NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
81 reportsClear category filter123,000 miles · Aug 21, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1997 JEEP GRAND CHEROKEE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SPORADICALLY STALLS WITHOUT WARNING. THE VEHICLE USUALLY RESTARTS IMMEDIATELY AFTERWARDS. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. HE TOOK THE VEHICLE TO THE DE…
Read full complaint
TL*THE CONTACT OWNS A 1997 JEEP GRAND CHEROKEE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SPORADICALLY STALLS WITHOUT WARNING. THE VEHICLE USUALLY RESTARTS IMMEDIATELY AFTERWARDS. PRIOR TO THE FAILURE, THE CONTACT NOTICED THAT THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. HE TOOK THE VEHICLE TO THE DEALER ON NUMEROUS OCCASIONS AND HAD VARIOUS REPAIRS PERFORMED, WHICH CONSISTED OF REPLACING THE THROTTLE POSITION SENSOR, INTAKE TEMPERATURE SENSOR, MAP SENSOR, INTAKE AIR CONTROL VALVE, CRANKSHAFT POSITION SENSOR, DISTRIBUTOR, CAP AND ROTOR, SPARK PLUGS, ELECTRICAL WIRING, FUEL PUMP, OXYGEN SENSOR, COOLANT TEMPERATURE SENSOR, AND THE IGNITION COIL. NONE OF THE REPAIRS HAVE SUCCESSFULLY REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 123,000 AND CURRENT MILEAGE WAS 125,000.
NHTSA ODI #10239174
91,000 miles · May 14, 2008
Engine And Engine Cooling
JEEP RUNS FOR A BIT SOMETIMES THEN JUST STALLS OUT NO MATTER WHAT SPEED YOU ARE TRAVELING. CHANGED MULTIPLE PARTS TO TRY AND RESOLVE THE ISSUE AND NO LUCK. I HAVE NOTICED MULTIPLE PEOPLE ON THE INTERNET COMPLAINING OF THE SAME PROBLEM WITH NO LUCK FIXING THE PROBLEM EITHER. *TR
NHTSA ODI #10227700
125,000 miles · May 8, 2008
Engine And Engine Cooling
THE 1997 JEEP GRAND CHEROKEE STALLS WHEN YOU DRIVE AND SOMETIMES WILL COME BACK BUT USUALLY WILL NOT. IF YOU WIGGLE THE PLUG ON THE COMPUTER IT APPEARS TO FIX THE PROBLEM FOR A WHILE BUT THEN IT BEGINS STALLING AGAIN. THE CAR STALLS AT ALL DIFFERENT TIMES, EVEN IN THE MIDDLE OF AN INTERSECTION! WE HAVE DONE CONSIDERABLE RESEA…
Read full complaint
THE 1997 JEEP GRAND CHEROKEE STALLS WHEN YOU DRIVE AND SOMETIMES WILL COME BACK BUT USUALLY WILL NOT. IF YOU WIGGLE THE PLUG ON THE COMPUTER IT APPEARS TO FIX THE PROBLEM FOR A WHILE BUT THEN IT BEGINS STALLING AGAIN. THE CAR STALLS AT ALL DIFFERENT TIMES, EVEN IN THE MIDDLE OF AN INTERSECTION! WE HAVE DONE CONSIDERABLE RESEARCH ON THE INTERNET AND TRIED THE "SCREW THEORY" AND CHECKED OTHER POSSIBILITIES. CHECKED THE PLUG CONNECTORS AND THEY WERE ALL FINE. EVERYTHING TESTS OUT FINE AND WE CAN'T FIGURE OUT WHAT ELSE WE CAN DO! *TR
NHTSA ODI #10227100
163,000 miles · Feb 17, 2008
Engine And Engine Cooling
WHILE I INDICATE THAT THIS PROBLEM BEGAN JAN 2008, IT HAS BECOME OBVIOUS WITH RESEARCH THAT THE PROBLEMS I HAD OVER THE LAST TWO YEARS LED UP TO THIS. FOR THE LAST 2 YEARS, IF I AM DRIVING IN HIGH ALTITUDES, ENGINE WILL SPUTTER, LOSE POWER AND THREATEN TO DIE. OVER THE LAST TWO MONTHS, MY CAR WILL JUST DIE. NO WARNING, NO SPE…
Read full complaint
WHILE I INDICATE THAT THIS PROBLEM BEGAN JAN 2008, IT HAS BECOME OBVIOUS WITH RESEARCH THAT THE PROBLEMS I HAD OVER THE LAST TWO YEARS LED UP TO THIS. FOR THE LAST 2 YEARS, IF I AM DRIVING IN HIGH ALTITUDES, ENGINE WILL SPUTTER, LOSE POWER AND THREATEN TO DIE. OVER THE LAST TWO MONTHS, MY CAR WILL JUST DIE. NO WARNING, NO SPEED REQUIREMENT, NO SITUATION REQUIREMENT. HAVE REPLACE SO MANY THINGS, IT IS UNBELIEVABLE AND VERY COSTLY. ONCE THE CAR HAS DIED, IT WILL REFUSE TO RESTART FOR SEVERAL MINUTES TO ONE HOUR. WHEN IT DOES RESTART SUPER HEAVY GAS SMELL ACCOMPANIES. TODAY IT STARTED TO BACKFIRE. PLEASE DO SOMETHING ABOUT THIS. THIS HAPPENS TO MANY OTHER JEEP GRAND CHEROKEE OWNERS. MINE IS A 97. THANK GOD IT HAS NOT HAPPENED TO ME ON THE FREEWAY AT HIGH SPEEDS LIKE SOME OTHERS. WHAT KIND OF HAVOC WOULD THAT CAUSE ON OUR FREEWAYS DURING RUSH HOURS? *TR
NHTSA ODI #10218278
199,000 miles · Feb 2, 2008
Engine And Engine Cooling
MY 1997 JEEP GRAND CHEROKEE LAREDO JUST DIES WHEN I'M DRIVING. DOESN'T MATTER WHAT SPEED I'M GOING. IT DIED OVER 10 TIMES ON MY WAY HOME FROM SAN JOSE TO SAN FRANCISCO WHILE ON THE FREEWAY GOING 60 MPH. THIS PROBLEM STARTED OVER A MONTH AGO. WE HAVE CHANGED THE CRANK SENSOR AND COIL. THE TROTTLE HAS BEEN CHECKED AND THE FUEL …
Read full complaint
MY 1997 JEEP GRAND CHEROKEE LAREDO JUST DIES WHEN I'M DRIVING. DOESN'T MATTER WHAT SPEED I'M GOING. IT DIED OVER 10 TIMES ON MY WAY HOME FROM SAN JOSE TO SAN FRANCISCO WHILE ON THE FREEWAY GOING 60 MPH. THIS PROBLEM STARTED OVER A MONTH AGO. WE HAVE CHANGED THE CRANK SENSOR AND COIL. THE TROTTLE HAS BEEN CHECKED AND THE FUEL INJECTOR. WE HAVE CHANGED THE BATTERY. WE DON'T KNOW WHAT ELSE TO CHANGE. AFTER READING THE SAME COMPLAINTS FROM JEEP OWNERS ON THE CNET CAR TECH FORUMS I DEDICED TO FILE A COMPLAINT. THEY HAVE THE SAME PROBLEM AND ARE SPENDING A LOT OF MONEY REPLACING DIFFERENT PARTS AND THE PROBLEM CONTINUES. THIS PROBLEM IS VERY DANGEROUS, DRIVING ON THE FREEWAY THEN THE CAR JUST DIES. I HAVE NO MONEY TO SPEND TO KEEP ON REPLACING DIFFERENT PARTS. PLEASE HELP. THANKS. *TR
NHTSA ODI #10216776
102,569 miles · Jun 23, 2006
Engine And Engine CoolingInjury
MY 1997 JEEP GRAND CHEROKEE LAREDO HAS HAD A CRACKED EXHAUST MANIFOLD FOR SOME TIME NOW. THE DEALERSHIP KNOWS THE PRICE FOR ONE OFF THE TOP OF THEIR HEAD WITHOUT LOOKING IT UP. DUST OR WATER CAN GET IN THERE AND CREATE ENGINE FAILURE, IT CAN ALSO CAUSE THE ENGINE TO GET TO HOT AND CAUSE A FIRE. CARBON MONOXIDE LEAKS INTO THE CAB…
Read full complaint
MY 1997 JEEP GRAND CHEROKEE LAREDO HAS HAD A CRACKED EXHAUST MANIFOLD FOR SOME TIME NOW. THE DEALERSHIP KNOWS THE PRICE FOR ONE OFF THE TOP OF THEIR HEAD WITHOUT LOOKING IT UP. DUST OR WATER CAN GET IN THERE AND CREATE ENGINE FAILURE, IT CAN ALSO CAUSE THE ENGINE TO GET TO HOT AND CAUSE A FIRE. CARBON MONOXIDE LEAKS INTO THE CABIN WHEN THE WINDOWS ARE UP AND THE HEATER IS ON. *JB
NHTSA ODI #10160614
Mileage unknown · Jun 14, 2006
Engine And Engine Cooling
AFTER DRIVING AT HIGHWAY SPEED FOR ABOUT 1 HOUR THE CAR SUDDENLY AND SPONTANEOUSLY STOPS. THIS HAS HAPPENED ON FIVE DIFFERENT OCCASIONS. *NM
NHTSA ODI #10159832
Mileage unknown · Oct 13, 2005
Engine And Engine CoolingFuel System, GasolineParking Brake
CONSUMER NOTICED A CHIRPING NOISE COMING FROM THE FRONT WHEELS THAT DISAPPEARED WHEN THE BRAKES WERE APPLIED. *TS THE DEALER WAS UNABLE TO CORRECT THE PROBLEM THE CONSUMER WAS REFERRING TO. THE CONSUMER HAD A LIST OF PROBLEMS THAT NEEDED TO BE CORRECTED ON THE VEHICLE AND THEY WERE: ROTORS AND PADS FRONT AND REAR, EMERGENCY BR…
Read full complaint
CONSUMER NOTICED A CHIRPING NOISE COMING FROM THE FRONT WHEELS THAT DISAPPEARED WHEN THE BRAKES WERE APPLIED. *TS THE DEALER WAS UNABLE TO CORRECT THE PROBLEM THE CONSUMER WAS REFERRING TO. THE CONSUMER HAD A LIST OF PROBLEMS THAT NEEDED TO BE CORRECTED ON THE VEHICLE AND THEY WERE: ROTORS AND PADS FRONT AND REAR, EMERGENCY BRAKE SHOES, WIPER BLADES, MUFFLER AND TAIL PIPE, OIL DIP DIP STICK, RIGHT AXLE BOOT,EMERGENCY BRAKE PIVOT, THE BACK GLASS NEEDED TO BE ADJUSTED, THE FUEL PUMP MODULE WAS REPLACED, THE REAR DIFFERENTIAL BEARINGS WERE REPLACED. THE CONSUMER WAS TOLD BY CUSTOMER SERVICE THERE WERE 2 OUTSTANDING RECALLS ON THE VEHICLE AND THE PROBLEM SHE WAS DESCRIBING SOUNDED AS THOUGH IT WAS RELATED TO ONE OF THE RECALLS. *JB
NHTSA ODI #10140983
Mileage unknown · Feb 22, 2005
Engine And Engine Cooling
SINCE MID DECEMBER 2004, I HAVE BEEN HAVING TROUBLE WITH MY 1997 JEEP GRAND CHEROKEE. IT HAS SINCE BEEN IN THE SHOP ON A WEEKLY BASIS, WITH THE SAME PROBLEM OF THE MOTOR HESITATING OR CUTTING OFF WHILE DRIVING. SO HERE WE ARE $1400 LATER DRIVING OFF THE LOT AND THE CAR CUTS OFF TWICE BEFORE DRIVING 1/4 OF A MILE. THEY HAVE CL…
Read full complaint
SINCE MID DECEMBER 2004, I HAVE BEEN HAVING TROUBLE WITH MY 1997 JEEP GRAND CHEROKEE. IT HAS SINCE BEEN IN THE SHOP ON A WEEKLY BASIS, WITH THE SAME PROBLEM OF THE MOTOR HESITATING OR CUTTING OFF WHILE DRIVING. SO HERE WE ARE $1400 LATER DRIVING OFF THE LOT AND THE CAR CUTS OFF TWICE BEFORE DRIVING 1/4 OF A MILE. THEY HAVE CLEANED THE THROTTLE PLATE TWICE, REPLACED THE FUEL PUMP, REPLACED THE CATALYTIC CONVERTER, REPLACED A PRIMARY COIL TWICE, REPLACED THE O2 DOWNSTREAM SENSOR, REPLACED WIRING IN THE STEERING COLUMN AND THEN THIS WEEK REPLACED THE O2 UPSTREAM SENSOR. AND I STILL HAVE THE SAME PROBLEM WITH THE HESITATION AND CUTTING OFF. THE ONLY RESPONSE FROM THE DEALERSHIP SERVICE DEPARTMENT WAS THAT WITH THIS MANY MILES I'M GOING TO BE NICKELED AND DIMED WITH REPAIRS. THE CAR HAS NEVER GIVEN ME ANY MAJOR PROBLEMS PRIOR TO DECEMBER. I AM NOT GETTING ANYWHERE WITH THIS SERVICE DEPARTMENT AND AM NOT READY TO GIVE UP ON THIS CAR. I TOOK IT TO THE DEALERSHIP FOR THE REPAIRS FEELING THAT THEY WOULD BE THE MOST KNOWLEDGEABLE ABOUT THE CAR. I AM VERY FRUSTRATED AT NOT BEING ABLE TO FIND OUT THE PROBLEM AND HAVE IT CORRECTED. I WOULD APPRECIATE ANY SUGGESTIONS. I HAVE REQUESTED A PRINT OUT FROM SADLER THAT DETAILS ALL THAT HAS BEEN DONE TO THIS CAR SINCE DECEMBER. I WOULD APPRECIATE IT IF SOMEONE COULD CONTACT ME CONCERNING THIS ISSUE.*AK
NHTSA ODI #10112002
56 miles · Jan 15, 2004
Engine And Engine CoolingFuel System, GasolineStructure
I PURCHASED THIS 1997, JEEP GRAND CHEROKEE FROM BROADWAY VOLKSWAGEN ON AUTO ROW IN OAKLAND CA. AT THE TIME THE ODOMETER READ 48,080K. TWO WEEKS AGO THE CAR STOPPED RUNNING WHILE I WAS DRIVING IT. I HAD TO HAVE IT TOWED TO ALBERA BROS. JEEP/CHRYSLER DEALERSHIP WHERE I?VE TAKEN THE VEHICLE SINCE I PURCHASED IT. I ALSO PURCHASED A …
Read full complaint
I PURCHASED THIS 1997, JEEP GRAND CHEROKEE FROM BROADWAY VOLKSWAGEN ON AUTO ROW IN OAKLAND CA. AT THE TIME THE ODOMETER READ 48,080K. TWO WEEKS AGO THE CAR STOPPED RUNNING WHILE I WAS DRIVING IT. I HAD TO HAVE IT TOWED TO ALBERA BROS. JEEP/CHRYSLER DEALERSHIP WHERE I?VE TAKEN THE VEHICLE SINCE I PURCHASED IT. I ALSO PURCHASED A WARRANTY, FOR $1500 AT THE TIME THAT I PURCHASE THE VEHICLE, WHICH WAS CONTAINED IN THE CONTRACT OF THE AUTOMOBILE INSTALLMENT PAYMENTS. THE WARRANTY WAS TO COVER ALL REPAIR THAT IS COVER FOR 72 MONTHS OR 100K MILES. I CONTACTED THE WARRANTY COMPANY, WARENTECH, WHO'S HEADQUARTERS ARE IN TEXAS AND WAS ADVISED THAT THEY WOULD HAVE TO SEND SOMEONE OUT TO LOOK AT THE CAR. SOMEONE DID COME OUT LOOK AT THE CAR AND TOOK PICTURES. AFTER A FEW DAYS I CONTACTED WARENTECH AND WAS ADVISED THAT THEY WOULD HAVE TO REVIEW THE INFORMATION AND WOULD GET BACK TO ME. AFTER SEVERAL MORE DAYS I CONTACTED WARENTECH AGAIN. I WAS ADVISED THAT THEY NEEDED ME FAX THEM MY MAINTENANCE RECORDS VERIFYING THAT I HAD MAINTAINED THE VEHICLE. I FAXED WARENTECH COPIES OF ALL RECENT MAINTENANCE RECORDS. AFTER TWO OR THREE MORE DAYS, I ONCE AGAIN CONTACTED WARENTECH AND WAS ADVISED THAT I NEEDED TO SEND MORE MAINTENANCE RECORDS AND IF I DIDN'T HAVE ANYMORE THEY WOULD DENY COVERAGE FOR REPAIR TO THE VEHICLE. I FAXED OVER A TOTAL OF 13 MORE RECORDS OF MAINTENANCE VERIFYING THAT OIL CHANGES AS WELL AS OTHER MAINTENANCE RECORDS. THAT WAS TWO DAYS AGO AND I?VE NOT HEARD ANYTHING FROM WARENTECH SINCE. I HAVE ALREADY PAID $125 DOLLARS TO HAVE THE CAR TOWED TO THE DEALERSHIP AND HAVE PAID ANOTHER $140 FOR A RENTAL CAR TO GET TO AND FROM WORK. I AM VERY AFRAID THAT WARENTECH IS GOING TO REFUSE TO PAY FOR THE REPAIRS THEY'VE ALREADY HAD ALMOST 2-WEEKS AND NOTHING HAS BEEN DONE. I PAY $546 A MONTH CAR NOT VIA PAYROLL DEDUCTION AND HAVE NEVER MISSED A PAYMENT THIS FOR TWO YEARS AND I STILL OWE OVER$18K FOR THE CAR. I DON'T KNOW WHAT TO DO.
NHTSA ODI #10070082
Official recalls
5Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Feb 15, 2002
ON CERTAIN SPORT UTILITY VEHICLES, IF A DRIVER HAS NOT PLACED THE SHIFTER LEVER FULLY INTO THE "PARK" POSITION AND LEAVES THE VEHICLE RUNNING, THE VEHICLE MAY UNEXPECTEDLY MOVE REARWARD AFTER SEEMING TO BE STABLE.
Consequence & remedy
Consequence: INADVERTENT MOVEMENT OF THE VEHICLE COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A SECONDARY DETENT SYSTEM TO THE FLOOR SHIFTER ASSEMBLY. DAIMLERCHRYSLER SENT INTERIM NOTICES TO OWNERS CONCERNING THIS PROBLEM ON MARCH 22, 2002. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 10, 2000
VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, ILLINOIS, INDIANA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, OR WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT DISC BRAKE ROTORS CAN EXPERIENCE SEVERE CORROSION IF OPERATED FOR AN EXTENSIVE PERIOD IN THE "SALT BELT." IF THE ROTORS ARE NOT REPLACED, THE CORROSION CAN EVENTUALLY COMPROMISE THE STRUCTURAL INTEGRITY OF THE STAMPED STEEL CENTER HUB SECTION OF THE ROTOR.
Consequence & remedy
Consequence: THE REDUCED STRENGTH CAN ALLOW THE CAST IRON WEAR SURFACE TO SEPARATE FROM THE HUB, REDUCING THE BRAKE EFFECTIVENESS OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THESE ROTORS WITH ROTORS THAT ARE COATED WITH A CORROSION PROTECTION.
Nov 7, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE FUEL TANK MOUNTED FUEL LEVEL SENDING UNIT ACCURACY CAN DEGRADE OVER TIME, INDICATING SIGNIFICANTLY MORE FUEL IN RESERVE THAN IS ACTUALLY PRESENT.
Consequence & remedy
Consequence: OWNERS MAY NOT BE AWARE THAT THEIR VEHICLE IS LOW ON FUEL INCREASING THE RISK OF A VEHICLE CRASH IF THE VEHICLE STOPS DUE TO NO FUEL.
Remedy: DEALERS WILL REPLACE THE FUEL LEVEL SENDING UNIT.
May 16, 1997
THE ELECTRICAL CIRCUIT DESIGN ALLOWS THE POTENTIAL FOR AN INADVERTENT AIR BAG DEPLOYMENT UPON VEHICLE IGNITION SHUT DOWN.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE AIR BAG ELECTRONIC CONTROL MODULE WITH A NEWLY DESIGNED MODULE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
PE10031 · Crash Related Fuel Tank Fires
Opened Aug 23, 2010 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.
DP09005 · Fuel Storage System Crash Related Fires
Opened Nov 6, 2009 · Closed Aug 23, 2010
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.
EA02029 · Hood Latch Failure
Opened Oct 16, 2002 · Closed Feb 10, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages; Latches/locks/linkages:hood:latch; Structure
ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATCH ASSEMBLY OR COULD ACCOUNT FOR THEIR HIGHER COMPLAINT RATE.AS A RESULT, ODI EXPANDED THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL GRAND CHEROKEE VEHICLES EQUIPPED WITH THE SUBJECT HOOD LATCH ASSEMBLIES.IN PERFORMING EA02-029, IT WAS DETERMINED THAT SOME OF THE SECONDARY HOOD LATCHES IN THE SUBJECT VEHICLES MAY EXHIBIT INCREASED OPERATING FRICTIONAL RESISTANCE; HOWEVER, SINCE NONE OF THE PRIMARY HOOD LATCHES SHOWED ANY EVIDENCE OF MECHANICAL OR OPERATIONAL DEFICIENCY AND THE COMPLAINT RATE OF HOOD FLY-UPS MEASURED OVER AN EXTENDED EXPOSURE TIME WAS LOW, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.
Additional source detail variants (3)
Latches/locks/linkages
ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATCH ASSEMBLY OR COULD ACCOUNT FOR THEIR HIGHER COMPLAINT RATE.AS A RESULT, ODI EXPANDED THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL GRAND CHEROKEE VEHICLES EQUIPPED WITH THE SUBJECT HOOD LATCH ASSEMBLIES.IN PERFORMING EA02-029, IT WAS DETERMINED THAT SOME OF THE SECONDARY HOOD LATCHES IN THE SUBJECT VEHICLES MAY EXHIBIT INCREASED OPERATING FRICTIONAL RESISTANCE; HOWEVER, SINCE NONE OF THE PRIMARY HOOD LATCHES SHOWED ANY EVIDENCE OF MECHANICAL OR OPERATIONAL DEFICIENCY AND THE COMPLAINT RATE OF HOOD FLY-UPS MEASURED OVER AN EXTENDED EXPOSURE TIME WAS LOW, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.
Latches/locks/linkages:hood:latch
ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATCH ASSEMBLY OR COULD ACCOUNT FOR THEIR HIGHER COMPLAINT RATE.AS A RESULT, ODI EXPANDED THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL GRAND CHEROKEE VEHICLES EQUIPPED WITH THE SUBJECT HOOD LATCH ASSEMBLIES.IN PERFORMING EA02-029, IT WAS DETERMINED THAT SOME OF THE SECONDARY HOOD LATCHES IN THE SUBJECT VEHICLES MAY EXHIBIT INCREASED OPERATING FRICTIONAL RESISTANCE; HOWEVER, SINCE NONE OF THE PRIMARY HOOD LATCHES SHOWED ANY EVIDENCE OF MECHANICAL OR OPERATIONAL DEFICIENCY AND THE COMPLAINT RATE OF HOOD FLY-UPS MEASURED OVER AN EXTENDED EXPOSURE TIME WAS LOW, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.
Structure
ODI OPENED EA02-029 TO DETERMINE WHETHER A SAFETY-RELATED DEFECT TREND EXISTED IN THE MY 1997 JEEP GRAND CHEROKEE HOOD LATCH ASSEMBLIES.DURING EA02-029, THERE WAS NO SPECIFIC FAILURE MECHANISM IDENTIFIED THAT COULD DIFFERENTIATE THE MY 1997 VEHICLES FROM OTHER VEHICLES CONTAINING THIS SAME HOOD LATCH ASSEMBLY OR COULD ACCOUNT FOR THEIR HIGHER COMPLAINT RATE.AS A RESULT, ODI EXPANDED THE SCOPE OF THIS INVESTIGATION TO INCLUDE ALL GRAND CHEROKEE VEHICLES EQUIPPED WITH THE SUBJECT HOOD LATCH ASSEMBLIES.IN PERFORMING EA02-029, IT WAS DETERMINED THAT SOME OF THE SECONDARY HOOD LATCHES IN THE SUBJECT VEHICLES MAY EXHIBIT INCREASED OPERATING FRICTIONAL RESISTANCE; HOWEVER, SINCE NONE OF THE PRIMARY HOOD LATCHES SHOWED ANY EVIDENCE OF MECHANICAL OR OPERATIONAL DEFICIENCY AND THE COMPLAINT RATE OF HOOD FLY-UPS MEASURED OVER AN EXTENDED EXPOSURE TIME WAS LOW, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.
PE02045 · Hood Latch
Opened May 17, 2002 · Closed Oct 16, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA01017 · ROLL-AWAY In Reverse When Parked
Opened Nov 1, 2001 · Closed Dec 18, 2002
Status: closed (inferred from source dates) · Power Train
DAIMLERCHRYSLER HAS RECALLED THE ZJ MODELS TO INCORPORATE A SECONDARY DETENT SPRING INTO THE SHIFTER.EVEN THOUGH THE WJ 6 CYL. VEHICLES USE THE SAME MANUAL DETENT LEVER THAT AS THE VEHICLES IN THE RECALL POPULATION, ODI BELIEVES THAT THE WJ REDESIGNED SHIFTER, WHICH IMPROVES FLOOR SHIFTER FUNCTIONALITY AND ERGONOMICS, HELPS TO PROVIDE FEEDBACK TO THE DRIVER TO INDICATE WHETHER ?PARK? HAS OR HAS NOT BEEN ACHIEVED.ALTHOUGH THE INVESTIGATOR WAS ABLE TO INDUCE A ?FALSE PARK? IN THE WJ PLATFORM FOR 6 CYL. VEHICLES, THE LEVEL OF DIFFICULTY WAS GREATER THAN THAT REQUIRED FOR ALL ZJ MODELS, AND THE COMPLAINT RATE WAS SIGNIFICANTLY LOWER THAN THE RECALLED ZJ POPULATION.FURTHER, THE ODI INVESTIGATOR WAS ALSO ABLE TO CREATE A ?FALSE PARK? IN PEER VEHICLES WITH THE SAME LEVEL OF DIFFICULTY AND FREQUENCY AS THE SUBJECT VEHICLE WJ PLATFORM.THE WJ COMPLAINT RATE WAS INFLATED DUE TO NATIONAL EXPOSURE THROUGH THE PRESS. THE COMPLAINT RATE PRIER TO THE JULY 5, 2001 MEDIA COVERAGE FOR THE WJ VEHICLES IS SIMILAR TO THE PEER VEHICLE INCIDENT RATE.BASED ON THE ABOVE, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME IN THE WJ POPULATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED WITH A SAFETY RECAL FOR THE ZJ PLATFORM ONLY.
PE01021 · Inadvertent Rollaway In Reverse Park
Opened Jun 28, 2001 · Closed Nov 1, 2001
Status: closed (inferred from source dates) · Power Train
No summary supplied.
Illustration