NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
127 reportsClear category filter64,217 miles · Jan 12, 2020
Electronic Stability Control (esc)Service Brakes
I WAS APPROACHING A 4 WAY STOP WITH MY CHILDREN IN THE VEHICLE, GOING APPROX. 10MPH. I PRESSED ON THE BRAKES BUT WAS UNABLE TO STOP, MAKING ME GO THROUGH THE INTERSECTION WITH VEHICLES TURNING INTO MY LANE. THE BRAKE PEDAL WAS ROCK SOLID AND LOCKED UP, AND WAS UNABLE TO BE PRESSED. DURING THAT TIME THE SERVICE ELCTRONIC BRAKING …
Read full complaint
I WAS APPROACHING A 4 WAY STOP WITH MY CHILDREN IN THE VEHICLE, GOING APPROX. 10MPH. I PRESSED ON THE BRAKES BUT WAS UNABLE TO STOP, MAKING ME GO THROUGH THE INTERSECTION WITH VEHICLES TURNING INTO MY LANE. THE BRAKE PEDAL WAS ROCK SOLID AND LOCKED UP, AND WAS UNABLE TO BE PRESSED. DURING THAT TIME THE SERVICE ELCTRONIC BRAKING LIGHT POPULATED ON MY DASHBOARD.
NHTSA ODI #11298647
88,500 miles · Dec 12, 2019
Service Brakes
2015 JEEP CHEROKEE TRAILHAWK. WAS PARKED WHEN SERVICE BRAKE LIGHT CAME ON AND WOULDN'T ALLOW VEHICLE TO DRIVE. COULD NOT DISENGAGE THE PARKING BRAKE FOR ALMOST 2 HOURS. DID THIS SEVERAL TIMES WITHIN 2 DAYS. SET UP SERVICE AT DEALERSHIP AND THEY SAID WATER WAS GETTING INTO THE PARKING BRAKE MODULAR AND CORRODING IT IN THE WIRING …
Read full complaint
2015 JEEP CHEROKEE TRAILHAWK. WAS PARKED WHEN SERVICE BRAKE LIGHT CAME ON AND WOULDN'T ALLOW VEHICLE TO DRIVE. COULD NOT DISENGAGE THE PARKING BRAKE FOR ALMOST 2 HOURS. DID THIS SEVERAL TIMES WITHIN 2 DAYS. SET UP SERVICE AT DEALERSHIP AND THEY SAID WATER WAS GETTING INTO THE PARKING BRAKE MODULAR AND CORRODING IT IN THE WIRING HARNESS THE PARKING BRAKE MODULAR AND CORRODING IT AND THE WIRING HARNESS.
NHTSA ODI #11288789
59,000 miles · Dec 9, 2019
EngineService BrakesVisibility/wiper
CAR WILL TURN OFF. TURN THE KEY AND PULL IT OUT, CAR STAYS RUNNING. WHEN THIS HAPPENS, CAR IS IN A POSSESSED STATE WHERE BRAKE LIGHTS STAY ON AT ALL TIMES, TURN SIGNALS DO NOT WORK, WIPERS DO NOT WORK, HORN DOES NOT WORK. TOOK IT TO DEALERSHIP AND WAS TOLD THERE ARE NO CODES, SO NOTHING THEY CAN DO. PULL THE BATTERY CABLE OFF…
Read full complaint
CAR WILL TURN OFF. TURN THE KEY AND PULL IT OUT, CAR STAYS RUNNING. WHEN THIS HAPPENS, CAR IS IN A POSSESSED STATE WHERE BRAKE LIGHTS STAY ON AT ALL TIMES, TURN SIGNALS DO NOT WORK, WIPERS DO NOT WORK, HORN DOES NOT WORK. TOOK IT TO DEALERSHIP AND WAS TOLD THERE ARE NO CODES, SO NOTHING THEY CAN DO. PULL THE BATTERY CABLE OFF TO SHUT THE CAR DOWN. THIS WILL HAPPEN MID DRIVE SO ALL OF A SUDDEN YOU'LL LOSE YOUR TURN SIGNALS, WIPERS, HORN, BRAKE LIGHTS, DOOR LOCKS, AND MAIN LIGHT CONTROL. WHEN YOU PULL OVER, ONLY WAY TO TURN THE CAR OFF IS TO PULL THE BATTERY CABLE.
NHTSA ODI #11287881
Mileage unknown · Dec 5, 2019
Electronic Stability Control (esc)EngineService Brakes
I WAS LEAVING MY CONDOMINIUM, SOON AFTER STEPPING THE PEDAL, BRAKE THAT MESSAGE APPEARED ON THE ON-BOARD COMPUTER, THEN VEHICLE STOPPED WALKING. I WAS TRYING TO CALL AGAIN, TO PARK THE SAME INSIDE MY PARKING SPACE INSIDE THE CONDOMINIUM, STARTED TO MAKE A VERY LUCKY NOISE AND NOT CALLING, HAD TO MANEUVER THE VEHICLE WITHOUT STA…
Read full complaint
I WAS LEAVING MY CONDOMINIUM, SOON AFTER STEPPING THE PEDAL, BRAKE THAT MESSAGE APPEARED ON THE ON-BOARD COMPUTER, THEN VEHICLE STOPPED WALKING. I WAS TRYING TO CALL AGAIN, TO PARK THE SAME INSIDE MY PARKING SPACE INSIDE THE CONDOMINIUM, STARTED TO MAKE A VERY LUCKY NOISE AND NOT CALLING, HAD TO MANEUVER THE VEHICLE WITHOUT STARTING AND STILL CALL A WINCH, TO TAKE TO MY RELIABLE MECHANIC, THAT UNTIL TODAY WE CAN NOT FIND OUT WHAT THE PROBLEM IS THIS VEHICLE, WHENEVER WE PRESS THE BRAKE PEDAL, THE MESSAGE APPEARS AND DOES NOT START THE VEHICLE.
NHTSA ODI #11287022
Mileage unknown · Nov 24, 2019
Power TrainService Brakes
I HAVE 2015 JEEP CHEROKEE LATITUDE. SOMETIMES CHECK ENGINE LIGHT COMES ON AND THEN IS GONE AFTER FEW HOURS OR DAY. SOME TIMES MESSAGE BLINKING "SERVICE PARK BRAKE SERVICE TRANSMISSION" THEN LIKE SOMETHING WAS WRONG WITH SYSTEM DOES NOT SAVE CLOCK TIME OR A/C PUT ME ON HEATH AND AUTO LIGHT DOES NOT STAY ON. SOMETIMES WHEN I START…
Read full complaint
I HAVE 2015 JEEP CHEROKEE LATITUDE. SOMETIMES CHECK ENGINE LIGHT COMES ON AND THEN IS GONE AFTER FEW HOURS OR DAY. SOME TIMES MESSAGE BLINKING "SERVICE PARK BRAKE SERVICE TRANSMISSION" THEN LIKE SOMETHING WAS WRONG WITH SYSTEM DOES NOT SAVE CLOCK TIME OR A/C PUT ME ON HEATH AND AUTO LIGHT DOES NOT STAY ON. SOMETIMES WHEN I START THE CAR AND RELEASE THE PARK BARK BRAKE CAR JUMPS HARD TWO OR THREE TIMES AND AFTER I TURN ENGINE OFF WITHOUT USING PARKING BRAKE AND BACK ON EVERYTHING IS FINE.THE CAR ONLY HAS 55000 MILES. I'M SO AFRAID TO DRIVE CAR BECAUSE DON'T KNOW WHAT CAN HAPPENED
NHTSA ODI #11282068
Mileage unknown · Nov 19, 2019
Service Brakes
MY VEHICLE'S EMERGENCY BRAKE RELEASE CONTINUES TO REMAIN IN THE ON POSITION, PREVENTING ME FROM DRIVING MY CAR FROM TIME TO TIME, KILLING MY BATTERY POWER MULTIPLE TIMES-I HAVE REPLACED MY BATTERY TWICE IN THE LAST YEAR. I HAD THE JEEP DEALERSHIP IN WHITE BEAR MN CHARGE ME $185 FOR A DIAGNOSIS AND THE TELL ME I HAVE TO FULLY REP…
Read full complaint
MY VEHICLE'S EMERGENCY BRAKE RELEASE CONTINUES TO REMAIN IN THE ON POSITION, PREVENTING ME FROM DRIVING MY CAR FROM TIME TO TIME, KILLING MY BATTERY POWER MULTIPLE TIMES-I HAVE REPLACED MY BATTERY TWICE IN THE LAST YEAR. I HAD THE JEEP DEALERSHIP IN WHITE BEAR MN CHARGE ME $185 FOR A DIAGNOSIS AND THE TELL ME I HAVE TO FULLY REPLACE THE BRAKES CONTROL BOX WITH A COST OF MORE THAN $800 AND MENTIONED THE WARRANTY DOES NOT COVER THIS DUE TO THE TIME FRAME, BUT MY CONCERN HAS BEEN EXPRESSED SINCE I'VE OWN THE CAR IN 2015 AND ONLY HAVE 65,000 CURRENTLY ON THE CAR THAT I CAN NO LONGER DRIVE AND YET AFFORD TO FIX SINCE I AM A COLLEGE STUDENT. PLEASE HELP.
NHTSA ODI #11281172
57,000 miles · Nov 19, 2019
Electrical SystemPower TrainService Brakes
ELECTRONIC PARKING BRAKE MODULE CONNECTOR WATER INTRUSION WHICH CAUSES THE MODULE TO SHORT OUT AND THE WIRING HARNESS CORROSION. THIS CAUSES THE PARKING BREAK TO ENGAGE AND DISENGAGE WITHOUT WARNING. THIS ALSO PROMPTS AN ERROR THAT THE 4WD IS UNAVAILABLE. CONFIRMED WITH PATRIOT JEEP IN OAKLAND MD THAT THE 4WD WILL NOT WORK ON 11…
Read full complaint
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
NHTSA ODI #11281032
29,000 miles · Oct 23, 2019
Service Brakes
WHILE I WAS DRIVING HOME FROM SCHOOL, THE "SERVICE PARKING BRAKE" LIGHT CAME UP ON THE DASH. I PULLED OVER AND TURNED OFF THE ENGINE AND TURNED IT BACK ON. THE LIGHT DID NOT COME BACK ON, SO I DIDNT THINK IT WAS AN ISSUE. TWO DAYS LATER I GOT INTO MY CAR AND TURNED ON THE ENGINE AND THE LIGHT CAME ON AGAIN. THIS TIME I WAS NOT A…
Read full complaint
WHILE I WAS DRIVING HOME FROM SCHOOL, THE "SERVICE PARKING BRAKE" LIGHT CAME UP ON THE DASH. I PULLED OVER AND TURNED OFF THE ENGINE AND TURNED IT BACK ON. THE LIGHT DID NOT COME BACK ON, SO I DIDNT THINK IT WAS AN ISSUE. TWO DAYS LATER I GOT INTO MY CAR AND TURNED ON THE ENGINE AND THE LIGHT CAME ON AGAIN. THIS TIME I WAS NOT ABLE TO REMOVE THE EMERGENCY PARKING BRAKE. I HAD TO SEARCH ONLINE AND FOUND OUT THAT THE PARKING BRAKE AUTOMATICALLY COMES OFF IF YOU PUT YOUR SEAT BELT ON AND PUT THE VEHICLE INTO D OR R. SINCE THIS HAPPENED THE LEVER TO REMOVE THE PARKING BREAK WOULD NOT WORK AT ALL. EVERY TIME I PRESSED THE BUTTON, IT SAID SERVICE PARKING BRAKE. I ALSO READ ONLINE THAT A TSB WAS ISSUED FOR THIS PROBLEM. THE PROBLEM WAS THAT THE PARKING BRAKE MODULE IN THE REAR, AS WELL AS THE HARNESS NEEDED TO BE REPLACED SINCE IT WAS CORRODED. HOW WOULD SOMETHING THAT IS IN THE REAR OF THE VEHICLE, HIDDEN BEHIND THE SIDE PANELS GET CORRODED AND HAVE THE OWNER BE RESPONSIBLE FOR DAMAGES IF THIS IS SOMETHING THAT SHOULD BE PLACED IN A LOCATION WHERE IT CANNOT GET WET OR CORRODED.
NHTSA ODI #11270367
60,000 miles · Oct 15, 2019
Electronic Stability Control (esc)Power TrainService Brakes
WE BOUGHT A 2015 JEEP CHEROKEE IN 2016 AND WITHOUT BEING TOLD OF THE ISSUES WITH THE TRANSMISSIONS ISSUES. WE HAVE HAD OUR JEEP IN THE SHOP FOUR TIMES WITH TRANSMISSIONS ISSUES OF SHIFTING HARD AND NOW GOING INTO NEUTRAL WHEN IN DRIVE AND THE BRAKES GOING HARD AND THE JEEP COMING TO A STOP. THE ANIT SLIDE HAS NOW CAME ON AND THE…
Read full complaint
WE BOUGHT A 2015 JEEP CHEROKEE IN 2016 AND WITHOUT BEING TOLD OF THE ISSUES WITH THE TRANSMISSIONS ISSUES. WE HAVE HAD OUR JEEP IN THE SHOP FOUR TIMES WITH TRANSMISSIONS ISSUES OF SHIFTING HARD AND NOW GOING INTO NEUTRAL WHEN IN DRIVE AND THE BRAKES GOING HARD AND THE JEEP COMING TO A STOP. THE ANIT SLIDE HAS NOW CAME ON AND THE JEEP SHAKES . THE UPDATES CAME ONE DAY WHEN I WAS GETTING ONTO THE HIGHWAY GOING 65 MPH AND THE JEEP WENT TO 30 MPH WITH MY GRANDKIDS IN THE CAR AND TWO DISELS ONE BEHIND ME BLOWING THE HORN BECAUSE HE ALMOST HIT ME AND ONE TO THE SIDE OF ME. MY HUSBAND WAS COMING HOME FROM A DR VISIT AGAIN THE JEEP WENT INTO A NEUTRAL STATE WHILE IN THE DRIVE POSITION AND THE JEEP STOPPED AND HE WAS ALMOST HIT THEN THE JEEP JERKED AND WENT INTO GEAR SO HE WENT INTO A SHOPPING CENTER AND HAD TO STOP AND KILL THE JEEP AND RESTART THE JEEP TO MAKE THE JEEP RESTART JUST TO GET IT HOME. IT WENT BACK TO THE SHOP THAT NIGHT! WE HAVE HAD THE JEEP IN THE SHOP FOR HARD SHIFTING WHEN TAKING OFF AND NOW IT IS HARD SHIFTING WHEN TAKING OFF AND DOWN SHIFTING, ANTI SLIDE RANDOMLY COMES ON, BRAKES ARE NOT PROPERLY STOPPING THE CAR. GO TO THE DEALER WHERE WE BOUGHT IT AND THEY ONLY OFFERED $7500 FOR IT WHEN WE OWE $15, 000 AND THIS IS SO RIDICULOUS. CALLED JEEP AND AWAITING A CALL, THEY STATED THEY HAVE TO CALL THE DEALER. IN THE MEAN TIME I HAD TO BUY ANOTHER CAR BECAUSE OURS IS TO UNSAFE TO DRIVE! THE JEEP IS STICKING IN GEAR AND THE TAC METER IS STAYING ON 3 OR 4. THEN WHEN YOU TURN THE JEEP OFF AND TURN IT BACK ON IT MAY OR MAY NOT WORK. WE HAVE BACKED IT OUT OF OUR DRIVEWAY AND PUT INTO DRIVE AND IT SHIFTS SO HARD INTO FIRST AND SECOND GEAR. NOW SINCE THE LAST TIME WE PICKED IT UP FROM THE SHOP THE JEEP HAS NOW STARTED LOOSING POWER WHEN YOU ATTEMPT TO DRIVE. WE HAVE PARKED THE JEEP AND DECIDED IT ISN'T SAFE!
NHTSA ODI #11268641
52,000 miles · Oct 10, 2019
Electronic Stability Control (esc)EngineService Brakes
WAS DRIVING DOWN THE INTERSTATE AT 70MPH THE ENGINE ABRUPTLY SHUT OFF. THE DASHBOARD READ "SHIFT TO P THEN DESIRED GEAR". THIS HAS ALSO HAPPENED WHEN COMING TO A STOP. ATTEMPTING TO RESTART THE ENGINE CAUSES THE STARTER TO RUN FOR ABOUT 45 SECONDS AND THEN THE ENGINE WILL SLOWLY SPUTTER TO LIFE. THIS VEHICLE IS UNSAFE AND THERE …
Read full complaint
WAS DRIVING DOWN THE INTERSTATE AT 70MPH THE ENGINE ABRUPTLY SHUT OFF. THE DASHBOARD READ "SHIFT TO P THEN DESIRED GEAR". THIS HAS ALSO HAPPENED WHEN COMING TO A STOP. ATTEMPTING TO RESTART THE ENGINE CAUSES THE STARTER TO RUN FOR ABOUT 45 SECONDS AND THEN THE ENGINE WILL SLOWLY SPUTTER TO LIFE. THIS VEHICLE IS UNSAFE AND THERE ARE A MASSIVE AMOUNT OF COMPLAINTS ABOUT THIS SPANNING BACK OVER 4 YEARS.
NHTSA ODI #11267628
Official recalls
11May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Dec 9, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence & remedy
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Oct 19, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015 Jeep Cherokee vehicles manufactured October 1, 2014, to June 18, 2015. The affected vehicles may have a misrouted air conditioning suction/discharge hose.
Consequence & remedy
Consequence: If the line is misrouted, it may contact the exhaust manifold, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will inspect the routing of the air conditioning hose. Any hose that is misrouted will be replaced and installed correctly. This work will be performed free of charge. The recall began on November 23, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R57.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
PE15003 · Engine Compartment Fire
Opened Jan 13, 2015 · Closed Dec 9, 2015
Status: closed (inferred from source dates) · Engine; Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Additional source detail variants (2)
Engine
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Illustration