NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
36 reportsClear category filter2,500 miles · Jan 8, 2008
Engine And Engine Cooling
2006 JEEP COMMANDER ENGINE DIES SUDDENLY. TWO DIFFERENT DEALERS COULD FIND NOTHING WRONG. PROBLEMS OCCURRED AT LEAST 14 TIMES AND 7 TIMES IN THE LAST 90 DAYS. FIRST OCCURRED AT 2500 MILES AND DEALER SAID NOTHING WRONG. OCCURRED AT 8000, 9000, 12000, 15100, 15500, 17500, 18600, 18700, 19000 AND 19406. AT 17500 TOOK TO DIFFERENT D…
Read full complaint
2006 JEEP COMMANDER ENGINE DIES SUDDENLY. TWO DIFFERENT DEALERS COULD FIND NOTHING WRONG. PROBLEMS OCCURRED AT LEAST 14 TIMES AND 7 TIMES IN THE LAST 90 DAYS. FIRST OCCURRED AT 2500 MILES AND DEALER SAID NOTHING WRONG. OCCURRED AT 8000, 9000, 12000, 15100, 15500, 17500, 18600, 18700, 19000 AND 19406. AT 17500 TOOK TO DIFFERENT DEALER WHO REPLACED THE BATTERY AFTER TOWING IT IN AND KEPT CAR FOR 4 DAYS TO TRY AND DIAGNOSE ISSUE. ON 12/8, WE SMELLED GAS AND WE COULD NOT RESTART IT FOR 30 SECONDS. ON 12/21 IT DIED ON A RAILROAD CROSSING. MY WIFE CROSSES 6 TRACKS A DAY AND IT HAS DIED ONE OTHER TIME ON THE TRACKS, AND ONE TIME WHILE MERGING INTO 65 MPH TRAFFIC. HAVE SPENT 1 HOUR ON PHONE WITH CHRYSLER CUSTOMER SERVICE SO FAR BECAUSE I TOLD THEM WE ONLY DRIVE IT TO WORK AND WE WANT A LOANER OR NEW VEHICLE IMMEDIATELY. AM ALSO PROCEEDING WITH TEXAN LEMON LAW FILING. THIS LOOKS LIKE NHTSA#EA07007. *TR
NHTSA ODI #10214246
29,890 miles · Dec 8, 2007
Engine And Engine Cooling
JEEP COMMANDER STALLS WHEN SLOWING, OR PARKED. THERE HAS ALSO BEEN ONE OCCASION WHERE THE VEHICLE STALLED ON THE INTERSTATE AT 70MPH. THE VEHICLE WAS JUST SERVICED ON THE 6TH OF DECEMBER AND THE DEALERSHIP "COULD NOT DUPLICATE THE ISSUE", HOWEVER SINCE I HAVE GOT THE VEHICLE BACK IT HAS BEEN WORSE. *TR
NHTSA ODI #10211197
Mileage unknown · Dec 2, 2007
Electrical SystemEngine And Engine Cooling
2006 JEEP COMMANDERS ENGINE STALLS AND HEADLIGHTS GO OUT. I TOOK IT TO THE DEALERSHIP, AT WHICH TIME THEY ADVISED THAT THEY COULD NOT HELP ME. THEY SAID THEY WOULD HAVE TO SEE IT HAPPEN...LIKE WHEN MY LIGHTS WENT OUT ON A DARK FREEWAY ALMOST KILLING ME AND MY HUSBAND. *TR
NHTSA ODI #10210486
6,000 miles · Oct 29, 2007
Engine And Engine CoolingPower Train
TL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE ENGINE STALLED AT LEAST FIVE TIMES. THE VEHICLE LOST POWER AND THE ENGINE COMPLETELY SHUT OFF WHILE DRIVING 40 MPH. SHE ONLY HAD TO TURN THE KEY ONCE TO RESTART THE ENGINE. SHE ALSO STATED THAT THE TRANSMISSION LIGHT ILLUMINATED DURING THE STALLING AN…
Read full complaint
TL*THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE ENGINE STALLED AT LEAST FIVE TIMES. THE VEHICLE LOST POWER AND THE ENGINE COMPLETELY SHUT OFF WHILE DRIVING 40 MPH. SHE ONLY HAD TO TURN THE KEY ONCE TO RESTART THE ENGINE. SHE ALSO STATED THAT THE TRANSMISSION LIGHT ILLUMINATED DURING THE STALLING AND THE TRANSMISSION WAS STUCK IN THIRD GEAR. THE CONTACT HAD TO DRIVE NINE MILES TO THE DEALER WITH THE VEHICLE IN THIRD GEAR. SHE PAID OUT OF POCKET FOR THE REPAIR. THE DEALER STATED THAT THE FAILURE WAS CAUSED BY BUILD UP IN THE TRANSMISSION FILTER. THE CURRENT MILEAGE IS 16,011. UPDATED 01-14-08. *KB UPDATED 12/12/07.*JB
NHTSA ODI #10207374
7,050 miles · Oct 1, 2007
Engine And Engine Cooling
WHILE DRIVING MY 2006 JEEP COMMANDER IN A VERY CROWDED PARKING LOT, IT COMPLETELY STALLED WITHOUT WARNING!! THE CAR BEHIND ME HAD TO MAKE A VERY SUDDEN STOP TO AVOID AN ACCIDENT. THE POWER STEERING AND BRAKES WENT OUT AND I HAD TO PUT THE CAR IN PARK AND RESTART IT. THIS SAME THING OCCURRED WHEN MY HUSBAND WAS DRIVING IT APPROX.…
Read full complaint
WHILE DRIVING MY 2006 JEEP COMMANDER IN A VERY CROWDED PARKING LOT, IT COMPLETELY STALLED WITHOUT WARNING!! THE CAR BEHIND ME HAD TO MAKE A VERY SUDDEN STOP TO AVOID AN ACCIDENT. THE POWER STEERING AND BRAKES WENT OUT AND I HAD TO PUT THE CAR IN PARK AND RESTART IT. THIS SAME THING OCCURRED WHEN MY HUSBAND WAS DRIVING IT APPROX. ONE MONTH AGO, BUT WE WRONGLY ATTRIBUTED IT TO THE CAR HAVING ONLY A QUARTER TANK OF GAS IN IT AT THE TIME. I HAVE 8 YEAR OLD TRIPLETS THAT DEPEND ON THIS CAR DAILY AND I WILL NOT PUT THEIR SAFETY AT RISK!! PLEASE HELP US SCARED COMMANDER OWNERS TO MAKE CHRYSLER DO THE RIGHT THING BEFORE SOMEONE IS SERIOUSLY INJURED OR EVEN KILLED. THANK YOU. *JB
NHTSA ODI #10204603
20,000 miles · Sep 5, 2007
Engine And Engine Cooling
MY 2006 JEEP COMMANDER STALLS AT HIGHWAY SPEEDS AND HAS TO BE RESTARTED IN MOTION. IT ALSO STALLS IN THE MIDDLE OF INTERSECTIONS AND WHILE SITTING AT A STOP LIGHT. I HAVE BEEN STRANDED IN THE MIDDLE OF AN INTERSECTION AT LEAST 4 TIMES AND IT HAS HAPPENED AT 70MPH AT LEAST TWICE. I AM AFRAID TO DRIVE THIS VEHICLE. THE DEALER …
Read full complaint
MY 2006 JEEP COMMANDER STALLS AT HIGHWAY SPEEDS AND HAS TO BE RESTARTED IN MOTION. IT ALSO STALLS IN THE MIDDLE OF INTERSECTIONS AND WHILE SITTING AT A STOP LIGHT. I HAVE BEEN STRANDED IN THE MIDDLE OF AN INTERSECTION AT LEAST 4 TIMES AND IT HAS HAPPENED AT 70MPH AT LEAST TWICE. I AM AFRAID TO DRIVE THIS VEHICLE. THE DEALER HAS DONE ALL THEY CAN TO TRY TO FIX IT BUT CAN NEVER RECREATE THE PROBLEM. IT STOPPED FOR ABOUT 6-8 MONTHS BUT YESTERDAY THEY HAD TO REPLACE MY BATTERY AND IT STARTED ALL OVER AGAIN. IT HAS DONE IT 3 TIME IN THE LAST 24HRS WITH MY CHILDERN IN THE CAR. I HAVE SEEN NUMEROUS POSTS REGARDING THE SAME PROBLEM AND CAN'T BELIEVE A RECALL HAS NOT BEEN ISSUED. I GUESS SOMEONE HAS TO BE INJURED OR WORSE. *TR
NHTSA ODI #10202004
25,000 miles · Aug 6, 2007
Engine And Engine Cooling
ENGINE STALLS AT HIGHWAY SPEEDS. LOSS OF POWER STEERING AND BRAKES. *TR
NHTSA ODI #10198573
2,700 miles · Aug 5, 2007
Engine And Engine Cooling
I HAVE A 2006 COMMANDER WHICH TRIES TO DIE WHEN IDLING. WHILE WAITING IN LINE AT BANK OR AT STOP SIGNS/LIGHTS. THE RPMS DROP FROM USUALLY 1000RPM TO BELOW 500RPM. I HAVE FOUND THAT IT WILL ONLY DO THIS IN DRIVE. IF I SHIFT IT INTO NEUTRAL, THE RPMS IMMEDIATELY GO BACK UP. IT HAS HAPPENED FOR THE PAST YEAR, AT LEAST TWICE A MON…
Read full complaint
I HAVE A 2006 COMMANDER WHICH TRIES TO DIE WHEN IDLING. WHILE WAITING IN LINE AT BANK OR AT STOP SIGNS/LIGHTS. THE RPMS DROP FROM USUALLY 1000RPM TO BELOW 500RPM. I HAVE FOUND THAT IT WILL ONLY DO THIS IN DRIVE. IF I SHIFT IT INTO NEUTRAL, THE RPMS IMMEDIATELY GO BACK UP. IT HAS HAPPENED FOR THE PAST YEAR, AT LEAST TWICE A MONTH. *JB
NHTSA ODI #10198557
6,500 miles · Jul 30, 2007
Engine And Engine Cooling
2006 JEEP COMMANDER STALLS WHEN DRIVING. UNEXPECTED AND UNPREDICTABLE. *JB
NHTSA ODI #10197795
Mileage unknown · Jul 23, 2007
Engine And Engine Cooling
ENGINE STALLS OCCURRED 4 TIMES IN THE YEAR SINCE OBTAINED. ALL AT LOW SPEED. POSSIBLE STALL AT HIGH SPEED BUT SEEMED ENGINE STARTED ITSELF UP. OTHER TIMES HAD TO RESTART. *TR
NHTSA ODI #10197198
NHTSA investigations
4PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
DP06002 · Petition Re: Unintended Acceleration
Opened Jul 13, 2006 · Closed Jan 3, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Fuel System, Other:fuel Injection System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Additional source detail variants (4)
Engine And Engine Cooling:engine
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Fuel System, Other:fuel Injection System
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Illustration