NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
1,002 reportsClear category filter5,000 miles · Feb 4, 2016
Power Train
2015 JEEP CHEROKEE LATITUDE. EXPERIENCING LUNGING "JOLT" WHEN GAS PEDAL IS "CAREFULLY" USED ESPECIALLY AFTER A STOP. SLIGHT BUT NOTICEABLE ACCELERATION WHILE COASTING OR BRAKING. PERIODIC UNUSUAL REVVING IN LOWER GEARS WHILE ACCELERATING. VEHICLE TAKEN TO THE DEALERSHIP FOR "FLASH" AND MULTIPLE RE-ASSESSMENT BUT DEALER STATES VE…
Read full complaint
2015 JEEP CHEROKEE LATITUDE. EXPERIENCING LUNGING "JOLT" WHEN GAS PEDAL IS "CAREFULLY" USED ESPECIALLY AFTER A STOP. SLIGHT BUT NOTICEABLE ACCELERATION WHILE COASTING OR BRAKING. PERIODIC UNUSUAL REVVING IN LOWER GEARS WHILE ACCELERATING. VEHICLE TAKEN TO THE DEALERSHIP FOR "FLASH" AND MULTIPLE RE-ASSESSMENT BUT DEALER STATES VEHICLE PERFORMS AS "DESIGNED". DEALERSHIP STATES MULTIPLE COMPLAINTS FOR THE SAME REASON BY OTHER CUSTOMERS. CASE WORKERS FROM FCA OFFERED TRANSMISSION WARRANTY EXTENSION FOR LIFE BUT RETRACTED OFFER AFTER IT WAS FOUND WE HAVE ALREADY PURCHASED EXTENDED WARRANTY. CASE WORKER THEN OFFERED 2 YEARS WORTH OF OIL CHANGES. THE OFFER WAS REFUSED SO COMPLAINT HAS BEEN CLOSED FOR THE SECOND TIME.
NHTSA ODI #10824159
3,000 miles · Jan 31, 2016
Power Train
TRANSMISSION SHIFTS VERY ROUGH WHEN SHIFTING FROM FIRST TO SECOND. SOMETIMES THE WHOLE VEHICLE WHICH SHAKE WHEN IT SHIFTS.
NHTSA ODI #10823332
10,000 miles · Jan 28, 2016
Power Train
UNDER ACCELERATION FROM A STOP (EITHER STRAIGHT LINE OR MAKING A RIGHT HAND TURN) THE RPMS INCREASE BEFORE THE VEHICLE RESPONDS. WHEN IT DOES, THE VEHICLE LUNGES FORWARD UNPREDICTABLY. DURING MANUAL SHIFTING AND BRAKING (WHILE IN MOTION) THE RPMS SHOOT UP TO BEFORE TRANSMISSION ENGAGES 4TH GEAR WHEN DOWNSHIFTING FROM 5TH CAUSING…
Read full complaint
UNDER ACCELERATION FROM A STOP (EITHER STRAIGHT LINE OR MAKING A RIGHT HAND TURN) THE RPMS INCREASE BEFORE THE VEHICLE RESPONDS. WHEN IT DOES, THE VEHICLE LUNGES FORWARD UNPREDICTABLY. DURING MANUAL SHIFTING AND BRAKING (WHILE IN MOTION) THE RPMS SHOOT UP TO BEFORE TRANSMISSION ENGAGES 4TH GEAR WHEN DOWNSHIFTING FROM 5TH CAUSING A MOMENTARY FREEWHEELING SCENARIO. DURING ACCELERATION FROM ABOUT 10-15 MPH THE VEHICLE ONCE AGAIN INCREASES RPMS AND THEN LUNGES FORWARD. THE VEHICLE PERFORMS HARD SHIFTING BETWEEN GEARS WHILE IN MOTION. AT FREEWAY SPEEDS THE TRANSMISSION MAY NOT DOWNSHIFT/ RESPOND OR ACCELERATE FOR 3-4 SECONDS. WHEN REVERSING THE THE SAME LUNGING SCENARIO OCCURS HOWEVER IT IS LESS PREDICABLE AS REVERSE GEAR IS TALLER. OVERALL PERFORMANCE IS SPORADIC AND UNPREDICTABLE.
NHTSA ODI #10822959
4,000 miles · Jan 26, 2016
Power Train
RMP'S SPIKE WHEN TRYING TO STOP LUNGING VEHICLE FORWARD, COASTING WITHOUT CRUISE CONTROL ON INTERSTATE AT 70 VEHICLE RPM'S JUMPED UP CAUSING IT TO INCREASE SPEED LUNGING FORWARD TO 80 MPH AS IF ACCELERATOR IS PUSHED, LETTING OFF GAS TO SLOW DOWN VEHICLE WILL LUNGE FORWARD AS IF YOU WERE APPLYING GAS AND RPM'S JUMP UP, IF FOOT IS…
Read full complaint
RMP'S SPIKE WHEN TRYING TO STOP LUNGING VEHICLE FORWARD, COASTING WITHOUT CRUISE CONTROL ON INTERSTATE AT 70 VEHICLE RPM'S JUMPED UP CAUSING IT TO INCREASE SPEED LUNGING FORWARD TO 80 MPH AS IF ACCELERATOR IS PUSHED, LETTING OFF GAS TO SLOW DOWN VEHICLE WILL LUNGE FORWARD AS IF YOU WERE APPLYING GAS AND RPM'S JUMP UP, IF FOOT ISN'T ON BREAK YOU WOULD HIT SOMEONE, VERY UNSAFE TO DRIVE AND HAS ALREADY ALMOST CAUSED ME TO HIT SOMEONE 4 TIMES. DOESN'T DO IT ALL THE TIME IT AND IS INTERMITTENT. PROBLEM HAS OCCURRED APPROXIMATELY 6 TIMES. HAS BEEN TO DEALER OVER 30 DAYS AND ONLY HAS 5,000 MILES ON IT. THEY SAY CAN'T DUPLICATE THE PROBLEM. VERY UNSAFE TO DRIVE AND NO ONE WANTS TO FIX PROBLEM. STARTED HAPPING AT 2,000 MILES.
NHTSA ODI #10822250
7,000 miles · Jan 21, 2016
Power TrainFire
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING 60 MPH, THE VEHICLE WOULD NOT CHANGE GEARS WHEN PROMPTED AND WOULD NOT ACCELERATE. IN ADDITION, THERE WAS AN ODOR OF BURNING RUBBER AND A CLICKING NOISE FROM THE TRANSMISSION. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. WHILE DRIVING 60 MPH, THE VEHICLE WOULD NOT CHANGE GEARS WHEN PROMPTED AND WOULD NOT ACCELERATE. IN ADDITION, THERE WAS AN ODOR OF BURNING RUBBER AND A CLICKING NOISE FROM THE TRANSMISSION. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 7,000.
NHTSA ODI #10821551
980 miles · Jan 14, 2016
EnginePower Train
I WAS BACKING UP MY DAUGHTERS DRIVEWAY. HER DRIVEWAY IS A LITTLE STEEP AND WHEN I WENT TO GIVE THE JEEP MORE GAS THE RPMS DROPPED FROM 1500 TO IDLE AND THEN BACK TO 1500 RPMS REALLY QUICK, IT DID THIS A COUPLE TIMES. THE DOG ENDED UP ON THE FLOOR OF THE CAR, FRIENDS STANDING OUTSIDE THE CAR THOUGH I DIDN'T KNOW HOW TO DRIVE. I…
Read full complaint
I WAS BACKING UP MY DAUGHTERS DRIVEWAY. HER DRIVEWAY IS A LITTLE STEEP AND WHEN I WENT TO GIVE THE JEEP MORE GAS THE RPMS DROPPED FROM 1500 TO IDLE AND THEN BACK TO 1500 RPMS REALLY QUICK, IT DID THIS A COUPLE TIMES. THE DOG ENDED UP ON THE FLOOR OF THE CAR, FRIENDS STANDING OUTSIDE THE CAR THOUGH I DIDN'T KNOW HOW TO DRIVE. I FINALLY HAD TO TURN THE JEEP AROUND AND GO UP HER DRIVEWAY IN THE FORWARD DIRECTION. WE WENT OUT TO EAT LATER AND WHEN I CAME BACK I TRIED BACKING UP HER DRIVEWAY AGAIN AND IT DID THE SAME THING. I TOOK THE JEEP INTO THE DEALER ON 6/29/15 WITH 990 MILES ON IT. THE DEALER UPDATED THE PCM AND TCM AND RETESTED IT BUT COULD NOT GET IT TO FAIL. IT FAILED AGAIN ABOUT 3 MONTHS LATER ON LABOR DAY WEEKEND, 2015. AGAIN BACKING UP MY DAUGHTERS DRIVEWAY. I CONTACTED THE JEEP SERVICE MANAGER AND HE SAID THEY PROBABLY CAN'T FIX IT IF IT DOESN'T SET A CODE. (GREAT) THE JEEP HASN'T FAILED BACKING UP AGAIN BUT IT DID FAIL ON THE HIGHWAY AT 65 MILES PER HOUR COMPLETELY SHUTTING DOWN AND NOT RESTARTING. (SEE COMPLAINT #10819212) LIKE OTHER JEEP OWNERS I'VE NOTICED THE JEEP STAYS IN THIRD GEAR TO LONG AT LOW SPEED, ESPECIALLY IF YOU HAVE TO MAKE A LEFT TURN IN FRONT OF ON COMING TRAFFIC. I'VE RESORTED TO DOWN SHIFTING THE TRANSMISSION MYSELF SO I CAN HAVE SOME POWER TO MAKE THE TURN WITHOUT GETTING HIT. ( NOTE TO CHRYSLER, I'M A FIRST TIME JEEP BUYER, KEEP DOING NOTHING ABOUT THE ENGINE AND TRANSMISSION PROBLEMS AND YOU CAN FIND YOUR JEEP AT A FORD OR CHEVY DEALERSHIP.......REAL SOON).
NHTSA ODI #10820341
Mileage unknown · Jan 13, 2016
EnginePower Train
MY TRANSMISSION HAS BEEN SLIPPING SINCE I PURCHASED THE VEHICLE A YEAR AGO, (12-28-15) APPX, THEY SAID THEY FIXED THE PROBLEM, BUT IT HAS RECENTLY BECAME WORSE THAT IT WAS ORIGINALLY. WHEN I'M STOPPED AND THEN BEGIN TO START GOING AGAIN THE CAR HESITATES FOR ABOUT 3-5 SECONDS THEN IT JERKS AND GOES. IT ALSO SEEMS TO DOWNSHIFT …
Read full complaint
MY TRANSMISSION HAS BEEN SLIPPING SINCE I PURCHASED THE VEHICLE A YEAR AGO, (12-28-15) APPX, THEY SAID THEY FIXED THE PROBLEM, BUT IT HAS RECENTLY BECAME WORSE THAT IT WAS ORIGINALLY. WHEN I'M STOPPED AND THEN BEGIN TO START GOING AGAIN THE CAR HESITATES FOR ABOUT 3-5 SECONDS THEN IT JERKS AND GOES. IT ALSO SEEMS TO DOWNSHIFT ON ITS OWN OR NOT AT ALL.
NHTSA ODI #10819994
17,000 miles · Jan 12, 2016
Power Train
THERE HAVE BEEN SEVERAL INSTANCES OF SLOW RESPONSE FROM THE TRANSMISSION. HEADING SOUTH AT A HIGHWAY INTERSECTION WHERE CROSS TRAFFIC DOES NOT STOP, I WAITED AT THE STOP SIGN UNTIL TRAFFIC WAS CLEAR TO THE EAST. I PRESSED THE ACCELERATOR AND DIDN'T GET MUCH RESPONSE UNTIL TRAFFIC WAS CLOSE ENOUGH THAT I DEBATED ABOUT NOT CROSS…
Read full complaint
THERE HAVE BEEN SEVERAL INSTANCES OF SLOW RESPONSE FROM THE TRANSMISSION. HEADING SOUTH AT A HIGHWAY INTERSECTION WHERE CROSS TRAFFIC DOES NOT STOP, I WAITED AT THE STOP SIGN UNTIL TRAFFIC WAS CLEAR TO THE EAST. I PRESSED THE ACCELERATOR AND DIDN'T GET MUCH RESPONSE UNTIL TRAFFIC WAS CLOSE ENOUGH THAT I DEBATED ABOUT NOT CROSSING AND THE CAR SUDDENLY MOVED INTO THE LANES OF TRAFFIC. I WAS ABLE TO CROSS TO THE DIVIDER BEFORE BEING BROADSIDED BECAUSE TRAFFIC SLOWED FOR ME. ANOTHER INCIDENT INVOLVES PULLING OUT OF MY DRIVEWAY. I LIVE ON A MAJOR HIGHWAY SO I AM VERY CAUTIOUS WHEN I PULL OUT. AS I TURNED RIGHT FROM MY DRIVEWAY MY CAR DIDN'T DO MORE THAN CREEP ALONG EVEN THOUGH IT HAD GONE DOWN THE DRIVE JUST FINE. I GOT THE RPM UP TO 6 ON THE GAUGE (7 IS RED) WHEN IT SUDDENLY "CAUGHT" AND TOOK OFF. A CAR THAT HAD BEEN A LONG DISTANCE BACK CAME VERY CLOSE TO REAR-ENDING ME. ON ANOTHER OCCASION AS I PULLED UP BEHIND A CAR AT A LIGHT, MY CAR WAS STOPPING AND THEN SUDDENLY LURCHED FORWARD BEFORE COMING TO A COMPLETE STOP. I HADN'T STOPPED BRAKING OR PUSHED THE ACCELERATOR. I WOULD HAVE HIT THE CAR IN FRONT OF ME IF I HADN'T BEEN LEAVING A FAIR AMOUNT OF ROOM BETWEEN US. THE VARIABILITY AND UNPREDICTABILITY OF THIS CAR IS WHAT MAKES IT SO DANGEROUS. IT HAS SMALL ISSUES LIKE DIFFICULTY CLIMBING HILLS ON OCCASION OR JUMPING WHEN IT SHIFTS DURING NORMAL DRIVING BUT I HAVE CHANGED MY ROUTES (CHOOSE STOPLIGHTS TO CROSS HIGHWAYS) AND DRIVING STYLE (LEAVE LOTS OF ROOM BETWEEN IT AND OTHER CARS) TO ACCOMMODATE DAILY INCONVENIENCE.
NHTSA ODI #10819842
3,200 miles · Jan 7, 2016
Power Train
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. THE CONTACT STATED THAT THE VEHICLE SHIFTED INTO THIRD GEAR AND DOWNSHIFTED TO THE NEXT GEAR ON ITS OWN. THE VEHICLE ALSO JERKED WHILE DRIVING 30 MPH WITHOUT WARNING. IN ADDITION, WHEN THE ACCELERATOR PEDAL WAS ENGAGED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS NOT DIAGNOSED OR …
Read full complaint
TL* THE CONTACT OWNS A 2015 JEEP CHEROKEE. THE CONTACT STATED THAT THE VEHICLE SHIFTED INTO THIRD GEAR AND DOWNSHIFTED TO THE NEXT GEAR ON ITS OWN. THE VEHICLE ALSO JERKED WHILE DRIVING 30 MPH WITHOUT WARNING. IN ADDITION, WHEN THE ACCELERATOR PEDAL WAS ENGAGED, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE TRANSMISSION CONTROL MODULE WAS UPDATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 3,200. ...UPDATED 02/03/16 *BF THE CONSUMER STATED THE DEALER REPLACED THE TRANSMISSION CONTROL AND WIRING HARNESS. THE CONSUMER STATED THE VEHICLE WAS A LITTLE BETTER, BUT THERE WAS STILL SOME HARD SHIFTING AND THE DOWN SHIFTING FROM 5TH TO 1ST WAS SLOW AND SOMETIMES NON-EXISTENT. UPDATED 02/09/16*JB
NHTSA ODI #10818737
138 miles · Jan 7, 2016
Power Train
DANGEROUS 2015 JEEP CHEROKEE LATITUDE WITH 853 MILES. FIRST WEEK OF OWNERSHIP I NOTICED A VERY ODD SHIFTING WERE THE JEEP WOULD LUNG FORWARD FROM 1ST TO 2ND GEAR AT ABOUT 5MPH, HARD SHIFTS, AND WAS STRUGGLING TO FIND GEARS AT 35-40MPH ALONG WITH A NONRESPONSIVE GAS PEDAL THAT SPOOKED ME DURING MANY ACCELERATION INSTANCES OF SLOW…
Read full complaint
DANGEROUS 2015 JEEP CHEROKEE LATITUDE WITH 853 MILES. FIRST WEEK OF OWNERSHIP I NOTICED A VERY ODD SHIFTING WERE THE JEEP WOULD LUNG FORWARD FROM 1ST TO 2ND GEAR AT ABOUT 5MPH, HARD SHIFTS, AND WAS STRUGGLING TO FIND GEARS AT 35-40MPH ALONG WITH A NONRESPONSIVE GAS PEDAL THAT SPOOKED ME DURING MANY ACCELERATION INSTANCES OF SLOW SPEEDS AND HIGHWAY SPEEDS. TOOK INTO THE DEALERSHIP WHERE I BOUGHT IT FROM AND EXPLAINED WHAT WAS BEING EXPERIENCED, WITH THE BACK UP CAMERA BEING SATURATED WITH LIGHT, AND GAS DOOR THAT WAS NOT ALIGNED WITH THE BODY. THEY CHECKED FOR CODES BUT A SERVICE LIGHT NEVER APPEARED. WAS TOLD THERE WERE UPDATES THAT NEED TO BE INSTALLED. AFTER THE UPDATE,WHICH I ASSUMED WAS A POWER TRAIN UPDATE FOR THE TRANSMISSION. LEFT DEALERSHIP AND IT ALL STARTED HAPPENING AGAIN WITH THE TRANSMISSION. SO WAS TOLD BY A SERVICE REP NEED TO LET THE TRANSMISSION LEARN MY DRIVING HABITS WHITH NO HARSH ACCELERATION BECAUSE OF THE 350 MILE BREAKIN PERIOD. DROVE FOR A WHILE TOO SEE IF IT WOULD SMOOTH OUT. NOPE IT DIDN'T IT STARTED HAVING AN ODD FEELING WHEN PUT IN DRIVE AND MOVING FORWARD LIKE THE CLUTCHS IN THE TRANSMISSION WERE SLIPPING WHICH GIVES THE SENSATION OF WOBBLE VIBRRATION. RETURNED IT BACK TO THE DEALERSHIP AGAIN FOR SECOND TIME DUE TO WHEN IN THE MID DEL OF AN INTERSECTION WHILE MAKING A LEFT TURN WITH APPROPRIATE THROTTLE APPLIED IT SUDDENLY LOSS POWER WITH TRAFFIC COMING FROM OPPOSITE DIRECTION SO I HAD TO WOT THE GAS PEDAL TO GET IT TO MOVE THEN IT RESPONDED WITH ME OVER ACCELERATING INTO A TURN AND IMMEDIATELY GOT OFF THE GAS AND HAD TO APPLY BRAKE PRESSURE AND CONTROL STEERING. IT HAPPENDED QUIET A FEW TIMES BEFORE I FINALLY GOT FRUSTRATED WITH IT AND RETURNED TO DEALER FOR SERVICE 3RD TIME. WAS TOLD COULDN'T DUPLICATE,SO THEY CAN'T FIX IT. FILED COMPLAINT WITH FCA FOR REMEDY. THIS JEEP MAKES ME FEAR DRIVING IT.
NHTSA ODI #10818579
Official recalls
11May 11, 2023
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US, LLC) is recalling certain 2014-2016 Jeep Cherokee vehicles equipped with a power liftgate. An electrical short in the power liftgate module may lead to a vehicle fire with the ignition on or off.
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will relocate the power liftgate module and add a water shield. In addition, dealers will inspect for corrosion and replace the module and electrical connectors, if necessary. Repairs will be performed free of charge. Owner letters were mailed March 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 49A. This recall supersedes recalls 15V-393 and 15V-826. Vehicles repaired under the prior recalls will still need to have the new remedy performed.
Jun 11, 2020
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence & remedy
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Additional source detail variants (2)
Power Train:automatic Transmission
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
Power Train:driveline:differential Unit
Chrysler (FCA US LLC) is recalling certain 2014-2017 Jeep Cherokee vehicles equipped with a two-speed Power Transfer Unit (PTU). Relative movement in the Power Transfer Unit (PTU) between the differential input splines and the transmission output shaft may cause some input spline teeth to wear off, which may eventually cause a loss of engagement between the transmission and the differential inside the PTU. If this occurs, power cannot be transferred between the front wheels and the transmission which results in a loss of drive while the vehicle is in motion and a loss of the Park function while stationary.
Consequence: A loss of drive can cause a vehicle crash without prior warning. A loss of the Park function can cause unintended vehicle rollaway which can increase the risk of a crash or injury.
Remedy: FCA US LLC will notify owners, and dealers will perform a software update that will maintain vehicle propulsion by engaging rear wheel drive and prevent rolling in Park by activating the electronic parking brake if a failed input spline occurs. This recall began July 14, 2020. Owners may contact FCA USA LLC customer service at 1-800-853-1403. FCA's number for this recall is W47.
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Dec 21, 2017
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Consequence & remedy
Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.
Aug 10, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence & remedy
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Additional source detail variants (2)
Seats:mid/rear Assembly
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Seats
Chrysler (FCA US LLC) is recalling certain model year 2014-2016 Jeep Cherokee vehicles manufactured July 29, 2013, to February 5, 2016. The seat fasteners on the first or second row seats may not have been tightened to the proper torque specification.
Consequence: Loose fasteners may allow the seats to move, increasing the risk of injury to the seat occupants in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the seats or seat sets, free of charge. The recall is expected to begin during September 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall S63.
Jul 12, 2016
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee and 2015 Chrysler 200, Jeep Renegade, RAM ProMaster, and 2016 Fiat 500X vehicles equipped with 9-speed automatic transmissions. The transmission sensor clusters may have insufficient crimps in the transmission wire harness, and as a result, the transmission may unexpectedly shift to neutral. On August 29, 2016 Chrysler added the 2016 Fiat 500X vehicles to this recall.
Consequence & remedy
Consequence: If the vehicle unexpectedly shifts to neutral, there is an increased risk of a crash.
Remedy: Chrysler will notify owners, dealers will reprogram the Powertrain Control Module and the Transmission Control Module and if necessary replace the transaxle range sensor wire harness, free of charge. The recall began on November 7, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S55.
Dec 9, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence & remedy
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Additional source detail variants (2)
Structure:body:hatchback/liftgate
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Electrical System:wiring: Rear Compartment/trunk
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Jeep Cherokee vehicles manufactured February 18, 2015, to September 10, 2015 and equipped with the power liftgate option. In the affected vehicles, water may leak into the Power Liftgate Control Module and result in a high resistance short circuit.
Consequence: A short circuit in the module increases the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the module and connectors for corrosion, replacing the damaged components as necessary. The mastic shield will be removed and the module will be covered with a water shield. These repairs will be performed free of charge. The recall began on February 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R67. This recall is superseded by NHTSA recall 23V-338.
Oct 19, 2015
Chrysler (FCA US LLC) is recalling certain model year 2015 Jeep Cherokee vehicles manufactured October 1, 2014, to June 18, 2015. The affected vehicles may have a misrouted air conditioning suction/discharge hose.
Consequence & remedy
Consequence: If the line is misrouted, it may contact the exhaust manifold, increasing the risk of a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will inspect the routing of the air conditioning hose. Any hose that is misrouted will be replaced and installed correctly. This work will be performed free of charge. The recall began on November 23, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R57.
Jul 23, 2015
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Consequence & remedy
Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.
Jun 22, 2015
Chrysler (FCA US LLC) is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 4, 2013, to February 18, 2015 and equipped with a Power Liftgate option. In the affected vehicles, water may enter the Power Liftgate Control Module and cause a high resistance short circuit in the module.
Consequence & remedy
Consequence: A short circuit in the liftgate control module may result in a fire.
Remedy: Chrysler will notify owners, and dealers will inspect the power liftgate control module and connectors for corrosion, substitute a bolt for the threaded grommet installed to seal an attachment point used in non-power liftgate vehicles and cover the power liftgate control module in a foam water shield, free of charge. The recall began on October 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R27. This recall is superseded by NHTSA recall 23V-338.
Jan 28, 2015
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence & remedy
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Additional source detail variants (2)
Air Bags:side/window:curtain
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Air Bags:side/window
Chrysler is recalling certain model year 2014-2015 Jeep Cherokee vehicles manufactured January 1, 2013, to November 19, 2014. The affected vehicles may experience unintended side curtain and seat air bag deployment during vehicle operation.
Consequence: If the air bags deploy unexpectedly during vehicle operation, it can increase the risk of personal injury and increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will re-flash the occupant restraint control module software, free of charge. The recall began on March 4, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE22009 · Electronic Parking Brake Water Ingress
Opened Jul 22, 2022 · Closed Oct 29, 2023
Status: closed (inferred from source dates) · Parking Brake:electrical; Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Parking Brake:electrical
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Parking Brake:electrical:control Module
The Office of Defects Investigation (ODI) opened investigation PE22-009 after having received 80 complaints on model years 2014-2020 Jeep Cherokees alleging the Electronic Parking Brake (EPB) inadvertently activated while the vehicle was in motion.During this investigation, the subject vehicles were updated to include only Model Years (MY) 2014-2016, while MY 2017-2020 were considered peers.Based on related repair invoices, ODI believed the EPB module was damaged by water leaking into the vehicle. When the EPB inadvertently activates, it can cause a stalling condition bringing the vehicle to a stop. ODI was aware of recall 15V-393 that addresses water ingress affecting the power liftgate module on nearly the same population of vehicles subject of this investigation. The liftgate module can potentially catch fire as a result of the water damage. Both the liftgate and EPB modules are located in a similar area of the vehicle. On May 11, 2016, the manufacturer released a Technical Service Bulleting (ODI #10191415, FCA #08-060-16) that instructs dealers on replacing the EPB module and inspecting the electrical connector for corrosion if a customer describes having the EPB not releasing. This Preliminary Evaluation was opened to assess the scope, frequency, and safety-related consequences of the alleged defect. On September 8th, 2022, ODI sent an information request letter to Fiat Chrysler US LLC (FCA) requesting pertinent information on the subject 2014-2016 Jeep Cherokee and Peer 2017-2020 Jeep Cherokee vehicles. FCA Provided its full response on October 27th, 2022 after ODI granted a one-week extension. ODI has reviewed the information FCA provided as well as new reports submitted to NHTSA’s Vehicle Owner Questionnaire database. Based on a review of all available information, ODI has identified evidence supporting a total of 1,655 subject vehicles that likely experienced a failure of the subject EPB. Within the subject vehicle complaints, ODI identified the 2014 Model Year (MY) Jeep Cherokee as having the highest rate of failure, while also being the oldest group of vehicles in this investigation. The 2014 Jeep Cherokees that likely experienced a failure of the subject EPB represent an incident rate of approximately 0.58%. The average Time In Service (TIS) at failure was 2.6 years and the oldest failure occurred at 8.5 years in service. The 2014 population of vehicles is at 9 years in service. All other MY Jeep Cherokee vehicles (both subject and peer) within this investigation had significantly lower failure rates than the 2014 MY Jeep Cherokee. ODI has reviewed all the information available at this time, and identified four allegations of a crash, three allegations of injuries, and one allegation of a fire.Two of the crash allegations alleged injuries, and the alleged injuries were minor severity.All of the alleged injuries appeared to be consistent with hard braking and did not need medical attention. There was no supporting information that demonstrated a fire had occurred on the vehicle. In its response to ODI, FCA provided its assessment of the alleged defect in the subject vehicles, stating that it does not believe the alleged defect poses an unreasonable risk to motor vehicle safety. FCA states the majority of incidents involving the EPB inadvertently activating occurred while the vehicle was stationary and that a small number of incidents occurred while the vehicle was backing up or at low speeds. This is consistent with ODI’s observations. Based on the analysis conducted by ODI, this investigation will be closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. NHTSA reserves the right take additional actions if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
RQ15004 · Software Security Vulnerability
Opened Jul 24, 2015 · Closed Jan 5, 2016
Status: closed (inferred from source dates) · Electrical System:software
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015 letter, FCA submitted a second Part 573 safety recall report expanding the scope of the Uconnect RA4 model radio to include additional 7,810 MY 2015 Jeep Renegade vehicles manufactured from September 18, 2014 through June 25, 2015 (Recall 15V-508).Scope analysis indicated that Uconnect radios installed in FCA vehicles not included in recalls 15V-461 or 15V-508 (subject recalls) are not equipped with built-in cellular access or short range wireless communication features and, thus, do not contain the security vulnerabilities addressed by the subject recalls. SUBJECT VEHICLES: MY2014 through 2015 Dodge Durango, Jeep Grand Cherokee and Jeep Cherokee sport utility vehicles; MY2013 through 2015 Ram 1500, 2500, 3500 and 4500/5500 pickup trucks; MY2013 through 2015 Dodge Viper vehicles; and MY2015 Chrysler 200, 300, Jeep Renegade, Dodge Charger and Challenger vehicles.According to FCA, long and short range wireless vulnerabilities identified in the recalled vehicles could allow unauthorized third-party access to, and manipulation of, networked vehicle control systems.Successful exploitation of the vulnerabilities, coupled with reverse engineering of networked microprocessor control modules, could result in unauthorized manipulation of vehicle control systems. This unauthorized manipulation of vehicle controls and systems could expose the driver, vehicle occupants or other highway users to an increased risk of injury.FCA and its network provider, Sprint, conducted a nationwide campaign to block access to a radio communications port that was unintentionally left open.On July 27, 2015, short range wireless vulnerabilities were also blocked.Finally, third party security evaluation and regression testing identified vulnerabilities that were either remedied by Sprint or through updates to the FCA Uconnect software.ODI identified a total of 30 complaints or field reports on unique vehicles submitted by FCA (29) or received by NHTSA (1) alleging incidents of theft from a vehicle or anomalous performance that the owner alleged were caused by, or may have been caused by, remote hacking.Twenty-six (87%) of these reports were submitted after a magazine article was published on July 21, 2015, describing the remote hacking of an FCA vehicle by researchers who were able to affect the operation of various vehicle control systems, including the service brakes, steering, throttle and ignition.Most of the complaints involved vehicle systems that were not safety critical (e.g., complaints related to radio, navigation system, or air-conditioning control) and did not affect vehicle control.Three complaints reported engine stalls.One owner reported sudden unintended acceleration allegedly related to hacking.None of the complaints or field reports reviewed involved the steering and braking vehicle control effects demonstrated by the research hackers prior to the recall.There were no confirmed incidents of hacking in any of the records reviewed by ODI.The remedies completed by Sprint and FCA appear to have eliminated vulnerabilities that mi
PE15003 · Engine Compartment Fire
Opened Jan 13, 2015 · Closed Dec 9, 2015
Status: closed (inferred from source dates) · Engine; Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Additional source detail variants (2)
Engine
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Equipment:appliance:air Conditioner
On October 15, 2015, Fiat Chrysler Automobiles, US LLC, (FCA), submitted a Defect Information Report (DIR) to NHTSA regarding an air-conditioning suction/discharge combo line routing condition that may result in engine compartment fire in approximately 75,574 model year (MY) 2015 Jeep Cherokee vehicles equipped with 2.4L engines and built from October 1, 2014 through June 18, 2015 (NHTSA Recall 15V-676, FCA Recall R57).According to FCA's DIR, a misrouted A/C combo line can be pinched and cut or thermally degraded by the exhaust manifold heat shield, potentially resulting in loss of air conditioning, smoke and/or fire from ignition of leaked A/C refrigerant oil onto a hot exhaust manifold.The recalled vehicles will be inspected for misrouted A/C combo lines and those found to be misrouted will be replaced.FCA estimates that one percent of the recalled population may be affected by the A/C combo line routing defect.ODI?s analysis of warranty data provided by FCA in response to the information request letter for PE15-003 identified a spike in claims related to the A/C combo line leakage in vehicles equipped with 2.4L engines built after October 1, 2014.FCA implemented its final process corrective action for the hose routing concern on June 18, 2015.The 113,034 MY 2015 Jeep Cherokee vehicles equipped with 3.2L engines have different A/C line routing configurations and are not affected by the A/C combo line routing defect.FCA provided a total of 220 warranty claims potentially related to the A/C combo line in vehicles equipped with 2.4L engines.Ninety-five percent of the claims (210) involved the 74,574 Jeep Cherokee 2.4L vehicles built during the recall period.Only 10 A/C combo line claims and no related fires were identified in the 28,250 Jeep Cherokee 2.4L vehicles that were built before or after the period with the hose routing concern.Analysis of engine compartment fires reported to ODI and FCA identified a total of 10 fires in MY 2015 Jeep Cherokee vehicles.Nine (9) of the fires involved vehicles equipped with 2.4L engines and 8 of these involved vehicles built during the production range subject to Recall 15V-676.These include 5 fires that FCA's investigations determined were most likely caused by the A/C combo line and 3 fires of unknown cause originating in the area of the exhaust manifold heat shield, resulting in fire incident rates in the recall population of 6.6 per 100,000 vehicles for the A/C combo line condition and 10.6 per 100,000 vehicles for fire incidents for which the A/C combo line could not be excluded as the cause.The other 2 engine compartment fires involved a low-mileage fire of unknown cause in a vehicle equipped with a 3.2L engine and a minor self-extinguished fire that FCA?s investigation attributed to a lower transmission oil cooler (TOC) line connection seepage condition in a rental vehicle equipped with a 2.4L engine and built prior to the recall production range. This preliminary evaluation is closed based on FCA?s recall.The following VOQ numbers are associated with the issues discussed in this closing resume: A/C combo line failure:10786287 Unknown cause:10712350, 10678215, 10672201
Illustration