2023 Jeep Grand Cherokee 4XE

Driving Screen, Swaybar Disconnect systems, Airbags, TPMS, Driving controls such as blinkers, and emergency flashers. The car was functioning normally, with no anomalies or error messages, including through phone notifications. The battery charge was nearly complete. I engaged Electric-Drive mode and used regenerative braking to recharge the battery on my way to town. Approximately 30 minutes into the drive, and with the battery at 99% charge, I heard a loud pop. It sounded like it was coming from the right-side passenger control arm. Shortly after, my dashboard was illuminated with warning lights, including a check engine light and notifications about air suspension and sway bar disconnection, airbags, tpms sensors, and more. The car decelerated dramatically; The dashboard screen flickered on and off as if rebooting. I got the vehicle safely, but during that time, the car seemed to be in limp mode, unresponsive to acceleration, and stiffer than normal breaking. The steering was also affected. I realized that if I had been on the highway, this could have caused a severe accident. Screen, Powertrain, and drivetrain fail while traveling 45+ miles an hour. It is a small 2-way road in turn with mild car and foot traffic around. The dealer has confirmed the issue as an issue that has been present in past vehicles in this model category. The car had been in my possession for less than 24 hours/40 driven miles.

The contact owns a 2023 Jeep Grand Cherokee. The contact stated while driving 15 MPH, the “4-WD mode Disabled”, and that the Automatic Emergency Braking activated messages were displayed. The vehicle then independently turned off. The contact stated that there were no other vehicles in front of the vehicle at the time of the failure. The contact was able to veer to the side of the road. The contact stated that upon restarting the vehicle, the messages were no longer displayed. The contact continued driving; however, the vehicle failed to shift smoothly into the intended gear. The vehicle was taken to the dealer, where diagnostic codes related to the transmission valve body were retrieved. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 1,100.

Transmission started leaking and spraying transmission fluid while driving. Fluid hits exhaust and then smokes and burns off. Jeep has replaced various parts however it appears that the ZF transmissions are failing / have cracks in the housing. Dealer acknowledges the problem. Upon the 2nd failure dealer had us tow it to the dealership. The Jeep is now at the dealer waiting for a response from FCA on what is to be done. This is occurring on a number of Jeeps - both Grand Cherokee 4Xe's and Wrangler 4Xe's. No warning lamps - just a burning smell when driving. We have concerns about catastrophic failure while driving. Also concerned about potential fire due to the fluid leaking onto the exhaust system. Was first discovered by the dealer during routine maintenance. Regarding my dates: I noticed the burning smell when the Jeep was new - Thought it was just the normal burn off of materials on a new vehicle. This leak comes and goes more often after long trips.

On February 23rd 2023 I picked up my new 2023 Jeep Grand Cherokee 4xe from conway Jeep in South Carolina . On the way home I noticed my foot kept slipping off the accelerator pedal and wasn't sure what was causing it. When I arrived home I noticed the accelerator pedal was made from a slick piece of plastic and didn't have a rubber cover or anti slip material installed like the brake pedal had. I contacted the jeep dealership and asked if jeep forgot to install one at the factory and if so please have one sent out. A representative spoke with their techs to order a new one and they stated jeep doesn't offer that part nor was it on the entire pedal assembly to order. They ended up checking all their grand cherokee 4xes on the lot and they all came like that. Jeep corporate office was notified on Feb 28th 2023 reporting my safety concern about having a pedal without any type of grip to help prevent a person's foot from slipping could cause a vehicle accident. The representative stated jeep does not make a part for that nor were they planning on fixing this safety issue and I should just go to an auto parts store to find something for it. To my knowledge every other vehicle that jeep currently manufactures has rubber material on the accelerator pedal. I also thought manufacturers were required by law to have some type of anti slip material on the accelerator, brakes, and clutch.