NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
43 reportsClear category filter121,000 miles · Apr 29, 2011
Fuel System, Gasoline
I HAVE BEEN GETTING THE RUN AROUND FORM CUSTOMER SERVICE AT CHRYSLER. I HAVE A JEEP GRAND CHEROKEE,AND WAS PLANNING ON BUYING ANOTHER. BUT>>> COMMENTS: --------- MY 2000 JEEP GRAND CHEROKEE WITH A 4L ENGINE STALLS WHEN TURNING LEFT IF THE FUEL LEVEL IN THE TANK IS BELOW 1/4. THE VIN NUMBER IS; [XXX] THIS IS VERY DANGEROUS…
Read full complaint
I HAVE BEEN GETTING THE RUN AROUND FORM CUSTOMER SERVICE AT CHRYSLER. I HAVE A JEEP GRAND CHEROKEE,AND WAS PLANNING ON BUYING ANOTHER. BUT>>> COMMENTS: --------- MY 2000 JEEP GRAND CHEROKEE WITH A 4L ENGINE STALLS WHEN TURNING LEFT IF THE FUEL LEVEL IN THE TANK IS BELOW 1/4. THE VIN NUMBER IS; [XXX] THIS IS VERY DANGEROUS, AND COULD CAUSE A SERIOUS ACCIDENT IF I AM NOT ABLE TO GET OUT OF THE WAY OF ONCOMING TRAFFIC. LAST WEEK I HAD THE LOCAL DEALER CHECK THE VEHICLE. THEY SAID IF IT WERE THE SENSING UNIT IN THE GAS TANK, IT WOULD BE COVERED UNDER A RECALL. THEY SAID IT WAS THE FUEL PUMP ITSELF, NOT THE SENSOR, AND THEREFORE, I WOULD HAVE TO PAY AROUND $1000.00 TO HAVE THE FUEL PUMP REPLACED. THERE IS NOTHING WRONG WITH THE PUMP, THERE IS SOMETHING WRONG WITH THE PICKUP DEVICE WHENTHE TANK LEVEL DROPS BELOW 1/4, AND THIS HAPPENS OVER A PERIOD OF TIME. I HAVE CHECKED SEVERAL WEB SITES AND FOUND QUITE A NUMBER OF PEOPLE COMPLAINING ABOUT THE SAME SITUATION. I CALLED CHRYSLER TODAY AT 1-800-992-1997 AND WAS TOLD I WOULD HAVE TO SPEAK WITH CUSTOMER SERVICE AT 1-800-853-1403. WHEN I CALLED THIS NUMBER I SPOKE TO A REPRESENTATIVE AND I EXPLAINED WHAT THE PROBLEM WAS AND I WAS TOLD THE VEHICLE WAS TOO OLD FOR THEM TO DO ANYTHING ABOUT IT. I ASKED TO SPEAK TO HIS SUPERIOR, AND WAS DENIED A NAME. WHEN I ASKED FOR A NAME, SHE ASKED "IS ANYTHING ELSE I CAN HELP YOU WITH AND TOLD ME THANKS FOR CALLING. THIS IS NOT AN ANOMALY WITH MY 2000 JEEP GRAND CHEROKEE, ACCORDING TO THE SITES I VISITED, THIS OCCURS FROM 95 AND ON INTO THE 2000 (S) JEEP. THE JEEP DIED ON MY ON A BUSY HIGHWAY AT 1/4 TANK AND I COULD NOT GET OUT OF THE WAS OF TRAFFIC IN SPEEDS OF 70+MPH. I THOUGHT I WAS GOING TO DIE GETTING MY VEHICLE TO THE SHOULDER OF THE ROAD. THIS DEFECT CAN CAUSE DEATH. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10398251
148,049 miles · Sep 3, 2009
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2000 JEEP GRAND CHEROKEE LAREDO. THE CONTACT NOTICED A FUEL LEAK WHEN FUELING THE GAS TANK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. HE CONTACTED THE DEALER AND A TECHNICIAN STATED THAT BECAUSE HIS VIN NUMBER WAS EXCLUDED FROM RECALL# 06E011000 (FUELSYSTEM, GASOLINE: DELIV…
Read full complaint
TL* THE CONTACT OWNS A 2000 JEEP GRAND CHEROKEE LAREDO. THE CONTACT NOTICED A FUEL LEAK WHEN FUELING THE GAS TANK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. HE CONTACTED THE DEALER AND A TECHNICIAN STATED THAT BECAUSE HIS VIN NUMBER WAS EXCLUDED FROM RECALL# 06E011000 (FUELSYSTEM, GASOLINE: DELIVERY: FUEL PUMP), HE WAS INELIGIBLE FOR A FREE REMEDY. THE VEHICLE HAS NOT BEEN REPAIRED.THE CURRENT AND THE FAILURE MILEAGES WERE 148,049.
NHTSA ODI #10282788
50,000 miles · Dec 4, 2008
Air BagsEngine And Engine CoolingExterior Lighting
MY CAR HAS MAJOR PROBLEMS AND I CAN'T AFFORD TO FIX, THEN I FIND THE PROBLEM THAT I HAVE IS DUE TO THE AUTOMAKER'S PROBLEM BECAUSE THE CAR IS ON RECALLS FOR THE PROBLEMS I AM HAVING. I RECEIVED NO NOTICES ON ANY RECALL, AND WHEN I GOT ON THE WEB-SITE TO CHECK FOR RECALLS THERE ARE AS MANY AS 10 MAJOR PROBLEMS WITH MY CAR AND JEE…
Read full complaint
MY CAR HAS MAJOR PROBLEMS AND I CAN'T AFFORD TO FIX, THEN I FIND THE PROBLEM THAT I HAVE IS DUE TO THE AUTOMAKER'S PROBLEM BECAUSE THE CAR IS ON RECALLS FOR THE PROBLEMS I AM HAVING. I RECEIVED NO NOTICES ON ANY RECALL, AND WHEN I GOT ON THE WEB-SITE TO CHECK FOR RECALLS THERE ARE AS MANY AS 10 MAJOR PROBLEMS WITH MY CAR AND JEEP. SOME COULD CAUSE ME TO CRASH OR EVEN EXPLODE WHILE DRIVING. WHERE ARE MY RECALL NOTICES? *TR
NHTSA ODI #10250735
125,000 miles · Aug 31, 2008
Fuel System, Gasoline
LONGER THAN NORMAL CRANKING TIME DUE TO A WORN O-RING IN THE FUEL MODULE ASSEMBLY OR BY PLASTIC CONTAMINANT ENTERING THE FUEL PUMP. TECHNICAL SERVICE BULLETIN #14-06-00 (PROVIDED BY SERVICE GARAGE). *TR
NHTSA ODI #10240496
65,000 miles · Jul 7, 2007
Fuel System, Gasoline
AIR CONDITIONER FAN AND CONTROL BOX HAS BEEN REPAIRED AND REPLACE MULITPLE TIMES NOW AND AGAIN IS BROKE. THE BRAKES/ROTORS ARE BAD HANDLING AND THE FUEL ECONOMY DOES NOT GET WHAT EVEN THE COMPUTER STATED. *AK
NHTSA ODI #10195543
80,000 miles · Nov 28, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE OPERATED AT A REDUCED SPEED, AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED THE FUEL INJECTORS WERE DROPPING AT DIFFERENT TIMES INSTEAD OF TOGETHER, AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT ALERTED.
NHTSA ODI #10174579
41,563 miles · Oct 17, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THERE WAS FUEL LEAKING FROM UNDERNEATH THE VEHICLE WHILE PARKED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THE LEAK ORIGINATED AT THE ROLLOVER VALVE. THE FUEL TANK WAS REPLACED, WHICH CORRECTED THE PROBLEM. THERE WAS A NHTSA RECALL# 00V195000, WHICH PERTAINED TO THE FUEL TANK ASSEMBLY. …
Read full complaint
DT*: THE CONTACT STATED THERE WAS FUEL LEAKING FROM UNDERNEATH THE VEHICLE WHILE PARKED. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THE LEAK ORIGINATED AT THE ROLLOVER VALVE. THE FUEL TANK WAS REPLACED, WHICH CORRECTED THE PROBLEM. THERE WAS A NHTSA RECALL# 00V195000, WHICH PERTAINED TO THE FUEL TANK ASSEMBLY. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. UPDATED 12/01/06. *JB
NHTSA ODI #10171056
Mileage unknown · Sep 18, 2006
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
TIE RODS, WHEEL BEARINGS, BALL JOINTS, FAN CLUTCH, SHORTED ENGINE COMPARTMENT WIRING HARNESS, FUEL PUMP ASSEMBLY ALL GONE WRONG FROM TIME OF PURCHASE; JANUARY 2000/BRAND NEW TO SEPT. 2006...SOME PD. UNDER WARRANTY OTHERS AFTER 2004 NOT; EVEN THOUGH THE DEFECTS USUALLY DO NOT HAPPEN TO A JEEP GRAND CHEROKEE/FULLY LOADED. THE LAST…
Read full complaint
TIE RODS, WHEEL BEARINGS, BALL JOINTS, FAN CLUTCH, SHORTED ENGINE COMPARTMENT WIRING HARNESS, FUEL PUMP ASSEMBLY ALL GONE WRONG FROM TIME OF PURCHASE; JANUARY 2000/BRAND NEW TO SEPT. 2006...SOME PD. UNDER WARRANTY OTHERS AFTER 2004 NOT; EVEN THOUGH THE DEFECTS USUALLY DO NOT HAPPEN TO A JEEP GRAND CHEROKEE/FULLY LOADED. THE LAST STRAW WAS THE BALL JOINTS; WE ASKED IF SOME FORM OF RECALL SHOULD OF BEEN DONE AND THEN ASKED FOR A REIMBURSEMENT BECAUSE MY WIFE'S' 2004 JEEP LIBERTY LIMITED HAD A RECALL ON IT'S BALL JOINTS/LOWER ONES SO AFTER HAVING MINE REPLACED LAST FRIDAY 9/15/2006 WE ASKED ABOUT THE GRAND CHEROKEE AND IT'S BALL JOINTS; WE ALSO UPDATED ON ALL THE DEFECTS WE'VE HAD TO CORRECT AND WONDERED IF IT WASN'T A EXPENSIVE LEMON...$35,000.00 IS WHAT I PAID. WE CALLED CHRYSLER MAIN CUSTOMER SERVICE AND WAS ONLY TOLD WERE SORRY, THE AGE OF THE JEEP AND PAST WARRANTY...WHAT DOES THAT HAVE TO DO WITH ALL THE PAST DEFECTS SINCE 2000 AND THE FACT WE TRIED THEIR CUSTOMER SERVICE IN 2002 AND GOT NO WHERE AGAIN. NO MATTER THE AGE OF THE VEHICLE...SAFETY IS SAFETY. AND IF BALL JOINTS GO BAD FOR NO REASON AND HAVE TO BE REPLACED THEN, IT SHOULD GO AS A SAFETY CONCERN FOR ALL THEIR VEHICLES. *JB
NHTSA ODI #10168572
10,998 miles · Sep 2, 2005
Fuel System, GasolineService Brakes, Hydraulic
DT: CONSUMER HAD TO REPLACE FIVE INDIVIDUAL BRAKES IN FIVE YEARS. FIRST WAS THE FRONT BRAKES AND ROTORS, THEN IT WAS THE FRONT BRAKES AND ROTORS AGAIN ABOUT SEVEN MONTHS LATER. THEN ALMOST A YEAR LATER, HAD THEM REPLACED AGAIN. A YEAR AFTER THAT HAD THE REAR BRAKES AND ROTORS DONE. FINALLY HAD THE FRONT BRAKES AND ROTORS …
Read full complaint
DT: CONSUMER HAD TO REPLACE FIVE INDIVIDUAL BRAKES IN FIVE YEARS. FIRST WAS THE FRONT BRAKES AND ROTORS, THEN IT WAS THE FRONT BRAKES AND ROTORS AGAIN ABOUT SEVEN MONTHS LATER. THEN ALMOST A YEAR LATER, HAD THEM REPLACED AGAIN. A YEAR AFTER THAT HAD THE REAR BRAKES AND ROTORS DONE. FINALLY HAD THE FRONT BRAKES AND ROTORS AGAIN. THE MECHANIC TOLD CONSUMER THAT THE ROTORS WERE WARPED, AND THAT THEY COULD BARELY GET THEM OFF OF THE CAR.*AK WHEN I FIRST NOTICED THIS, THE BRAKES STARTED TO SEEM LIKE THEY WERE NOT AS EFFECTIVE AS THEY SHOULD BE. THEN, ABOUT A WEEK LATER, THE CAR WILL START TO VIBRATE AS I PRESS THE BRAKE PEDAL, AND THE VIBRATION STARTS IN THE BRAKE PEDAL, AND CONTINUE TO VIBRATE UNTIL THE WHOLE CAR IS SHAKING. IT TOOK A LONG TIME FOR THE VEHICLE TO CRANK. THE DEALER REPLACED THE FUEL PUMP O-RING AND SHIMS. *NM
NHTSA ODI #10132096
58,000 miles · Sep 6, 2004
Fuel System, Gasoline
JEEP GRAND CHEROKEE FUEL PUMP FAILURE. IT IS DIFFICULT TO START. OFTEN YOU HAVE TO TURN THE KEY ON AND OFF 3-5 TIMES BEFORE YOU ATTEMPT TO CRANK OVER THE ENGINE. THIS WILL BUILD ENOUGH PRESSURE IN THE TANK TO GET IT STARTED. THE OTHER METHOD YOU MUST USE IS TO TURN THE ENGINE OVER FOR 5-10 SECONDS, AND IT WILL NEVER START DO…
Read full complaint
JEEP GRAND CHEROKEE FUEL PUMP FAILURE. IT IS DIFFICULT TO START. OFTEN YOU HAVE TO TURN THE KEY ON AND OFF 3-5 TIMES BEFORE YOU ATTEMPT TO CRANK OVER THE ENGINE. THIS WILL BUILD ENOUGH PRESSURE IN THE TANK TO GET IT STARTED. THE OTHER METHOD YOU MUST USE IS TO TURN THE ENGINE OVER FOR 5-10 SECONDS, AND IT WILL NEVER START DOING THIS THE FIRST TIME, BUT THEN WHEN YOU LET OFF THE KEY FOR 5 SECONDS, AND START AGAIN, IT WILL FINALLY CRANK THE ENGINE OVER. THIS GETS OLD, AND IS VERY DIFFICULT TO EXPLAIN WHEN SELLING THE VEHICLE. TO TOP IT OFF, THE FUEL PUMP IS IN THE TANK MAKING IT VERY LABOR INTENSIVE TO FIX. MY ASE CERTIFIED MECHANIC SAYS HE HAS FIXED SEVERAL WITH THIS PROBLEM, AND IT IS A WONDER WHY THIS HAS NEVER BEEN RECALLED. *AK
NHTSA ODI #10090487
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
PE10031 · Crash Related Fuel Tank Fires
Opened Aug 23, 2010 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
DP09005 · Fuel Storage System Crash Related Fires
Opened Nov 6, 2009 · Closed Aug 23, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
EA05020 · Fan Blade Failure (engine Cooling Fan)
Opened Nov 14, 2005 · Closed Sep 12, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling:cooling System:fan
DAIMLERCHRYSLER CORPORATION (DCC) HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL (06V199) OF CERTAIN JEEP GRAND CHEROKEE VEHICLES TO REPLACE THE ENGINE'S ELECTRIC MOTOR DRIVEN COOLING FAN. THE 182,875 VEHICLES INCLUDED IN THE RECALL ARE MODEL YEAR (MY) 2002 EQUIPPED WITH 4.0 LITER (SIX CYLINDER) ENGINES MANUFACTURED FROM FEBRUARY 4, 2002 THROUGH JUNE 17, 2002; AND MY 2000 EQUIPPED WITH EITHER THE 4.0 LITER (SIX CYLINDER) OR THE 4.7 LITER (EIGHT CYLINDER) ENGINE MANUFACTURED FROM JANUARY 31, 2000 THROUGH JUNE 12, 2000.DCC NOTED THAT THEIR ANALYSIS OF FAILED PARTS SHOWED EVIDENCE OF BRITTLE FRACTURE OF THE FAN BLADE.DCC FURTHER STATED, POOR BONDING BETWEEN THE RESIN MATERIAL AND THE GLASS FIBERS WAS OBSERVED, WHICH MAY BE ATTRIBUTED TO THE INJECTION MOLDING PROCESS. SINCE THE ROOT CAUSE OF FAN FAILURE COULD NOT BE CONCLUSIVELY IDENTIFIED DCC DECIDED THE RECALL SCOPE WOULD BE DETERMINED BY THE BUILD DATE RANGE OF THE COMPLAINT VEHICLES.THERE WERE 48 REPORTS FOR MY 2000, AND 196 FOR MY 2002.ODI WILL CONTINUE TO MONITOR THIS ISSUE FOR REPORTS ON VEHICLES OUTSIDE OF THE RECALL SCOPE.
EA01017 · ROLL-AWAY In Reverse When Parked
Opened Nov 1, 2001 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Power Train
DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.
Illustration