Service Brakes, Hydraulic
ON A HARD STOP THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKE LIGHT CAME ON. I TOOK MY JEEP THE DEALER, AND THEY HAD TO REPLACE A RUSTED BRAKE LINE THAT FAILED WHEN I MADE THE PANIC STOP. I CALLED CHRYSLER, AND THEY SAID THAT THERE WERE NO SERVICE BULLETINS OR PROBLEMS WITH OTHER JEEP GRAND CHEROKEES REGARDING BRAKE LINES RUS…
Read full complaint
ON A HARD STOP THE BRAKE PEDAL WENT TO THE FLOOR AND THE BRAKE LIGHT CAME ON. I TOOK MY JEEP THE DEALER, AND THEY HAD TO REPLACE A RUSTED BRAKE LINE THAT FAILED WHEN I MADE THE PANIC STOP. I CALLED CHRYSLER, AND THEY SAID THAT THERE WERE NO SERVICE BULLETINS OR PROBLEMS WITH OTHER JEEP GRAND CHEROKEES REGARDING BRAKE LINES RUSTING OUT AND LEAKING FLUID CAUSING BRAKE FAILURE. CHRYSLER REPLIED THAT SINCE MY JEEP WAS OUT OF WARRANTY, THEY WOULD NOT REIMBURSE ME FOR THE REPLACEMENT OF THE RUSTED BRAKE LINE. THIS IS NOT ONLY A FINANCIAL ISSUE, BUT A SERIOUS SAFETY ISSUE. CHRYSLER NEEDS TO NOTIFY OTHERS OF THIS POTENTIAL SAFETY PROBLEM. *TR
NHTSA ODI #10197569
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
PE10031 · Crash Related Fuel Tank Fires
Opened Aug 23, 2010 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
DP09005 · Fuel Storage System Crash Related Fires
Opened Nov 6, 2009 · Closed Aug 23, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
EA05020 · Fan Blade Failure (engine Cooling Fan)
Opened Nov 14, 2005 · Closed Sep 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX CYLINDER) ENGINES MANUFACTURED FROM FEBRUARY 4, 2002 THROUGH JUNE 17, 2002; AND MY 2000 EQUIPPED WITH EITHER THE 4.0 LITER (SIX CYLINDER) OR THE 4.7 LITER (EIGHT CYLINDER) ENGINE MANUFACTURED FROM JANUARY 31, 2000 THROUGH JUNE 12, 2000.DCC NOTED THAT THEIR ANALYSIS OF FAILED PARTS SHOWED EVIDENCE OF BRITTLE FRACTURE OF THE FAN BLADE.DCC FURTHER STATED, POOR BONDING BETWEEN THE RESIN MATERIAL AND THE GLASS FIBERS WAS OBSERVED, WHICH MAY BE ATTRIBUTED TO THE INJECTION MOLDING PROCESS. SINCE THE ROOT CAUSE OF FAN FAILURE COULD NOT BE CONCLUSIVELY IDENTIFIED DCC DECIDED THE RECALL SCOPE WOULD BE DETERMINED BY THE BUILD DATE RANGE OF THE COMPLAINT VEHICLES.THERE WERE 48 REPORTS FOR MY 2000, AND 196 FOR MY 2002.ODI WILL CONTINUE TO MONITOR THIS ISSUE FOR REPORTS ON VEHICLES OUTSIDE OF THE RECALL SCOPE.
EA01017 · ROLL-AWAY In Reverse When Parked
Opened Nov 1, 2001 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Power Train
DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.
Illustration