NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
66 reportsClear category filter100,000 miles · Apr 15, 2019
Electrical SystemUnknown Or Other
MY CAR LEAKS DURING RAIN FROM THE SUNROOF TO THE BLUE HOSE DRAIN AND FLOODED MY CAR. WHICH MESSED UP THE ELECTRICAL SYSTEM. I'M HAVING PROBLEMS WITH MY CAR SAYING IT'S OVER HEATING BUT IT'S NOT IT'S THE ELECTRICAL SYSTEM TELLING THE COMPUTER IN CAR THAT IT'S HOW WHEN ITS NOT AND NOW MY TRANSMISSION IS MESSED UP WE THINK. MY CAR …
Read full complaint
MY CAR LEAKS DURING RAIN FROM THE SUNROOF TO THE BLUE HOSE DRAIN AND FLOODED MY CAR. WHICH MESSED UP THE ELECTRICAL SYSTEM. I'M HAVING PROBLEMS WITH MY CAR SAYING IT'S OVER HEATING BUT IT'S NOT IT'S THE ELECTRICAL SYSTEM TELLING THE COMPUTER IN CAR THAT IT'S HOW WHEN ITS NOT AND NOW MY TRANSMISSION IS MESSED UP WE THINK. MY CAR IS CURRENTLY AT JEEP DEALER IN CERRITOS, CA FOR 2 DAYS NOW AND NO ONE CAN TELL ME WHAT WRONG.
NHTSA ODI #11196586
60,000 miles · Jul 1, 2018
Electrical SystemStructure
THE SUNROOF DRAIN DESIGN WAS FAULTY. DURING RAINING WEATHER, THE SUNROOF DRAINS CANNOT HANDLE THE COLLECTED RAIN AND THE RAIN WILL OVERFLOW AND GO INTO THE CAR. THE RAIN THAT OVERFLOWS FALLS INTO THE FRONT PANEL AND HAS CAUSED MULTIPLE ELECTRICAL FAILURES AND SHORTAGES. MOST IMPORTANTLY THE WATER HAS DAMAGED THE INSTRUMENT PANEL…
Read full complaint
THE SUNROOF DRAIN DESIGN WAS FAULTY. DURING RAINING WEATHER, THE SUNROOF DRAINS CANNOT HANDLE THE COLLECTED RAIN AND THE RAIN WILL OVERFLOW AND GO INTO THE CAR. THE RAIN THAT OVERFLOWS FALLS INTO THE FRONT PANEL AND HAS CAUSED MULTIPLE ELECTRICAL FAILURES AND SHORTAGES. MOST IMPORTANTLY THE WATER HAS DAMAGED THE INSTRUMENT PANEL AND HEADLIGHT CONTROLS WHICH CAUSES THEM TO SHUT OFF WHILE OPERATING THE VEHICLE.
NHTSA ODI #11104961
135,000 miles · Sep 14, 2017
Electrical SystemStructure
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER DOOR HANDLES FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER (HOLLYWOOD CHRYSLER JEEP, FT. LAUDERDALE, FLORIDA, 954-399-598) WHERE IT WAS DIAGNOSED THAT THE DOOR PANELS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE …
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER DOOR HANDLES FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER (HOLLYWOOD CHRYSLER JEEP, FT. LAUDERDALE, FLORIDA, 954-399-598) WHERE IT WAS DIAGNOSED THAT THE DOOR PANELS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. LATER, THE REAR DRIVER AND PASSENGER DOOR HANDLES ALSO FRACTURED. THE FAILURES WERE NOT REPAIRED. ADDITIONALLY, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 135,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11023536
157,000 miles · Aug 22, 2017
Electrical SystemEngine
THE A/C INLET FITTING IS DEFECTIVE CAUSING THE COOLANT TO LEAK OUT AND THE ENGINE TO OVERHEAT, THE PCM IS DEFECTIVE AND SAYS THE TIRE PRESSURE IS LOW WHEN IT ISNT
NHTSA ODI #11018949
175,796 miles · Mar 2, 2017
Electrical SystemEnginePower Train
DRIVING UNDER CERTAIN CONDITIONS THE VEHICLE ENGINE COMPLETELY SHUTS OFF AND STALLS. THIS HAPPENS ON THE HIGHWAY, MOSTLY AT SPEEDS OF ABOUT 45-60 MPH. THE TWO RECALLS AVAILABLE ON THE VEHICLE AS IT RELATES TO THIS ISSUE (TCM/PCM ) ( IGNITION SWITCH) HAVE BEEN RECENTLY FIXED BY THE DEARLERSHIP, HOWEVER THE VEHICLE CONTINUES TO M…
Read full complaint
DRIVING UNDER CERTAIN CONDITIONS THE VEHICLE ENGINE COMPLETELY SHUTS OFF AND STALLS. THIS HAPPENS ON THE HIGHWAY, MOSTLY AT SPEEDS OF ABOUT 45-60 MPH. THE TWO RECALLS AVAILABLE ON THE VEHICLE AS IT RELATES TO THIS ISSUE (TCM/PCM ) ( IGNITION SWITCH) HAVE BEEN RECENTLY FIXED BY THE DEARLERSHIP, HOWEVER THE VEHICLE CONTINUES TO MULFUNCTION IN THE SAME MANNER AND APPEARS TO BE GETTING WORSE. CONTACTING CHRYSLER, THEY ARE ABRASIVE AND UNCOOPERATIVE. A LITTLE RESEARCH SHOWS THAT THERE ARE SEVERAL OWNER COMPLAINTS ON THIS VERY ISSUE DATING BACK TO 2006-2007-2008. THERE APPEARS TO BE AN "ACTIVE" INVESTIGATION ONGOING BY THE NHTSA-OFFICE OF DEFECTS INVESTIGATIONS. WHAT IS THE STATUS OF THIS INVESTIGATION-10 YEARS LATER??? THERE APPEARS TO BE NO INTEREST ON THE PART OF THE MANAUFACTURER TO ADDRESS THIS ISSUE WITHOUT THE VEHICLE OWNER INCURRING MASSIVE LOSES IN ENDLESS DIAGNOSTIC AND REPAIR EXPENSES.
NHTSA ODI #10958008
120,000 miles · Jun 28, 2016
Electrical SystemPower Train
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. WHILE DRIVING 55 MPH, THE GEAR SHIFT LEVER MOVED OUT OF THE DRIVE POSITION INTO NEUTRAL WITHOUT WARNING. THE CONTACT WAS ABLE TO PLACE THE VEHICLE BACK INTO THE DRIVE POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRANS…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. WHILE DRIVING 55 MPH, THE GEAR SHIFT LEVER MOVED OUT OF THE DRIVE POSITION INTO NEUTRAL WITHOUT WARNING. THE CONTACT WAS ABLE TO PLACE THE VEHICLE BACK INTO THE DRIVE POSITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRANSMISSION SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V175000 (ELECTRICAL SYSTEM, POWER TRAIN). THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 09/22/16*LJ *JS
NHTSA ODI #10881223
140,000 miles · Nov 5, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE SHUT OFF. THE VEHICLE WAS ABLE TO BE RESTARTED ON THE FIRST ATTEMPT. THE FAILURE RECURRED MULTIPLE TIMES INTERMITTENTLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM) HOWEVER, THE PART WAS U…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE SHUT OFF. THE VEHICLE WAS ABLE TO BE RESTARTED ON THE FIRST ATTEMPT. THE FAILURE RECURRED MULTIPLE TIMES INTERMITTENTLY. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM) HOWEVER, THE PART WAS UNAVAILABLE TO PERFORM THE REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REMEDY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. PARTS DISTRIBUTION DISCONNECT. UPDATED 02/12/16*LJ THE CONSUMER STATED HER VEHICLE IS GETTING MORE AND MORE DIFFICULT TO CONTROL. *TR
NHTSA ODI #10788691
45,000 miles · Nov 4, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM); HOWEVER, THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO INSERT INTO THE IGNITION SWITCH AS WELL. ONCE INSERTED, THE KEY WAS DIFFICULT TO TURN. THE CONTACT ALSO STATED THAT…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM); HOWEVER, THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO INSERT INTO THE IGNITION SWITCH AS WELL. ONCE INSERTED, THE KEY WAS DIFFICULT TO TURN. THE CONTACT ALSO STATED THAT IT WAS DIFFICULT TO REMOVE THE KEY FROM THE IGNITION SWITCH. THE FAILURE RECURRED EACH TIME THE KEY WAS INSERTED OR REMOVED FROM THE IGNITION SWITCH. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000. UPDATED 02/05/16*LJ THE CONSUMER STATED SHE IS STILL HAVING PROBLEMS WITH THE VEHICLE. *TR
NHTSA ODI #10788411
Mileage unknown · Oct 27, 2015
Electrical System
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NO…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP COMMANDER 4X2. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V438000 (ELECTRICAL SYSTEM) HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10786229
106,000 miles · Oct 25, 2015
Electrical SystemUnknown Or Other
DRIVING DOWN THE HIGHWAY AND THE VEHICLE POWERED DOWN AS IF TO SHUT OFF. IT THEN THANKFULLY STARTED AGAIN. I TOOK IT TO PROGRESSIVE CHEVROLET IN MASSILLON AND THEY CONFIRMED IT IS PART OF THE P41/NHTSA 14V-438 RECALL. IT HAS BEEN THERE FOR 45 DAYS. CHRYSTLER INFORMS ME THE PARTS ARE AVAILABLE AND WILL BE THERE WITHIN THE WEE…
Read full complaint
DRIVING DOWN THE HIGHWAY AND THE VEHICLE POWERED DOWN AS IF TO SHUT OFF. IT THEN THANKFULLY STARTED AGAIN. I TOOK IT TO PROGRESSIVE CHEVROLET IN MASSILLON AND THEY CONFIRMED IT IS PART OF THE P41/NHTSA 14V-438 RECALL. IT HAS BEEN THERE FOR 45 DAYS. CHRYSTLER INFORMS ME THE PARTS ARE AVAILABLE AND WILL BE THERE WITHIN THE WEEK. PROGRESSIVE INFORMS ME THE PARTS ARE NOT AVAILABLE. I HAVE BEEN WAITING SINCE SEPTEMBER 11, 2015 FOR THE PART.
NHTSA ODI #10785867
NHTSA investigations
4PE14017 · Air Bag Non-deployment
Opened Jun 16, 2014 · Closed Dec 23, 2014
Status: closed (inferred from source dates) · Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Additional source detail variants (3)
Electrical System:ignition
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:module
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
Electrical System:ignition:switch
Chrysler is conducting a safety recall of approximately 643,618 model year 2006-2007 Jeep Commander and model year 2005-2007 Jeep Grand Cherokee vehicles to address the problem of ignition turning off while driving (see NHTSA recall 14V-438 for more information).According to Chrysler, these vehicles may experience an unintended change in ignition switch position while driving, which may result in loss of engine power, power steering, and braking assist, increasing the risk of a crash and disabling one or more of the vehicle's safety features including the frontal air bags.Most of the reported incidents occurred as a result of driver interaction with the ignition key.Based on the recall action taken by Chrysler, this Preliminary Evaluation is closed.Additionalinformation on this closing resume, and the investigation are in the PE14-017 public file available online at SaferCar.gov.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10101116 10103300 10106060 10112589 10116788 10126986 10128093 10130780 10145501 10146213 10153018 10155291 10156396 10158165 10162933 10166746 10178559 10183305 10186545 10189530 10192237 10193106 10194092 10199552 10199986 10221500 10222283 10227253 10231011 10328609 10358324 10392364 10577532 10585326 10585976 10599142 10604990 10605091 10605209 10606494 10606610 10607043 10607614 10607785 10608196 10615565 10615671 10615761 10616124 10633266 10633313 10633724 10639371 10640010 10644827 10652526 10653000 10653382 10654009 10654139 10654809 10655095 10659448 10662220 10662703
EA07007 · Engine Stalling
Opened Apr 27, 2007 · Closed May 7, 2008
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Additional source detail variants (3)
Electrical System
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Engine And Engine Cooling
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ON MAY 5, 2008, CHRYSLER LLC (CHRYSLER) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING AN ENGINE CALIBRATION ISSUE THAT COULD RESULT IN ENGINE STALL IN APPROXIMATELY 24,461 MODEL YEAR (MY) 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH THE 4.7L V-8 ENGINE AND BUILT FROM FEBRUARY 25, 2005 THROUGH JANUARY 11, 2006.ACCORDING TO CHRYSLER, THE POWERTRAIN CONTROL MODULE (PCM) WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL DURING CERTAIN OPERATING CONDITIONS.CHRYSLER DEALERS WILL REPROGRAM THE PCM SOFTWARE IN THE RECALLED VEHICLES. INFORMATION PROVIDED BY CHRYSLER DURING PE07-009 AND EA07-007 INDICATED THAT A REVISED ENGINE CALIBRATION WAS IMPLEMENTED IN PRODUCTION EFFECTIVE JANUARY 12, 2006 FOR THE MY 2006 JEEP COMMANDER VEHICLES EQUIPPED WITH 4.7L V-8 ENGINES.ODI'S ANALYSIS OFCONSUMER COMPLAINTS, FIELD REPORTS AND OTHER DATA RELATED TO FIELD EXPERIENCE WITH ENGINE STALLING IN MY 2006 THROUGH 2007 JEEP COMMANDER VEHICLES EQUIPPED WITH 3.7L, 4.7L AND 5.7L ENGINES IDENTIFIED AN ELEVATED RATE OF STALLING INCIDENTS IN THE MY 2006 VEHICLES EQUIPPED WITH 4.7L ENGINES THAT WERE MANUFACTURED BEFORE THE CALIBRATION CHANGE.ODI INTERVIEWED OVER 70 CONSUMERS WHO REPORTED STALLING INCIDENTS IN EARLY PRODUCTION MY 2006 4.7L VEHICLES.INFORMATION GATHERED FROM THOSE INTERVIEWS INDICATED THAT THE STALLING INCIDENTS WERE OCCURRING AT VARIOUS SPEEDS, OFTEN OCCURRED DURING TURNS AND TYPICALLY OCCURRED MORE THAN ONCE.THE INTERVIEWS DID NOT IDENTIFY ANY CONCERNS WITH RESTARTABILITY. ALTHOUGH THE EARLY MY 2006 PRODUCTION VEHICLES WITH 4.7L ENGINES MAKE UP ONLY ABOUT 15 PERCENT OF ALL MY 2006 THROUGH 2007 JEEP COMMANDERS BUILT BY CHRYSLER, THEY WERE RESPONSIBLE FOR 465 OF THE 854 REPORTED STALLING INCIDENTS (54%), 6 OF THE 12 CRASH INCIDENTS (50%) AND THE ONLY INJURY CLAIM.THE STALLING RATE FOR THE RECALLED VEHICLES IS 1.90 PERCENT, ALMOST 7 TIMES GREATER THAN THE RATE IN THE REMAINING POPULATION (0.28 PERCENT).CHRYSLER'S RECALL COVERS THE VEHICLES WITH THE ELEVATED STALLING RATE.THE REMAINING VEHICLES HAVE RELATIVELY LOW RATES OF STALLING AND DO NOT EXHIBIT ANY SIGNS OF AGGRAVATING FACTORS SUCH AS PROBLEMS WITH RESTART. ODI ALSO ANALYZED COMPLAINTS ALLEGING CONCERNS WITH LOSS OF LIGHTING COINCIDENT TO STALLING INCIDENTS.THIS ANALYSIS IDENTIFIED SEVEN STALLING INCIDENTS WHERE LOSS OF EXTERIOR LIGHTING WAS ALLEGED.NO SPECIFIC CAUSE WAS IDENTIFIED IN THESE INCIDENTS AND THERE WAS NO DISCERNIBLE PATTERN REGARDING ENGINE, VEHICLE PRODUCTION OPTIONS, BUILD RANGE OR FAILURE TREND. THIS INVESTIGATION IS CLOSED WITH CHRYSLER'S RECALL.
PE07009 · Engine Stall
Opened Feb 12, 2007 · Closed Apr 27, 2007
Status: closed (inferred from source dates) · Electrical System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Additional source detail variants (2)
Electrical System
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI HAS RECEIVED 76 VEHICLE OWNER COMPLAINTS ALLEGING INCIDENTS OF ENGINE STALL WHILE DRIVING IN MODEL YEAR (MY) 2006 THROUGH 2007 JEEP COMMANDER VEHICLES (SUBJECT VEHICLES).SOME OF THE COMPLAINTS REPORTED ONE OR MORE INCIDENTS OF ENGINE STALL WITH A SIMULTANEOUS LOSS OF SOME OR ALL LIGHTING SYSTEMS, INCLUDING HEADLAMPS.TWO ENGINE STALLS RESULTED IN A VEHICLE CRASH.IN ITS RESPONSE TO A REQUEST FOR INFORMATION, DAIMLERCHRYSLER CORPORATION (DCC) INDICATED THAT IT HAS NOT DETERMINED THE CAUSE OF ENGINE STALLING IN THE SUBJECT VEHICLES AND THAT IT HASFORMED A MULTI-DISCIPLINARY TASK FORCE TO INVESTIGATE THE ISSUE. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA07-007) TO FURTHER ASSESS THE FREQUENCY, SCOPE AND POTENTIAL SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
DP06002 · Petition Re: Unintended Acceleration
Opened Jul 13, 2006 · Closed Jan 3, 2007
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine; Fuel System, Other:fuel Injection System; Power Train:automatic Transmission:control Module (tcm/pcm/tecm); Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Additional source detail variants (4)
Engine And Engine Cooling:engine
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Fuel System, Other:fuel Injection System
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Vehicle Speed Control
ODI RECEIVED A PETITION REQUESTING A DEFECT INVESTIGATION CONCERNING UNINTENDED ACCELERATION IN THE 2006 JEEP COMMANDER STEMMING FROM A FATAL INCIDENT THAT OCCURRED IN DELAWARE IN DECEMBER 2005.AFTER A CAREFUL REVIEW OF THE CIRCUMSTANCES SURROUNDING THIS INCIDENT, ODI FINDS NO EVIDENCE TO INDICATE THE INFLUENCE OF A MANUFACTURING DEFECT.LIKEWISE, NO SIMILAR COMPLAINTS CONCERNING THIS MODEL EXIST IN THE ODI COMPLAINT DATABASE.ACCORDINGLY, THE PETITION IS DENIED.ODI RESERVES THE RIGHT TO REVISIT THIS ISSUE IN THE FUTURE SHOULD CIRCUMSTANCES WARRANT.
Illustration