← New search

2018 Jeep Cherokee

Owner reports · Recalls · Investigations

More warning signs than most Cherokee years

Owner complaints for the 2018 Jeep Cherokee are substantially higher than the model-year median of 113.

About this comparison →

When problems were reported

Mileage at the reported incident

359 reports with mileage · 324 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 292 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 190 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 155 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports5 fire reports3 injury reports

What owners actually said

683 reports
12,200 miles · Oct 20, 2019
Electrical SystemSteeringUnknown Or Other

WE PURCHASED A USED 2018 JEEP CHEROKEE LATITUDE (LESS THAN 13,000 MILES) FROM A DEALERSHIP IN COLORADO SPRINGS ON 10/17. ON THE WAY HOME, ABOUT 100 MILES, THE STOP /START WARNING LIGHT AND BATTERY LIGHT WENT ON ABOUT 8 MILES FROM HOME GOING APPROX. 50 MPH. WE DECIDED TO GET IT HOME. AT THE BOTTOM OF THE DRIVEWAY, WE PLACED THE …

Read full complaint

WE PURCHASED A USED 2018 JEEP CHEROKEE LATITUDE (LESS THAN 13,000 MILES) FROM A DEALERSHIP IN COLORADO SPRINGS ON 10/17. ON THE WAY HOME, ABOUT 100 MILES, THE STOP /START WARNING LIGHT AND BATTERY LIGHT WENT ON ABOUT 8 MILES FROM HOME GOING APPROX. 50 MPH. WE DECIDED TO GET IT HOME. AT THE BOTTOM OF THE DRIVEWAY, WE PLACED THE CAR IN REVERSE AND NOTICED THAT POWER STEERING WAS NOT WORKING. WE TURNED OFF THE VEHICLE AND AT RESTART, THE WARNING LIGHTS WERE RESET. WE NOTIFIED THE DEALERSHIP IMMEDIATELY AND THEY RECOMMENDED CHANGING OUT BATTERY. WE DROVE ABOUT 15 MILES TO AN AUTO PARTS STORE AND BOUGHT THE BEST BATTERY THEY HAD FOR THAT VEHICLE. WE DID NOT USE THE JEEP FOR THE NEXT DAY (FRIDAY). SATURDAY 10/19 WE DROVE IT DOWN TO DENVER (ABOUT 60 MILES) WITH NO PROBLEM. ON THE WAY HOME, AGAIN THE STOP /START WARNING LIGHT AND BATTERY LIGHT WENT ON GOING APPROX. 60 MPH. WE DROVE TO A PARKING LOT AND MADE A TURN INTO A PARKING SPOT. AT THAT POINT POWER STEERING WAS OPERABLE. I PLACED THE CAR IN PARK AND THEN IN REVERSE AND THEN NOTICED NO POWER STEERING, I PLACED THE CAR IN DRIVE AND AGAIN NO POWER STEERING. WE STOPPED AND RESTARTED THE VEHICLE AND THE WARNING LIGHTS WERE RESET. ABOUT 2 MINUTES LATER WHILE DRIVING, I NOTICED THAT THE DRIVER'S SIDE SEAT WARMER AND REAR DEFROST HAD BOTH BEEN SWITCHED ON AUTOMATICALLY.

NHTSA ODI #11269737

30,000 miles · Oct 19, 2019
Electrical SystemEnginePower Train

SERVICE SHIFTER LIGHT ALWAYS ON IN MOTION AND IN PARK. BURNS 1 QT OF OIL EVERY 2000 MILES VEHICLES JERKS WHEN TRYING TO ACCELERATE IN MOTION

NHTSA ODI #11269508

40,029 miles · Oct 17, 2019
Electrical SystemElectronic Stability Control (esc)Unknown Or Other

WHILE DRIVING MY 2018 JEEP CHEROKEE A MESSAGE APPEARED ON THE DASH 'SERVICE SHIFTER' ALL LIGHTS ON THE SHIFTER THEN LIGHT UP RED THE 'PRNDL' THIS HAS HAPPENED MULTIPLE TIMES. THE VEHICLE SEEMS TO NOT SHIFT GEARS PROPERLY WHEN THIS HAPPENS. IT HAS BEEN CHECKED BY THE DEALER AND THE SHIFTER/ WIRING HARNESS NEED TO BE REPLACED. I W…

Read full complaint

WHILE DRIVING MY 2018 JEEP CHEROKEE A MESSAGE APPEARED ON THE DASH 'SERVICE SHIFTER' ALL LIGHTS ON THE SHIFTER THEN LIGHT UP RED THE 'PRNDL' THIS HAS HAPPENED MULTIPLE TIMES. THE VEHICLE SEEMS TO NOT SHIFT GEARS PROPERLY WHEN THIS HAPPENS. IT HAS BEEN CHECKED BY THE DEALER AND THE SHIFTER/ WIRING HARNESS NEED TO BE REPLACED. I WAS INFORMED THIS IS AN ONGOING ISSUE WITH MOST JEEPS IN THE LAST FEW YEARS AND NO RECALL HAS YET BEEN MADE, I HAVE ONLY OWNED THIS VEHICLE FOR 7 MONTHS AND AM VERY DISAPPOINTED THUS FAR. THIS BEING AN ONGOING ISSUE THAT JEEP IS AWARE OF I FEEL THAT SOME ACTION SHOULD BE MADE FOR THE CUSTOMER. I AM A LOYAL JEEP CUSTOMER BUT AFTER THIS ISSUE NOT BEING RESOLVED FOR YEARS I MAY NOT CONTINUE TO BE A LOYAL CUSTOMER AND GO ELSEWHERE TO PURCHASE MY NEXT VEHICLE. THIS FIRST OCCURRED ON SEPTEMBER 25,2019 AND HAS HAPPENED MULTIPLE TIMES SINCE THE FIRST OCCURRENCE.

NHTSA ODI #11269119

21,630 miles · Oct 15, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

STARTING ISSUES BATTERY WILL NOT STAY CHARGED NO HELP FROM DEALERSHIP .OR ROADSIDE ASSISTANCE

NHTSA ODI #11268429

40,000 miles · Oct 14, 2019
Power Train

AFTER LESS THAN 1 YEAR OLD GETTING A SERVICE SHIFTER MESSAGE ON START UP. IT WOULD GO AWAY WHEN I TURNED ENGINE OFF AND ON BUT NOTE WON'T DO AWAY. CARE LESS THAN A YEAR OLD BUT JUST OUT OF WENT DUE TO MILAGE.

NHTSA ODI #11268372

13,300 miles · Oct 13, 2019
Unknown Or Other

I HAVE A LITTLE OVER 13300 MILES ON MY JEEP AS I WENT TO PARK MY CAR I NOTICED THE SERVICE SHIFTER LIGHT WAS ON AS WELL AS PARK, REVERSE, NEUTRAL, AND DRIVE WERE ALL LIT UP ON THE SHIFTER WHEN I LOOKED THIS UP ON GOOGLE THERE WHERE A NUMBER OF COMPLAINS MY JEEP IS STILL BRAND NEW I SHOULD NOT BE HAVING THIS PROBLEM! I DID NOT TU…

Read full complaint

I HAVE A LITTLE OVER 13300 MILES ON MY JEEP AS I WENT TO PARK MY CAR I NOTICED THE SERVICE SHIFTER LIGHT WAS ON AS WELL AS PARK, REVERSE, NEUTRAL, AND DRIVE WERE ALL LIT UP ON THE SHIFTER WHEN I LOOKED THIS UP ON GOOGLE THERE WHERE A NUMBER OF COMPLAINS MY JEEP IS STILL BRAND NEW I SHOULD NOT BE HAVING THIS PROBLEM! I DID NOT TURN IT BACK ON TO SEE IF IT WENT AWAY I PLAN ON TAKING IT TO A DEALERSHIP FIRST THING IN THE MORNING. I ALSO BOUGHT IT WHEN IT ONLY HAD 5 MILES ON IT NO REASON AT ALL FOR THIS TO HAPPEN THEREFORE SHOULD BE A RECALL!

NHTSA ODI #11268230

18,000 miles · Oct 12, 2019
Air BagsCrash

MY VEHICLE WAS HIT WITH DIRECT IMPACT ON FRONT OF VEHICLE AND DRIVERS SIDE AND NO AIRBAGS DEPLOYED. BOTH VEHICLES INVOLVED WHERE IN MOTION

NHTSA ODI #11268077

Mileage unknown · Oct 10, 2019
Power Train

TL* THE CONTACT OWNS A 2018 JEEP CHEROKEE. WHILE DRIVING VARIOUS SPEEDS, THE SERVICE SHIFTER WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE GEAR SELECTORS ILLUMINATED RED. THE VEHICLE WAS TAKEN TO GOSSETT CHRYSLER DODGE JEEP RAM (1901 COVINGTON PIKE, MEMPHIS, TN 38128, (901) 388-8989) WHERE THE BEZEL WAS REPL…

Read full complaint

TL* THE CONTACT OWNS A 2018 JEEP CHEROKEE. WHILE DRIVING VARIOUS SPEEDS, THE SERVICE SHIFTER WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE GEAR SELECTORS ILLUMINATED RED. THE VEHICLE WAS TAKEN TO GOSSETT CHRYSLER DODGE JEEP RAM (1901 COVINGTON PIKE, MEMPHIS, TN 38128, (901) 388-8989) WHERE THE BEZEL WAS REPLACED, BUT THE FAILURE OCCURRED TWICE AFTER THE REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND SCHEDULED AN APPOINTMENT WITH THE DEALER. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI #11267762

10,000 miles · Oct 9, 2019
EnginePower TrainSeat Belts

STARTING AT 25K MILES, THE VEHICLE STARTED TO BURN THROUGH OIL EVEN BEFORE THE NEXT OIL CHANGE. THE MANUAL STATES TO GO OFF THE OIL SYSTEM LIGHT, DEALERS SAY DIFFERENT. OIL HAD 14% LEFT, BUT THE CAR KEPT SHUTTING OFF WHILE DRIVING ON THE HIGHWAY. WENT TO DEALER, CAR BURNED THROUGH ALL THE OIL. THEY REFUSED TO CHECK FOR ENGINE DA…

Read full complaint

STARTING AT 25K MILES, THE VEHICLE STARTED TO BURN THROUGH OIL EVEN BEFORE THE NEXT OIL CHANGE. THE MANUAL STATES TO GO OFF THE OIL SYSTEM LIGHT, DEALERS SAY DIFFERENT. OIL HAD 14% LEFT, BUT THE CAR KEPT SHUTTING OFF WHILE DRIVING ON THE HIGHWAY. WENT TO DEALER, CAR BURNED THROUGH ALL THE OIL. THEY REFUSED TO CHECK FOR ENGINE DAMAGE AND FORCE ME TO PAY FOR A FULL OIL CHANGE. STATED BY THE DEALER, ITS A KNOWN ISSUE WITH JEEP AND THERE IS NO FIX FOR IT. NOW AT 33K, CHECK ENGINE LIGHT CAME ON, CYLINDER 4 MISFIRE. COIL PACK NEEDS REPLACED. THIS IS A TSB THAT WAS POSTED AT DEALERS BUT NOT GIVEN TO CONSUMERS. ALSO AIRBAG CONNECTION UNDER DRIVER SEAT COMES LOOSE AND CAUSES WARNING LIGHTS TO SERVICE AIRBAG. 10K MILES. DEALER SAID TO PLUG BACK IN AND JUST KEEP DEALING WITH IT.

NHTSA ODI #11267328

46,000 miles · Oct 6, 2019
Electrical System

THE SERVICE SHIFTER LIGHT HAS GONE OFF TURNING ON ALL LIGHTS ON THE GEAR RED. EVER SINCE IT CAME UP IT WILL KEEP COMING UP.

NHTSA ODI #11266635

Official recalls

7

25V011000 · Power Train

Apr 29, 2025

Chrysler (FCA US, LLC) is recalling certain 2017-2019 Jeep Cherokee vehicles. The power transfer unit (PTU) may become damaged and disengage the transmission and differential, resulting in a loss of drive power and/or loss of park function.

Consequence & remedy

Consequence: A loss of drive power can increase the risk of a crash. A loss of park function can cause an unintended vehicle rollaway, which can increase the risk of a crash or injury.

Remedy: Dealers will update the drivetrain control module and PTU software and replace the PTU, as necessary free of charge. Owner notification letters were mailed beginning February 19, 2026. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 01C.

18V524000 · Electrical System:wiring:front Underhood

Aug 9, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.

Consequence & remedy

Consequence: A vehicle stall can increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.

18V494000 · Power Train:axle Assembly:axle Shaft

Jul 26, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Cherokee all-wheel-drive vehicles. The bearing cage for the right front halfshaft assembly may not have been properly heat treated, possibly resulting in the bearing cage breaking and a potential halfshaft assembly failure.

Consequence & remedy

Consequence: If the halfshaft bearing cage breaks, the halfshaft may not be able to transmit engine power, causing a loss of drive or it can allow the vehicle to move while in the "Park" position. Either condition may increase the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the front right halfshaft assemblies, free of charge. The recall began September 20, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U78.

18V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control

May 17, 2018

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence & remedy

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Additional source detail variants (3)

Electrical System:software

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Vehicle Speed Control:cruise Control

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Electrical System:wiring

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

18V282000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

May 1, 2018

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Cherokee vehicles equipped with a 2.4L engine. These vehicles may have been manufactured with a fuel tube that may leak fuel into the engine compartment.

Consequence & remedy

Consequence: A fuel leak in the presence of the ignition source can increase the risk of a fire.

Remedy: Chrysler will notify owners, and dealers will inspect the fuel tube, replacing it as necessary, free of charge. The recall began May 24, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U39.

17V670000 · Engine And Engine Cooling:engine

Oct 24, 2017

Chrysler (FCA US LLC) is recalling certain 2018 Jeep Cherokee and Compass vehicles equipped with 2.4L engines. The engines may have a cracked oil pump housing that can result in oil pump failure.

Consequence & remedy

Consequence: If the oil pump fails, the engine will stall, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the oil pump, replacing it as necessary, free of charge. The recall began December 5, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T65.

17V543000 · Equipment:other:labels; Wheels:rim

Aug 31, 2017

Chrysler (FCA US LLC) is recalling certain 2017-2018 Jeep Cherokee vehicles. The tire and rim size information required to be on the Certification label was omitted during manufacturing, which may result in an incorrect tire and rim combination being installed on the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence & remedy

Consequence: The missing tire and rim designation information may lead to an incorrect combination being installed on the vehicle, increasing the risk of a crash.

Remedy: Chrysler will notify owners and will provide a corrected certification label, free of charge. The recall began October 13, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T53.

Additional source detail variants (2)

Equipment:other:labels

Chrysler (FCA US LLC) is recalling certain 2017-2018 Jeep Cherokee vehicles. The tire and rim size information required to be on the Certification label was omitted during manufacturing, which may result in an incorrect tire and rim combination being installed on the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence: The missing tire and rim designation information may lead to an incorrect combination being installed on the vehicle, increasing the risk of a crash.

Remedy: Chrysler will notify owners and will provide a corrected certification label, free of charge. The recall began October 13, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T53.

Wheels:rim

Chrysler (FCA US LLC) is recalling certain 2017-2018 Jeep Cherokee vehicles. The tire and rim size information required to be on the Certification label was omitted during manufacturing, which may result in an incorrect tire and rim combination being installed on the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence: The missing tire and rim designation information may lead to an incorrect combination being installed on the vehicle, increasing the risk of a crash.

Remedy: Chrysler will notify owners and will provide a corrected certification label, free of charge. The recall began October 13, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T53.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.