Illustration2006 JEEP COMMANDER STALLS OUT AT LOW SPEEDS. CAR SHUTS DOWN, NEED TO PUT ON BRAKE, TURN OFF ENGINE, AND RESTART VEHICLE. HAS BEEN VERY CLOSE CALLS ON BEING REAR ENDED WHEN CROSSING TRAFFIC SIGNALS AND STOP SIGNS. HAS RECURRED 20 TIMES. *TR
2006 Jeep Commander 4X2
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
480–25K
1525–50K
1550–75K
1675–100K
20100–150K
5150K+
119 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports0 fire reports1 injury reports
Engine And Engine Cooling complaints
36 reportsTL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE VEHICLE STALLS WHEN DRIVING AT 5 MPH. THE FAILURE HAS OCCURRED TWICE. WHILE PULLING OUT OF A PARKING LOT, THE VEHICLE APPEARED AS IF IT WOULD STALL. THE CONTACT APPLIED THE BRAKES AND CRASHED INTO THE SIDE OF ANOTHER VEHICLE. A POLICE REPORT WAS FILE…
Read full complaint
TL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE VEHICLE STALLS WHEN DRIVING AT 5 MPH. THE FAILURE HAS OCCURRED TWICE. WHILE PULLING OUT OF A PARKING LOT, THE VEHICLE APPEARED AS IF IT WOULD STALL. THE CONTACT APPLIED THE BRAKES AND CRASHED INTO THE SIDE OF ANOTHER VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT SHE WAS NOT APPLYING ENOUGH IN ORDER TO KEEP IT FROM STALLING. SHE CALLED THE MANUFACTURER WHO STATED THAT NO ONE ELSE IS ENCOUNTERING THIS FAILURE. NO RECALLS WERE AVAILABLE FOR THE VEHICLE. THE MANUFACTURER ADVISED HER TO CALL HER DEALER. THE DEALER STATED THAT THEY DO NOT KNOW HOW TO DUPLICATE THE FAILURE. THE CURRENT MILEAGE IS 8,894 AND FAILURE MILEAGE WAS 8,000.
WHILE TRAVELING OVER 70 MPH ON THE HIGHWAY, THE VEHICLE STALLED. I ASSUMED IT WAS DUE TO IT BEING LOWER THAN 1/4 FULL. I REFUELED WITH 87 OCTANE TO FULL, BUT THE VEHICLE CONTINUED TO STALL AT FULL STOPS AND ON THE HIGHWAY A TOTAL OF 9 MORE TIMES. THE NEXT DAY THE VEHICLE STALLED AGAIN SO I REFILLED IT WITH 89 OCTANE. THE VEH…
Read full complaint
WHILE TRAVELING OVER 70 MPH ON THE HIGHWAY, THE VEHICLE STALLED. I ASSUMED IT WAS DUE TO IT BEING LOWER THAN 1/4 FULL. I REFUELED WITH 87 OCTANE TO FULL, BUT THE VEHICLE CONTINUED TO STALL AT FULL STOPS AND ON THE HIGHWAY A TOTAL OF 9 MORE TIMES. THE NEXT DAY THE VEHICLE STALLED AGAIN SO I REFILLED IT WITH 89 OCTANE. THE VEHICLE STOPPED STALLING AFTER THAT. *TR
VEHICLE HAS STALLED TWICE DURING THE LAST WEEK. ONCE DRIVING THROUGH A NEIGHBORHOOD AS 20 MPH. SECOND TIME WAS TURNING INTO A PARKING SPACE AT A TARGET STORE. *TR
TL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. WHILE DRIVING 2-5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE ALSO LOST POWER STEERING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 8,755.
WHEN THE VEHICLE WAS RUNNING THE ENGINE AND ELECTRICAL SYSTEM TURNED OFF BY ITSELF. I WASVERY AFFRAID BECAUSE THE VEHICLE WAS USED BY MY WIFE. I REPORTED THIS TO TRIANGLE JEEP DEALERS MANTAINANCE SERVICE, BUT THEY DID NOT FIND THE PROBLEM. THE WARRANTY WAS CLOSE TO EXPIRE AND THE CRITICAL PROBLEM PERSISTED. *AK
TL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE IDLING AND ALSO WHEN THE CRUISE CONTROL WAS ACTIVATED AT 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER TWICE, BUT THE FAILURE COULD NOT BE DUPLICATED. THE CURRENT MILEAGE IS 12,800 AND FAILURE MILEAGE WAS 8,000.
VEHICLE STALLS WITH NO WARNING. VEHICLE STALLED ABOUT A DOZEN TIMES. DEALERSHIP HAD VEHICLE IN THREE TIMES AND CANNOT REPAIR. *TR
JEEP COMMANDER STALLS AT ALL SPEEDS. IT HAS HAPPEN TO VEHICLE 8 TIMES SINCE I HAVE OWNED IT. THE MOST RECENT INCIDENT HAPPEN ON MARCH 14 2007. PULLING OUT OF GROCERY STORE PARKING LOT AND JEEP COMPLETELY DIES. CARS LOCK THERE BRAKES TO AVOID HITTING MY CAR. I HAD MY WIFE AND 2 YR OLD DAUGHTER IN CAR WITH ME. DROVE CAR TO D…
Read full complaint
JEEP COMMANDER STALLS AT ALL SPEEDS. IT HAS HAPPEN TO VEHICLE 8 TIMES SINCE I HAVE OWNED IT. THE MOST RECENT INCIDENT HAPPEN ON MARCH 14 2007. PULLING OUT OF GROCERY STORE PARKING LOT AND JEEP COMPLETELY DIES. CARS LOCK THERE BRAKES TO AVOID HITTING MY CAR. I HAD MY WIFE AND 2 YR OLD DAUGHTER IN CAR WITH ME. DROVE CAR TO DEALERSHIP RIGHT AWAY AND TOLD THEM TO FIX IT. THEY TOLD ME LATER THAT DAY THEY COULD NOT FIND ANYTHING WRONG WITH IT AND JUST FLASHED THE COMPUTER FOR THE THIRD TIME. DO NOT FEEL SAFE IN CAR. THERE IS NO PARTICULAR TIME OF THE DAY, TEMPERATURE OR SPEED WHEN CAR STALLS. WORKING ON GETTING RID OF THE CAR AND GET ONE I DO NOT HAVE WORRY ABOUT GETTING HURT OR POSSIBLE DYING IN. *JB
TL*- THE CONTACT OWNS A 2006 JEEP COMMANDER WITH A CURRENT AND FAILURE ODOMETER READING OF 5000 MILES. THE CONTACT STATED THAT THE VEHICLE STALLED AT HIGH SPEEDS. THE CONTACT WAS DRIVING UNDER DRY CONDITIONS AT ABOUT 70 MPH WHEN THE STALLING OCCURRED. THE CONTACT WAS ABLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD WITHOUT A CRA…
Read full complaint
TL*- THE CONTACT OWNS A 2006 JEEP COMMANDER WITH A CURRENT AND FAILURE ODOMETER READING OF 5000 MILES. THE CONTACT STATED THAT THE VEHICLE STALLED AT HIGH SPEEDS. THE CONTACT WAS DRIVING UNDER DRY CONDITIONS AT ABOUT 70 MPH WHEN THE STALLING OCCURRED. THE CONTACT WAS ABLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD WITHOUT A CRASH. ONCE THE VEHICLE WAS IN PARK THEN IT WOULD RESTART WITH NO PROBLEM. THE CONTACT TOOK THE VEHICLE TO THE DEALER, AND THEY SAID THAT THEY COULD NOT FIND ANY PROBLEMS WITH THE VEHICLE. THE CONTACT ALSO CALLED THE MANUFACTURER, AND THEY TOLD HIM THAT THEY WOULD TALK ABOUT HIS VEHICLE, BUT OFFERED NO SOLUTION. *AK UPDATED 8/10/09 *CN UPDATED 08/13/09.*JB
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
DP06002 · Petition Re: Unintended Acceleration
Opened Jul 13, 2006 · Closed Jan 3, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Fuel System, Other:fuel Injection System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Additional source detail variants (4)
Engine And Engine Cooling:engine
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Fuel System, Other:fuel Injection System
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.