NHTSA owner reports · September 18, 2026 snapshot.
Suspension complaints
38 reportsClear category filter6,000 miles · Jan 14, 2016
Suspension
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING 55 MPH, THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE CV AXLES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO PART UNAVAILABILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILE…
Read full complaint
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING 55 MPH, THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER SIDE CV AXLES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO PART UNAVAILABILITY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 6,000.
NHTSA ODI #10820162
300 miles · Oct 6, 2015
Power TrainSuspension
WHEN SLOWING DOWN IN TRAFFIC OR STARTING A STEP GRADE THE TRANSMISSION BOGGS DOWN AND THEN SLAMS INTO A LOWER GEAR CAUSING A SUDDEN AND INSTANT SPEED AS IF YOU WERE TRYING TO DRAG RACE FROM A STOP SIGN. OFTEN CAUSING LOSS OF TRACTION AND FORCING THE WHEELS TO SPIN OUT. I HAVE HAD NUMEROUS TIMES WHERE I ALMOST REAR ENDED THE VEHI…
Read full complaint
WHEN SLOWING DOWN IN TRAFFIC OR STARTING A STEP GRADE THE TRANSMISSION BOGGS DOWN AND THEN SLAMS INTO A LOWER GEAR CAUSING A SUDDEN AND INSTANT SPEED AS IF YOU WERE TRYING TO DRAG RACE FROM A STOP SIGN. OFTEN CAUSING LOSS OF TRACTION AND FORCING THE WHEELS TO SPIN OUT. I HAVE HAD NUMEROUS TIMES WHERE I ALMOST REAR ENDED THE VEHICLE IN FRONT OF ME AT 4 WAY STOPS OR IN CONSTRUCTION ZONES. THE AXEL ALSO WOBBLE UPON STARTING OUT, MAINLY IN 2ND GEAR. ONE TIME WHILE ON A DIRT ROAD THE FORCE OF THE ECELLERATION PUT ME OFF THE ROAD. AFTER MY 4TH ATTEMPT TO HAVE A REPAIR DONE, THEY EXCHANGED THE INNER PORTION OF THE TRANSMISSION, THE VEHICLE NOW PERFORMS THIS ACTION ALMOST EVERY TIME I COME TO A STOP OR SLOW DOWN TO 5 TO 7 MPH AND THEN APPLY THE GAS AGAIN. NO GRADUALLY ECELLERATION AVAILABLE IN THIS VEHICLE. I WON'T ALLOW MY WIFE TO DRIVE DUE TO THE EXTREME SAFETY HAZARD HAVING TO GIVE MIN. OF 3 CAR LENGTHS SO AS TO NOT ENDANGER OTHERS ON THE ROAD. THE VEHICLE HAS BEEN IN THE SHOP 5 TIMES IN 5 MONTHS FOR THIS ISSUE AND STILL NOT CORRECTED. BOTH AXEL HAVE BEEN REPLACED ON THE FRONT OF THE JEEP AND NUMEROUS COMPUTER UPGRADES. MY SERVICE MANAGER STATED TO ME HE HAD 4 OTHERS IN HIS SHOP IN ONE DAY WAITING FOR A FIX AND ANOTHER DEALER IN TEXAS HAS 35. MY BEST FRIEND WORKS AS A SALESMAN FOR THE LOCAL DEALER AND SAID THEY ARE TOWED IN FOR THIS PROBLEM MULTIPLE TIMES A WEEK. WHEN ASKING HIS MANAGER WHAT TO SAY TO NEW BUYERS HE WAS TOLD THAT'S WHAT A WARRANTY IS FOR. MY JEEP WAS TAKEN INTO THE SERVICE DEPARTMENT FOR COMPUTER UPGRADE FOR THE TRANSMISSION BEFORE I EVEN BOUGHT IT.
NHTSA ODI #10780427
700 miles · Sep 15, 2015
Power TrainSuspensionVehicle Speed Control
PURCHASED CAR 5/13/15. ON 5/30 NOTICED SHIMMY/VIBRATION AS I ACCELERATED FROM A STOPPED POSITION INTO A SHARP RIGHT TURN. APPT MADE FOR SERVICE 6/8. AT CHECK-IN, CUSTOMER SERVC KNEW EXACTLY WHAT I WAS TALKING ABOUT; CONFIRMED IN TEST DRIVE. REPORTED STAR CASE #S1421000022, HALF-SHAFTS (LEFT & RIGHT AXLES) DEFECTIVE, NEED REPLACI…
Read full complaint
PURCHASED CAR 5/13/15. ON 5/30 NOTICED SHIMMY/VIBRATION AS I ACCELERATED FROM A STOPPED POSITION INTO A SHARP RIGHT TURN. APPT MADE FOR SERVICE 6/8. AT CHECK-IN, CUSTOMER SERVC KNEW EXACTLY WHAT I WAS TALKING ABOUT; CONFIRMED IN TEST DRIVE. REPORTED STAR CASE #S1421000022, HALF-SHAFTS (LEFT & RIGHT AXLES) DEFECTIVE, NEED REPLACING. TOLD CAR WAS COMPLETELY SAFE TO DRIVE IN THIS CONDITION. VERBAL & WRITTEN CONFIRM THAT PARTS WERE BEING MANUFACTURED AND WERE SCHEDULED FOR RELEASE 9-2015. TOLD BY SERVICE MGR, CHRYSLER ISSUED AN INTERNAL TSB 2-2015. PARTS WARPING WHEN HEATED AND FLUID LOSS OCCURS. ENTIRE ASSEMBLY NEEDS TO BE REPLACED BUT PARTS HAVEN'T BEEN MANUFACTURED, CONTRACTED WITH COMPANY THAT MANUFACTURES THE TRAILHAWK MODEL (NO PROBLEMS REPORTED ON THOSE PARTS). ASSURED CAR WAS SAFE TO DRIVE BUT CHRYSLER REP AGREED TO PAY FOR RENTAL CAR FOR LONG TRIP I HAD PLANNED PRIOR TO PURCHASE. RESEARCHED -- I HAVE FOUND THIS ISSUE DATES BACK TO THE 2014 MODELS. BOTTOM LINE, THEY KNEW THIS PART WAS DEFECTIVE PRIOR TO SELLING ME THE CAR IN MAY. I AGREED TO BE PATIENT BUT IT IS NOW SEPT AND HAVE NOT HAD MY "STATUS UPDATE" INQUIRY PHONE CALL RETURNED. VIBRATION ISSUE GREW WORSE QUICKLY, TURNED INTO A WOBBLE. I CAN'T DRIVE IT FOR EXTENDED PERIODS ON HIGHWAYS. AS THE CAR/PARTS HEAT UP, THE WOBBLE IN THE FRONT END IS A CONSTANT, NOT JUST ON TURNS. I FEEL AS IF THE AXLES WILL BREAK APART WHILE DRIVING. I DO NOT HAVE ANOTHER CAR THAT I CAN USE. THERE IS NO EXCUSE FOR SELLING CARS WITH A KNOWN DEFECT AND FORCING A BUYER TO PLACE THEIR LIFE IN JEOPARDY. OTHER ISSUES HAVE CROPPED UP. ENGINE RACES & DOESN'T ALWAYS SHIFT WHEN IT SHOULD; CRUISE CONTROL NOT CONSISTENT - LOSES SPEED. WHEN RETURNED TO SERVICE, TOLD THEY COULDN'T FIND A PROBLEM W/ CRUISE CONTROL, TOLD TRANSMISSION FUNCTIONING CORRECTLY, COMPUTER IS "LEARNING" HOW I DRIVE. BRAKES SQUEAK AFTER RAIN, TOLD NORMAL BY SVC MGR.
NHTSA ODI #10763794
5,700 miles · Aug 27, 2015
SteeringSuspensionVehicle Speed ControlCrash
I WAS DRIVING TO WORK ON A THURSDAY MORNING, THE SAME ROUTE I ALWAYS TAKE, I AM VERY FIMILAIR WITH THE RAOD AND TRAFFIC IN THIS AREA BECAUSE I HAVE BEEN DRIVING IT FOR THE LAST SEVEN YEARS STRAIGHT. WELL ON MY WAY, I GOT INTO A ACCIDENT, MY NEW JEEP HAS BEEN INTO THE SHOP A FEW TIMES FOR A RECALL, I HAVE ONLY HAD THE JEEP FOR 7 …
Read full complaint
I WAS DRIVING TO WORK ON A THURSDAY MORNING, THE SAME ROUTE I ALWAYS TAKE, I AM VERY FIMILAIR WITH THE RAOD AND TRAFFIC IN THIS AREA BECAUSE I HAVE BEEN DRIVING IT FOR THE LAST SEVEN YEARS STRAIGHT. WELL ON MY WAY, I GOT INTO A ACCIDENT, MY NEW JEEP HAS BEEN INTO THE SHOP A FEW TIMES FOR A RECALL, I HAVE ONLY HAD THE JEEP FOR 7 MONTHS AND HAVE HAD TO BRING IT IN 2 TIMES AND NOW A 3RD FOR AN AIRBAG DEPLOYMENT ISSUE. ANYWAY, I WAS DRIVING TO WORK AND MY JEEP DOES THIS THING WHERE IT FEELS LIKE IT SHUTS OFF WHEN I AM STOPPED AND TURNS BACK ON WHEN I BEGIN TO MOVE, I NOTICED IT WHEN I FIRST PURCHASED THE JEEP WHEN I BROUGHT IT IN TO THE DEALER, THEY TOLD ME IT IS SUPPOSE TO DO THAT BECAUSE OF THE FOUR WHEEL DRIVE, I SAID OK FINE I JUST WANTED TO MAKE SURE I WAS SAFE BECAUSE THAT IS ONE OF THE REASONS I PURCHASED THIS CAR. WELL ON THE WAY TO WORK, MY JEEP DID JUST THAT BUT LATELY IT IS DOING A JERKING MOVE WHEN IT STARTS TO ACCELARTE NOW, MAKING IT FEEL LIKE MY CAR IS JERKING AND ACCERATING ON ITS OWN WHICH RESULTED IN MY HITTING THE CAR IN FRONT OF ME. NOW THE JEEP WAS NOT GOING AT A FAST SPEED AT ALL, I AM VERY FAMILAIR WITH THE LOCATION SO I PAY ATTENTION TO DETAIL HERE. I FELT MY JEEP DO THE JERK MOVEMENT AND WITH MY ACCERATION I AM CERTAIN THIS IS WHAT CAUSED ME TO HIT THE CAR IN FRONT OF ME, I THINK THERE IS SOMETHING SERIOUSLY WRONG HERE AND THIS NEEDS TO BE ADDRESSED.
NHTSA ODI #10759816
200 miles · Aug 13, 2015
Suspension
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STARTED TO VIBRATE. THE CONTACT STATED THAT THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER; HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE …
Read full complaint
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE STARTED TO VIBRATE. THE CONTACT STATED THAT THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER; HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 200.
NHTSA ODI #10748336
100 miles · Jul 30, 2015
Suspension
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE SHOOK WHILE ACCELERATING AT LOW SPEEDS. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER ALIGNED THE TIRES; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE DEALER ALS…
Read full complaint
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE SHOOK WHILE ACCELERATING AT LOW SPEEDS. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER ALIGNED THE TIRES; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE DEALER ALSO TEST DROVE THE VEHICLE AND WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 100. MA 10/2 *CN
NHTSA ODI #10745058
5,000 miles · Jul 9, 2015
Suspension
DRIVING OVER ROUGH ROAD, NOTICED EXCESSIVE NOISE AND BANGING ( LIKE SOMETHING LOOSE) FROM RIGHT FRONT. TOOK IN TO DEALER, THEY SAID THE NOISE WAS NORMAL SUSPENSION NOISE! AFTER INSISTING THEY TEST DRIVE AGAIN AND PUT ON RACK TO VISUALLY INSPECT, THE DEALER CLAIMED NOTHING WRONG. I CONTACTED MANAGER AND EXPRESSED MY DISSATISFACTI…
Read full complaint
DRIVING OVER ROUGH ROAD, NOTICED EXCESSIVE NOISE AND BANGING ( LIKE SOMETHING LOOSE) FROM RIGHT FRONT. TOOK IN TO DEALER, THEY SAID THE NOISE WAS NORMAL SUSPENSION NOISE! AFTER INSISTING THEY TEST DRIVE AGAIN AND PUT ON RACK TO VISUALLY INSPECT, THE DEALER CLAIMED NOTHING WRONG. I CONTACTED MANAGER AND EXPRESSED MY DISSATISFACTION WITH THE SERVICE AND KNEW SOMETHING WAS WRONG. AFTER HAVING HIM GO ON A TEST DRIVE WITH ME, HE AGREED THEIR WAS A PROBLEM AND NOISE FROM FRONT STRUTS. ONLY THEN, WOULD THEY AGREE TO ORDER AND REPLACE THE RIGHT FRONT SHOCK. I'VE HAD NUMEROUS ATTEMPTS TO FIX OTHER ITEMS ON THIS VEHICLE, INCLUDING ASKING FOR ANY RECALL INFO TO BE CHECKED, AND THE DEALER SAID "IF YOU DIDN'T GET A CARD IN THE MAIL, THERE'S NO RECALLS". NOW I SEE THERE'S A RECALL ON THE POWER REAR LIFT GATE THAT I'VE HAD THERE WITH PROBLEMS OPENING, THEY HAVE NOT CONTACTED ME YET, ACCORDING TO RECALL R27, AND HAVE NOT FOUND ANY PROBLEMS WITH IT!
NHTSA ODI #10732856
800 miles · May 8, 2015
StructureSuspensionWheelsCrashInjury
A CAR TURNED LEFT AS I WAS GOING STRAIGHT AND STRUCK ME AT THE FRONT LEFT SIDE OF THE VEHICLE. THE IMPACT BROKE MY TIRED COMPLETELY OFF THE VEHICLE SMASHING BOTH THE FRONT AND THE ENTIRE SIDE OF MY CAR WITH ENOUGH DAMAGE FOR ME TO HAVE TO KICK MY DOOR MULTIPLE TIMES IN ORDER TO EXIT THE CAR. AFTER THE FIRST IMPACT I LOST CONTROL…
Read full complaint
A CAR TURNED LEFT AS I WAS GOING STRAIGHT AND STRUCK ME AT THE FRONT LEFT SIDE OF THE VEHICLE. THE IMPACT BROKE MY TIRED COMPLETELY OFF THE VEHICLE SMASHING BOTH THE FRONT AND THE ENTIRE SIDE OF MY CAR WITH ENOUGH DAMAGE FOR ME TO HAVE TO KICK MY DOOR MULTIPLE TIMES IN ORDER TO EXIT THE CAR. AFTER THE FIRST IMPACT I LOST CONTROL SINCE A TIRE WAS MISSING AND THE VEHICLE HIT A SEMI TRUCK HEAD ON. NO AIR BAGS DEPLOYED. CAR IS TOTALED AND HAS FRAME DAMAGE. I CONTACTED JEEP AND THEY HAVE SINCE DONE AN INVESTIGATION AND TOLD ME I WAS NOT GOING FAST ENOUGH FOR AIR BAGS TO DEPLOY AND ARE NOW NOT RETURNING MY CALLS. WHEN THE INVESTIGATOR CALLED ME AFTER HE INSPECTED THE VEHICLE HE WAS SHOCKED THAT I SAID THE CAR WAS TOTALED. THE CAR WAS BRAND NEW I HAD IT FOR 15 DAYS. THERE WAS A RECALL PERFORMED ON THE AIR BAGS THE DAY BEFORE AND WHEN REVIEWING THE RECEIPT SHOWED THAT THEY WORKED ON THE CAR FOR LESS THAN 15 MINS BUT HAD MY CAR FOR 6 HOURS? STATING THE RECALL WAS PREVIOUSLY PERFORMED EVEN THOUGH WHEN I BROUGHT MY CAR IN TO HAVE A SECURITY SYSTEM INSTALLED FEW DAYS PRIOR THEY SAID THE RECALL NEEDED TO BE PERFORMED AND I SET THE APPOINTMENT UP. THERE IS NO WAY I WAS NOT GOING FAST ENOUGH TO HAVE MY SAFETY FEATURES WORK IN MY BRAND NEW VEHICLE BUT I WAS GOING FAST ENOUGH FOR MY AXLE TO SNAP AND MY TIRE TO BECOME DISCONNECTED FROM THE VEHICLE. JEEP WILL NOT RETURN MY CALLS SO I MUST TAKE FURTHER ACTION. PLEASE ASSIST ME AND TAKE THIS SERIOUSLY NO ONE SHOULD FEEL UNSAFE IN THEIR VEHICLES.
NHTSA ODI #10715268
Official recalls
11May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Dec 9, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence & remedy
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Oct 19, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015 Jeep Cherokee vehicles manufactured October 1, 2014, to June 18, 2015. The affected vehicles may have a misrouted air conditioning suction/discharge hose.
Consequence & remedy
Consequence: If the line is misrouted, it may contact the exhaust manifold, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will inspect the routing of the air conditioning hose. Any hose that is misrouted will be replaced and installed correctly. This work will be performed free of charge. The recall began on November 23, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R57.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
PE15003 · Engine Compartment Fire
Opened Jan 13, 2015 · Closed Dec 9, 2015
Status: closed (inferred from source dates) · Engine; Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Additional source detail variants (2)
Engine
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Illustration